CONVECTAIR SOPRANO Guía de instalación

Installation,

Operating Instructions

& Warranty Registration

( IMPORTANT: To be read and kept by the user )

421AA2586 ind A

7808

SOPRANO

 INTRODUCTION 

Dear owner,

Congratulations on the purchase of this premium electric heater.

CONVECTAIR develops and produces the highest quality heating product

in the electrical industry.

To obtain the best results and the ultimate in performance and comfort, please

take a moment to read the installation, operation and maintenance instructions

detailed in this manual.

1- SPECIFICATIONS..........................................................................PAGE 3

2- RECOMMENDED SET-UP.............................................................PAGE 3

3- INSTALLATION AND MOUNTING................................................. PAGE 4

4- ELECTRICAL CONNECTION........................................................ PAGE 5

5- OPERATING INSTRUCTIONS...................................................... PAGE 6

6- MAINTENANCE............................................................................. PAGE 6

7- PREVENTION................................................................................ PAGE6

8- OVERHEAT CONTROL................................................................. PAGE 7

9- TROUBLESHOOTING................................................................... PAGE 7

10-IDENTIFICATION OF YOUR HEATER.......................................... PAGE 8

11- WARRANTY INFORMATION......................................................... PAGE 8

 TABLE OF CONTENTS 

1 SPECIFICATIONS

7KH 6RSUDQR LV D FRPSDFW GLVFUHHW DQG HI¿FLHQW XQLW WKDW PD\ EH XVHG LQ DQ\ URRP

in the house.

During the installation, the Soprano allows you to select a wattage, either 750W or 1500W.

It is also available in two models to suit your requirements: 120V or 240V.

The Soprano’s control (sold separately) can be a timer, a thermostat or even a wall switch

that meets electrical local codes.

2 RECOMMENDED SETUP

PLEASE READ CAREFULLY:

These instructions are essential for safe installation and use of your CONVECTAIR unit.

This unit must be connected to a 240 Volt or 120 Volt to 60 Hz depending on the model.

Switch breaker in the off position «OFF» before connecting. CONVECTAIR recommends

WKDWWKHXQLWEHLQVWDOOHGE\DTXDOL¿HGHOHFWULFLDQLQDFFRUGDQFHZLWKQDWLRQDODQGORFDO

codes.

Determine where the Soprano must be installed. Once the location is chosen, ensure that

WKHUHLVQRREVWDFOHWRWKHÀRZRIDLUDURXQG2EVHUYHFOHDUDQFHV)LJ

The connection of the unit must be in a rectangular junction box pre-installed in the wall.

It must be installed in the wall and of a size suitable for receiving the cable connection and

cover 2 3/4" x 4 1/2" (7 cm x 11.5 cm) supplied with the unit. Do not position the heater

below an electrical receptacle.

CAUTION:

 DO NOT INSTALL THE BOTTOM OF THE UNIT

TO LESS THAN 71” (180 CM) FROM THE FLOOR

SURFACE.

 DO NOT INSTALL THE SIDES OF THE UNIT

TO LESS THAN 4” (10 CM) FROM ALL SURFACES.

 DO NOT INSTALL THE TOP OF THE UNIT

TO LESS THAN 8 ”(20 CM) OF A SHELF

OR A TABLET.

 DO NOT INSTALL THE TOP OF THE UNIT

TO LESS THAN 12” (30 CM) FROM THE CEILING.

 MAINTAIN A MINIMUM CLEARANCE OF 20”

(50 CM) IN FRONT OF THE UNIT.

Minimum clearances in inch (cm)

40"

(100 cm)

4" (10 cm)

(20 cm)

12"(30 cm)

(CEILING)

71"

(180 cm)

Fig.1

3 INSTALL ATION AND MOUNTING

- In the case of a coating of wall, posed on foam, it is necessary to consider, between

the support and the wall, a hold of a thickness equal to that of foam (to avoid to obstruct

the air outlet).

- Release mounting bracket by pressing and pulling the locking tab on the back side

of the heater (Fig.2).

- Position the mounting bracket on the wall and check the horizontality. Mark and drill

WKH¿[LQJKROHV)LJ

- Replace mounting bracket and fasten it with appropriate screws and anchors.

Fig.3

Fig.2

A = 9 1/16’’ (23 cm)

B = 3” (7,6 cm)

C = 4 23/32” (12 cm)

D WRWKHÀRRU = 74 1/32” (188 cm)

4 ELECTRICAL CONNECTION

7ZRZDWWDJHFRQ¿JXUDWLRQVDUHSRVVLEOHIRUWKH6RSUDQR

&RQ¿JXUDWLRQ:

- From the junction box connect the ground wire (copper) to the unit’s green wire,

use wire connectors (not included).

- Wire the unit following the recommandations as shown on the wiring diagrams below:

- Carefully place wires in the junction box and screw on the cover.

- Place the Soprano against the wall and lock it in position. Fix it to mounting bracket

before using.

&RQ¿JXUDWLRQ:

- From the junction box connect the ground wire (copper) to the unit’s green wire,

use wire connectors (not included).

- Wire the unit following the recommandations as shown on the wiring diagrams below:

- Carefully place wires in the junction box and screw on the cover.

- Place the Soprano against the wall and lock it in position. Fix it to mounting bracket

before using.

CAUTION:

 DO NOT INSTALL HEATHER OVER A BATHTUB OR OTHER CONTAINER.

 DO NOT USE IN AREAS WHERE GASOLINE, PAINT, OR FLAMMABLE LIQUIDS

ARE USED OR STORED.

5 OPERATING INSTRUCTIONS

The operating can vary according to the type of control used. Please consult

the instruction manual of the thermostat or the timer.

6 MAINTENANCE

To keep your unit clean, regular maintenance is recommended.

To remove dust, use a soft cloth. To remove a stain, use a damp cloth. Never use abrasives

WKDWPLJKWGDPDJHWKH¿QLVK

WARNING: In some cases, the grill may turn yellow after a while. This is not due to

a manufacturing defect. This is due to smoke and suspended particles in the ambient air,

heated and blown through the grille. This coloring can be reduced by a weekly cleaning

of the grill.

7 PREVENTION

It is recommended to frequently clean the air intake at the rear of the unit especially

in areas where smoke and dust are present. Never use this heater during contruction or

other activities that generate high amounts of dust particles.

'XULQJWKH¿UVWWLPHRSHUDWLRQRIWKHXQLWLWLVSRVVLEOHWKDWDVOLJKWRGRXUDQGVPRNHDUH

expelled from your Soprano. This is normal and it will cease after a few minutes of use.

CAUTION: ALWAYS DISCONNECT POWER TO THE UNIT BEFORE OPENING

OR CLEANING.

CAUTION:

THIS HEATER IS HOT WHEN IN USE.

TO AVOID BURNS, DO NOT LET BARE SKIN

TOUCH HOT SURFACES.

8 OVERHEAT CONTROL

The Soprano is equipped with a safety cut-out which shuts off the fan and the heating

element in case of overheating.

To reset the safety cut out:

1- Shut the power of the heater off.

2- Check the heater DQG¿[WKHFDXVHRIRYHUKHDWLQJEORFNLQJFRYHULQJRUGXVW

3- Wait 5 minutes, turn the power on and start the heater to check that it operates properly.

9 TROUBLESHOOTING

Before calling your electrician, please go through these simple checks:

1- Make sure the breaker in the distribution panel is in the “ON” position.

2- Make sure that your timer, thermostat or switch (not included) are in the “ON” position.

3- Adjust the thermostat (not included) to the maximum power level.

4- If after all these tests, the unit does not work, shut power “OFF” and wait 5 minutes,

then repeat steps 1 to 3. If the unit still does not work, contact your electrician or

CONVECTAIR.

5- If the light is still off, and no heat is generated, call your electrician or the nearest

CONVECTAIR service center.

After a while, the unit may shut off even if the heater is not clogged up. In such case,

the unit may require internal cleaning. Please contact one of our service centers or call

CONVECTAIR.

30, carré Sicard, Sainte-Thérèse, Qc, CANADA J7E 3X6

Tel.: (450) 433-5701 Fax: (450) 434-3166

Email: support@convectair.com

www.convectair.com

10 IDENTIFICATION OF YOUR HE ATER

IMPORTANT: PRODUCT INFORMATION APPEARS ON THE HEATER’S

IDENTIFICATION LABEL.

7KHLGHQWL¿FDWLRQODEHOLVORFDWHGRQWKHLQVLGHRIWKHKHDWHUYLVLEOHWKURXJKWWKHVXSHULRU

opening of the facade).

It includes:

- The complete model number and

its production reference number (A)

that must be included in any warranty

claim.

- Capacity (B).

- 6WDQGDUGFHUWL¿FDWLRQ&

11 WARR ANTY INFORMATION

2 years against all defects / 5 years on heating element.

All CONVECTAIR heaters are subjects to a double warranty: 2 years on all parts and

manufacturing defects and 5 years on the heating element itself.

:DUUDQW\LVDSSOLFDEOHIURPGDWHRISXUFKDVHE\WKHFXVWRPHUDQGXQGHUFHUWDLQVSHFL¿F

conditions. All details furnished with each heater. Please keep your invoices (purchase

and/or installation).

SERVICE CENTER:

&RQWDFW&219(&7$,5WR¿QGFORVHVWVHUYLFHFHQWHU

- Toll-free: 1 800 463-6478

- :HEVLWHZZZFRQYHFWDLUFRP

1500W

412

7808.C15.BB

WEEK / YEAR

Tabla de contenidos

Otros manuales de Calentador de CONVECTAIR

CONVECTAIR

CONVECTAIR CALYPSO 7826 Manual de usuario

CONVECTAIR

CONVECTAIR opera 12 7732-C07 Manual

CONVECTAIR

CONVECTAIR Piccolo 7831 Instrucciones de instalación

CONVECTAIR

CONVECTAIR DIVA 7647 Instrucciones de instalación

CONVECTAIR

CONVECTAIR Allegro 7300-C07 Guía de inicio rápido

CONVECTAIR

CONVECTAIR Allegro 26 7304 Manual

CONVECTAIR

CONVECTAIR 7359 - C05 Manual de usuario

CONVECTAIR

CONVECTAIR DIVA 7648 Manual de usuario

CONVECTAIR

CONVECTAIR ALTO 7375 C Manual de usuario

CONVECTAIR

CONVECTAIR Samba Manual de operación y mantenimiento

CONVECTAIR

CONVECTAIR ALLEGRO II Manual de usuario

Manuales populares de Calentador de otras marcas

oventrop

oventrop Regucor Series Manual de usuario

Blaze King

Blaze King CLARITY CL2118.IPI.1 Manual de usuario

ELMEKO

ELMEKO ML 150 Manual de usuario

BN Thermic

BN Thermic 830T Manual de usuario

KING

KING K Series Guía

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Guía de inicio rápido

Well Straler

Well Straler RC-16B Manual de usuario

EUROM

EUROM 333299 Manual de usuario

Heylo

Heylo K 170 Manual de usuario

Eterna

Eterna TR70W Manual de usuario

Clarke

Clarke GRH15 Manual de instrucciones

IRSAP

IRSAP The Radiator Company Ovali Manual de usuario

Empire Heating Systems

Empire Heating Systems WCC65 Manual de usuario

Wetekom

Wetekom 92 86 43 Manual de usuario

Desa

Desa SPC170-F Manual de usuario

Watlow

Watlow Watrod Electric Tubular Heaters Manual de usuario

Haverland

Haverland ECO-DRY GPS Series Manual de lista de piezas

Stelpro

Stelpro ASILVC2060 Series Manual de usuario