CDA akd01 Manual de referencia
Customer Care Department • The Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY
akd01 & akd02 Waste Disposers
Manual for Installation, Use and Maintenance
2
Important
The CDA Group Ltd cannot be held responsible for injuries or losses
caused by incorrect use or installation of this product. Please note that
CDA reserve the right to invalidate the guarantee supplied with this
product following incorrect installation or misuse of the appliance.
This appliance is not designed to be used by people (including
children) with reduced physical, sensorial or mental capacity, or
who lack experience or knowledge about it, unless they have had
supervision or instructions on how to use the appliance by someone
who is responsible for their safety.
Under no circumstances should any external covers be removed for
servicing or maintenance except by suitably qualified personnel.
Appliance information:
Please enter the details on the appliance rating plate below for
reference, to assist CDA Customer Care in the event of a fault with
your appliance and to register your appliance for guarantee purposes.
Appliance Model
Serial Number
3
CE Declarations of Conformity:
This appliance has been designed, constructed and marketed in
compliance with safety requirements of EEC Directive 2006/95/EEC
(Low voltage) and requirements of EMC Directive 2004/108/EEC.
This appliance has been manufactured to the strictest standards and
complies with all applicable legislation, including Electrical safety (LVD)
and Electromagnetic interference compatibility (EMC).
IMPORTANT INFORMATION FOR CORRECT DISPOSAL OF THE
PRODUCT IN ACCORDANCE WITH EC DIRECTIVE 2002/96/EC.
At the end of its working life, the product must not be disposed of as
urban waste. It must be taken to a special local authority dierentiated
waste collection centre or to a dealer providing this service.
Disposing of a household appliance separately avoids possible
negative consequences for the environment and health deriving from
inappropriate disposal and enables the constituent materials to be
recovered to obtain significant savings in energy and resources. As a
reminder of the need to dispose of household appliances separately,
the product is marked with a crossed-out wheeled dustbin.
4
Important
• This appliance is designed for disposal of domestic foodstus only.
Any other use falls outside the design criteria so will be considered
dangerous and will invalidate the guarantee.
• The appliance must be installed under a sink in a purpose-designed
kitchen unit.
• Ensure no cable from any other appliance can come into contact
with (or enter) the waste disposer during use.
• Do not modify the appliance in any way as this will invalidate the
guarantee and is potentially dangerous.
• Do not use ammable solvents near the appliance.
• Never allow inammable or explosive substances and/or strong
corrosive acids or alkalis to enter the appliance.
• Do not allow children to play with or near the appliance, and pay
particular attention when the waste disposer is operating in the
presence of children.
• Operating, cleaning and user maintenance of the appliance must
not be done by children without supervision.
• If a fault is noticed, switch o the appliance and unplug it from the
electricity supply.
• There are no user-serviceable parts inside the appliance; all repairs
must be performed by a suitably qualified service engineer or
similar.
• Do not use a sink tted with a waste disposer for any purpose
other than food preparation or washing dishes. Uses such
as bathing children or pets, washing hair or similar have the
potential for causing injury.
• Do not insert hands or ngers into the waste disposer. If it is
5
necessary to push foods into the unit, only use the plug/pusher
supplied.
• Replace the splash-guard when worn to help prevent ejection of
materials, splashing water and entry of foreign objects.
• In event of the waste disposer jamming, always disconnect the
power supply (unplug it) before attempting to solve the problem,
or to retrieve any object that has accidentally fallen into the waste
disposer.
• Certain materials may damage the waste disposer if they are put
into it, so do not allow these to enter it:
Oyster, clam or similar shells
Metal obejcts
Glass or china
Plastic or plastic wrappings (including cling film)
Chemical drain cleaners
Paper or cardboard
Large bones
Toothpicks and other wooden items
Excessive quantities of fat or grease
Abrasive cleaners such as scouring products and grits
(including creams such as Cif)
• CDA and its agents cannot be held responsible for any damage or
injury caused by improper use of this appliance.
• This appliance should not be installed in locations where the
ambient temperature may fall below 0°C. Use in ambient
temperatures below 0°C may damage the waste disposer.
• When the waste disposer is not in use, we recommend that you
disconnect the electrical power supply.
6
Using Your Waste Disposer
To dispose of domestic food waste
• Ensure that your hands are dry, then turn on the electrical supply to
the waste disposer.
• Turn on the cold tap to run water through the disposer.
• Start the disposer, by a rm press of the air switch button.
• Insert food waste into the disposer, if this needs pushing in use the
pusher supplied. Do not use a finger or any other implement.
• After the grinding is complete, stop the disposer by a rm press of
the air switch button.
• Allow the water to continue running for a few seconds to rinse the
waste disposer through.
• Turn o the cold water tap.
• After ensuring that your hands are dry, turn o the electrical supply
to the waste disposer.
Note: The waste disposer is designed to grind a mix of foods at the
same time; inserting just one food type may cause blockage of the
waste disposer.
This is particularly important when grinding fibrous foods such
as banana skins, corn husks, pineapple or artichoke leaves, or
asparagus.
7
Care and Maintenance
Routine cleaning
In normal use, as described above, the waste disposer is unlikely to
require cleaning or maintenance.
If an unpleasant smell develops, due to buildup of greasy particles,
or if you intend not to use the waste disposer for a lengthy time, we
suggest the following procedure:
• Put a sliced lemon and a few ice cubes into the waste disposer.
• Switch it on without water owing through, for 5-10 seconds.
• Run cold water through while the waste disposer is still running and
until grinding ceases.
• Turn o the cold water tap.
Overload Shut-down
The waste disposer is fitted with a shut-down system to prevent
internal damage in the event of a solid object or excessive food
entering it. If this happens the waste disposer will automatically shut
down.
To restart the waste dicposer:
• Switch o the waste disposer and
disconnect the electrical supply.
• Remove the solid object or excessive
food waste.
• Insert the hexagonal key (supplied
with the unit) into the centre hole on
the base of the waste disposer, rotate
it backwards and forwards (Fig. 1). Fig. 1
8
• Wait 5 - 10 minutes.
• Press the red “Reset” button on the base of the waste disposer.
• Re-connect the electrical supply.
• Run water through the waste disposer and start it up normally.
Troubleshooting
If you have any problems with your appliance you should check this
troubleshooting table prior to calling CDA Customer Care, to prevent
unnecessary service calls and potential cost.
Due to the nature of the waste disposer no further maintenance or
cleaning should be attempted by the user. Always entrust this to a
suitably qualied service engineer or similar.
You observe that Possible Causes What should you do?
The disposer does not run.
Electrical power not reaching the
disposer.
Check the electrical cable is
plugged in.
Check the fuse and/or circuit
breaker protecting the circuit.
The overload shutdown has
been activated.
Press the red reset button on the
base of the unit.
PVC air tube not fully sealed. Check the connections at both
ends of the PVC air tube.
The motor cannot be turned,
even with the hexagonal key.
The disposer is jammed by a
solid object.
Call CDA Customer Support for
assistance.
The motor is turning but makes
metalic noises.
The disposer is jammed by a
solid object.
Call CDA Customer Support for
assistance.
The motor attempts to run but
then stops.
The disposer is jammed by a soft
object (e.g. excessive food).
See instructions for “Overload
shut-down” above.
Water ow is slow when o but
fast when turned on.
The disposer is installed in a
single sink. This is normal.
Water does not ow out freely in
the sink with disposer installed.
The disposer is installed in a
double bowl sink.
Blocked waste pipe, take apart
and clean.
9
Installation
Identication of parts
Identify and check all necessary parts, as Fig. 2.
1 Plug / Pusher
2 Sink ange
3 Rubber washer
4 Fibre washer
5 Mounting ring
6 Clamp
7 Splash guard
8 Disposer body
9 Rubber seal
10 Outlet ange
11 Screws
12 Drain tube
Fig. 2
10
Installing the waste disposer
We recommend that before you start
installation you check the existing drain
pipe is in good condition and that any
obstructions are removed.
Part reference numbers below refer
to the diagram on page 9
• If tting to an existing sink installation
it is necessary to remove the sink
drain and waste trap previously
installed.
• Clean the sink ange area of any
putty or other debris.
• Open the clamp (6) and remove the
sink ange (2). (Fig. 1).
• Unscrew the mounting ring (5) and
remove the fibre washer (4).
• Pass the sink ange (2) through the
rubber washer (3) and the sink hole.
• Tighten the mounting ring (5) with
bre washer (4) onto the sink ange,
then tighten the screws so the sink
ange is seated rmly.
• Check that the splash guard (7) is
fitted to the disposer body (8).
• Wet the splash guard (7) with water.
Fig. 2
Fig. 3
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Manuales populares de Eliminación de basura de otras marcas
Insinger
Insinger I-6 Manual de usuario
Franke
Franke CE-50 Manual de funcionamiento
Leafield Environmental
Leafield Environmental Envirobank 140 Hoja de instrucciones
Meiko
Meiko TopCut B Manual de usuario
KitchenAid
KitchenAid KCDB250G2 Manual de usuario
Gladiator
Gladiator Garage Compactor Manual de usuario
