Cornelius 300026000 Manual de usuario

IMI Cornelius Inc. 1982-88 Revised: February 17, 1988

August 23, 1982

300099001

IMI CORNELIUS INC.

One Cornelius Place

Anoka. MN 55303-6234

Telephone (800) 238–3600

Facsimile (612) 422–3246

INSTALLATION KITS (P/N 300025000), (P/N 300025200),

(P/N 300026000), (P/N 300026200), (P/N 300388000) AND

(P/N 300388200) ON PRESSURIZED LIQUID-BASE

BEVERAGE DISPENSERS

Read and understand these instructions thoroughly before installing this kit. Retain these instructions as part of

your Service Manual.

NITROGEN GAS

CHECK VALVE

NITROGEN GAS

CYLINDER

DISPENSER

CONCENTRATE

TANK

WATER INLET

LINE CONNECTION

QUICK

DISCONNECT (2)

FIGURE 1. ONE-FLAVOR INSTALLATION KIT (P/N 300025000 OR P/N 300025200)

300099001 2

NITROGEN GAS

CHECK VALVE (2)

NITROGEN GAS

CYLINDER

DISPENSER

CONCENTRATE

TANK (2)

WATER INLET

LINE CONNECTION

QUICK

DISCONNECT (4)

FIGURE 2. TWO-FLAVOR INSTALLATION KIT (P/N 300026000 OR 300026200)

NITROGEN GAS

CHECK VALVE (4)

NITROGEN GAS

CYLINDER

GEMINI TWO-FLAVOR

DISPENSING VALVE (2)

DISPENSER

CONCENTRATE

TANK (4)

WATER INLET

LINE CONNECTION

QUICK

DISCONNECT (8)

1234

FIGURE 3. FOUR-FLAVOR INSTALLATION KIT (P/N 300388000 OR P/N 300388200)

3300099001

Kits Part Numbers and Their Part Quantities

Item-

No. Part

No. Name 300025000 300025200 300026000 300026200 300388000 300388200

1 183405000 Nitrogen Gas Regulator

Ass’y 111111

2 183301100 Check Valve 11––––

3 178025100 Tapered Gasket, White 335599

4 176090136 Gas Line Ass’y (with ball-

lock quick disconnect) 1–2–4–

178151136 Gas Line Ass’y (with pin-

lock quick disconnect) –1–2–4

5 176103148 Product Line Ass’y (with

ball-lock quick discon-

nect)

1–2–4–

178150148 Product Line Ass’y (with

ball-lock quick discon-

nect)

–1–2–4

6 183302100 Manifold Ass’y ––11––

183304100 Manifold Ass’y –––––1

IMPORTANT: Only qualified personnel should install this kit.

1. Unpack and inspect kit. Make sure all items are present and in good condition.

2. One Flavor Kit. (see Figure 1)

Install CHECK VALVE (item 2) in NITROGEN GAS REGULATOR ASS’Y (item 1) outlet. Use pipe thread

sealing compound to seal connection.

Two and Four–Flavor Kits. (see Figure 2 or 3)

Install MANIFOLD ASS’Y (item 6) in NITROGEN GAS REGULATOR (item 1) outlet. Use pipe thread seal-

ing compound to seal connection.

3. One-Flavor Kit. (see Figure 1)

A. Connect GAS LINE ASS’Y (item 4) to check valve installed in nitrogen gas regulator assembly. Seal

connection with TAPERED GASKET, WHITE (item 3).

B. Route, but do not connect, other end of gas line with quick disconnect on its end to concentrate tank

location.

C. Connect PRODUCT LINE ASS’Y (item 5) to 1/4-inch flare (7/16-20) concentrate inlet fitting on back of

dispenser. Seal connection with TAPERED GASKET, WHITE (item 3).

D. Route other end of product line, with quick disconnect on its end, to concentrate tank location.

300099001 4

Two and Four-Flavor Kits. (see Figure 2 or 3)

E. Connect GAS LINES ASSEMBLIES (item 4) to check valves on manifold assembly installed in nitro-

gen gas regulator assembly outlet. Seal connections with TAPERED GASKETS, WHITE (item 3).

F. Route, but do not connect, other ends of gas lines with quick disconnects on their ends to concentrate

tanks location.

G. Connect PRODUCT LINES ASSEMBLIES (item 5) to 1/4-inch flare (7/16-20) concentrate inlet fittings

on back of the Dispenser. Seal connections with TAPERED GASKETS, WHITE (item 3).

H. Route other ends of product lines, with quick disconnects on their ends, to concentrate tanks location.

4. Connect nitrogen gas pressure regulator and lines assembly to nitrogen gas cylinder as instructed in Ser-

vice Manual provided with the Dispenser.

5. Complete Dispenser installation as instructed in Service Manual provided with the Dispenser.

IMPORTANT: Nitrogen gas check valves (see applicable Figure 1, 2, or 3) must be inspected and

serviced at least once a year as instructed in Service Manual provided with the Dispenser.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Dispensador de bebidas de Cornelius

Cornelius

Cornelius Enduro 200 Manual de usuario

Cornelius

Cornelius Cornelius VANTAGE POST-MIX DISPENSER Manual de usuario

Cornelius

Cornelius ENDURO 250 Manual de usuario

Cornelius

Cornelius ED 300 BC Manual de usuario

Cornelius

Cornelius DF250 Manual de usuario

Cornelius

Cornelius V4 Instrucciones de funcionamiento

Cornelius

Cornelius R-404A REFRIGERANT Manual de usuario

Cornelius

Cornelius QUEST ELITE 4000 Manual de usuario

Cornelius

Cornelius Quest Juice Dispenser Manual de usuario

Cornelius

Cornelius remcor DB275--BCP Manual de usuario

Cornelius

Cornelius IDC 255 Manual de usuario

Cornelius

Cornelius ED-300 Guía de configuración

Cornelius

Cornelius FCB V2 Especificaciones

Cornelius

Cornelius FlavorFusion 255 Manual de usuario

Cornelius

Cornelius SPIRIT 414384-XXX Guía de configuración

Cornelius

Cornelius IntelliCarb Cold Beverage Dispenser Guía de instalación

Cornelius

Cornelius CTP-20 Guía de configuración

Cornelius

Cornelius Enduro 150 8 Valve Manual de usuario

Cornelius

Cornelius Quantum 45200001 Guía de configuración

Cornelius

Cornelius Visual Display Dispenser JS7-W25 Manual de usuario

Cornelius

Cornelius CHD22 Guía

Cornelius

Cornelius Jetspray JT20 Guía de configuración

Cornelius

Cornelius Ribbon Manual

Cornelius

Cornelius Impulse XL Manual de usuario

Manuales populares de Dispensador de bebidas de otras marcas

PEGAS

PEGAS Evolution Manual de usuario

Ugolini

Ugolini MT micro Manual de usuario

Bunn

Bunn SLCA-7 Instrucciones de instalación

Gekkeikan

Gekkeikan Sake Machine Manual de usuario

Olympia

Olympia DH709 Manual de usuario

Marco

Marco ECOSMART PB10 Manual de usuario

Marvel

Marvel ML24BN Series Manual

Cecilware

Cecilware 2K-GB-LD Manual

Sure Vend

Sure Vend 673 Manual de usuario

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Manual de usuario

Bunn

Bunn LCR-3 HV Guía de solución de problemas

Servend

Servend SV-200 Manual de usuario

EdgeStar

EdgeStar VBR440 Manual de usuario

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Manual de usuario

Siemens

Siemens GA 3000 Manual de instrucciones y seguridad

Selbach

Selbach Fruit Juice dispenser Manual de usuario

Taylor

Taylor C302NP Manual de usuario

Vinotemp

Vinotemp VT-WINEDISP2 Manual de usuario