Briggs & Stratton 040229-2 Guía de configuración
Home Generator Systems
Illustrated Parts List
Manual No. 194689A Rev. B (03/28/2008)
12000 Rated Watts
Home Generator System
Model
040229-2
Exploded View - Main Unit
Copyright © 2008 Briggs & Stratton Power Products Group, LLC. All rights reserved. No part of this material may be
reproduced or transmitted in any form by any means without the express written permission of Briggs & Stratton Power
Products Group, LLC.
2BRIGGSandSTRATTON.COM
3
Item Part # Description
1 U203030GS BASE, Mounting
2 198899GS MOUNT, Vibration
3 24910GS HHS, Trilobular 5/16 - 18 x 1/2
4 194683GS SOLENOID, Gas Fuel
5 194829GS FITTING, Coupling
6 194830GS REGULATOR
7 195936GS BRACKET, Mounting Solenoid
8 202382GS FITTING, 1/2 Flare 3/8 - 18 NPT
9 * HHCS, M8 - 1.25 x 12
10 * HHCS, M6 - 1.0 x 30
11 * WASHER, 1/4 Lock
12 * NUT, M6 - 1.0
13 B4300GS HHS, Trilobular, 1/4 - 20 x 1/2
14 194818GS BATTERY
15 198593BGS WIRE-A, Red
16 198913GS KIT, Battery Hardware
17 185939VGS WIRE-A, Black
18 * HHCS, M8 1.25 x 16
19 201824GS BRACKET, Muffler Mounting Base
20 * WASHER, Flat 5/16 - M8
23 1723165SM HOSE, Oil Drain
24 186649GS DECAL, Oil Drain
25 * HHCS, 5/16 - 18 x 1
26 * NUT, 5/16 - 18
27 * WASHER, Lock 5/16 - M8
28 * HHCS, 5/16 - 24 x 3/4 SEMS
29 * HHCS, 1/4 - 20 x 1
30 * HHCS, 5/16 -18 x 1 - 3/4
31 B198897GS BRACKET, Alt Support
32 200013GS PLATE, Blocking Air, Alt
33 194005GS NUT, 1/4 - 20 Flange, Nylok
34 * WASHER, Shakeproof Ext. M6-1/4
35 186790HGS WIRE, Ground
36 * WASHER, Lock, M10
37 * NUT, Hex, M10 - 1.5
38 * HHCS, 1/4 - 20 x 3/4
39 B198896GS BRACKET, Engine Mounting
40 201817GS DUCT, Air
41 199999GS PTHS, #6 x 1/2"
42 * WASHER, Lock 3/8
43 * HHCS, 3/8 - 16 x 1-1/4
44 186790CGS WIRE
45 186206GS PLATE, Switch Oil Temp
46 * NUT, Hex 1/4 - 20
47 * WASHER, M6, Flat 1/4
48 * HHCS, M10 - 1.5
49 B4260GS DISK, Engine Air
Item Part # Description
50 692062 SCREW
51 NSP ASSY, Alternator (see page 7)
52 40976GS SHCS, M8 - 1.25 x 20
53 193506GS DECAL, Caution Hot Surface
54 806425 GASKET
55 198758GS MUFFLER
56 194681GS BASE, Muffler Box
57 198928GS KIT, Insulation, Muffler Base
58 56893GS CRIMPTITE, 10 - 24 x 1/2
59 201282GS ASSY, Bulkhead, Alternator End w/
Insulation
60 198929GS KIT, Insulation, Muffler Box
61 194682GS COLLECTOR, Muffler Box
62 194680GS BOX, Muffler Top
63 192445GS SCREW. 10 - 32 x 5/8
64 * PPHMS, 4-40 x 0.19
65 * WASHER, Lock #4
66 186205GS SWITCH, Oil Temp
67 198593CGS WIRE-A
68 691656 SOLENOID/BRACKET
70 205397GS DECAL, Requirements, Fuel
900 § ENGINE
901 843644 FUEL HOSE
902 843438 CLAMP
Items Not Illustrated
199327GS MANUAL, Install
194689GS MANUAL, Operator’s
MS3792 MANUAL, Engine
204516GS KIT, Manual/Accessory HGS
198810GS PAINT, Touchup, Grey 1/2 oz Bottle
198811GS PAINT, Touchup, Sliver 1/2 oz Bottle
B3518GS CAP, Funnel Oil Bottle
202295GS HOSE, Flex
198866GS KIT, Led Remote
198918GS KIT, Decals, Service
Optional Accessories
199475GS PAINT, Touchup, Spray, Silver, 12oz
199474GS PAINT, Touchup, Spray, Gray, 12oz
6030 KIT, Cold Weather (Includes Battery
and Oil Warmers)
* - Items without part numbers are common fasteners and
are available at local hardware stores.
§ - Contact Engine Manufacturer
Illustrated Parts List - Main Unit
Exploded View - Enclosure
4BRIGGSandSTRATTON.COM
Item Part # Description
1 197275GS PAD, Mounting w/Holes
2 U203030GS BASE, Mounting
3 198991GS ASSY, Bulkhead, Engine End
. . . . . . . Bulkhead, Engine End
. . . . . . . Decal, Fuel Inlet
. . . . . . . Seal, Foam
. . . . . . . Seal, Foam Engine Air
. . . . . . . Bushing, 1-1/2
. . . . . . . Bushing, 1-3/8
. . . . . . . Plug, Dome 1-1/2
. . . . . . . Pin, Hinges with Hardware
4 198986GS ASSY, Door, Engine. End
. . . . . . . Weldment, Door Engine End
. . . . . . . Insulation, Top
. . . . . . . Insulation, Bottom
. . . . . . . Barrel, Hinges with Hardware
5 198910GS ASSY, Duct, Engine Air
. . . . . . . Decals
. . . . . . . Lug, Ground Connect w/Hardware
. . . . . . . Bracket, Mounting Breaker
w/Hardware
6 198993GS ASSY, Support, Rail
. . . . . . . Support Rail Engine End
. . . . . . . Seal, Foam
. . . . . . . Decal, Rainproof
7 B4300GS HHS, Trilobular, 1/4-20 x ½
8 186173GS BUSHING, Snap, 1-3/8"
9 197493GS BUSHING, Snap, 1-1/2"
10 198461GS PLUG, Dome, 1-1/2"
11 * HHCS, 3/8 - 16 x 1
12 * WASHER, Flat, 3/8 - M10
13 * WASHER, Lock 3/8
14 * NUT, 3/8 - 16
15 200438GS ASSY, Door
. . . . . . . Weldment Door
. . . . . . . Insulation
. . . . . . . Barrel Hinges with Hardware
. . . . . . . Decals
Item Part # Description
16 199629GS SEAL, Foam, Engine Air
17 203303GS INSULATION, Engine Door, Bottom
18 195733GS MOUNT, Tie Wrap
19 195935GS DUCT, Rubber Alternator
20 203029GS ADAPTER, Alternator
21 198893GS ASSY, Roof/Siderails
. . . . . . . Weldment Roof/Siderails
. . . . . . . Insulation
22 201282GS ASSY, Bulkhead, Alternator End
. . . . . . . Decal, Caution Hot Muffler
. . . . . . . Seal, Foam
. . . . . . . Pin, Hinges with Hardware
. . . . . . . Bracket, Muffler
23 200409GS DECAL, Caution Hot Muffler
24 194679GS COVER, Air Intake Alternator
25 198926GS ASSY, Vent, Exhaust
26 B1797GS CLIP, Tree
27 198927GS ASSY., Vent, Alternator
28 198888GS SEAL, Foam
29 194694GS COVER, Air Intake Engine
30 203302GS INSULATION, Engine Door, Top
31 197312GS SEAL, Foam
32 196397GS INSULATION, Front/Rear Door
33 195597GS INSULATION, Roof
35 198460GS PLUG, Dome
36 192940GS RETAINER, Hose
38 198890GS KIT, Door, Hinge
39 194828GS SET, Latch Key
40 198889GS KIT, Door Latch
* - Items without part numbers are common fasteners and
are available at local hardware stores.
Illustrated Parts List - Enclosure
5
Item Part # Description
1 198911GS ASSY, Cover, Circuit Breaker w/
Decals
2 * SCREW, 10 x 0.62, Plastite
3 201089GS BREAKER, Circuit 60A, 2P
4 192770GS BRACKET, Mounting Breaker
5 199011GS LUG, Ground Connect
6 191991GS BOLT, 1/4-10 x 1, Plastite
7 198573GS FUSE, Auto Type 15 Amp
8 196655GS ASSY, Control Panel
9 197492GS SCREW, PT, M4 - 1.79 x 16.0
10 198910GS ASSY, Duct, Engine Air w/ Decals
12 198549GS DECAL, Terminal Block
13 198550GS DECAL, Ground, Neutral
14 205393GS DECAL, Warning, Outdoor Install
15 193297GS DECAL, Caution, Standby
16 205392GS DECAL, Warning, Auto Start
Item Part # Description
17 205394GS DECAL, Caution, Electric Shock
18 205395GS DECAL, Warning Shock
19 * NUT, 1/4 - 20
21 * WASHER, Shakeproof, Ext M6 1/4
22 * HHCS, 1/4 - 20 x 3/4
Items Not Illustrated
201090GS HARNESS, Wire, CTL Board to
Engine/Alternator
198517GS HARNESS, Wire, E1 & E2 Sensing
198515GS CONNECTOR, Terminal, 2 Pin
198516GS CONNECTOR, Terminal, 10 Pin
* - Items without part numbers are common fasteners and
are available at local hardware stores.
Exploded View & Illustrated Parts List - Control Panel
6BRIGGSandSTRATTON.COM
Exploded View & Illustrated Parts List - Alternator
Item Part # Description
1 192970GS BRACKET, Drive End
2 192973GS SCREEN, Protection
3 B4908GS BOLT, Shaft Stay
4 * SCREW, Socket Head Cap
5 192969GS FRAME and Stator
6 192962GS PLUG, Rubber Grid
7 192966GS GRID
9 192967GS BOX, Terminal Lid
10 192968GS TERMINAL BOARD
11 * WASHER, Flat, #10 - M5
12 * NUT, 10 - 32
13 192974GS CAPACITOR
14 * PPHMC, 10 - 32 x 3/4
15 192972GS DIODE
16 192971GS ASSY., Rotor
17 * SCREW, M8 x 1.25 x 35mm
18 * WASHER, Shakeproof, Ext M6 - 1/4
19 * NUT, 1/4 - 20
* - Items without part numbers are common fasteners and are
available at local hardware stores.
7
Tabla de contenidos
Otros manuales de Generador portátil de Briggs & Stratton
Briggs & Stratton
Briggs & Stratton 196382GS Manual de usuario
Briggs & Stratton
Briggs & Stratton Portable Generator Manual de usuario
Briggs & Stratton
Briggs & Stratton 1653 Manual de usuario
Briggs & Stratton
Briggs & Stratton PowerBoss PowerBOSS 5600 Watt Portable... Manual de usuario
Briggs & Stratton
Briggs & Stratton 01532-2 Manual de usuario
Briggs & Stratton
Briggs & Stratton 86262GS Manual de usuario
Briggs & Stratton
Briggs & Stratton 30470 Manual de usuario
Briggs & Stratton
Briggs & Stratton Portable Generator Manual de usuario
Briggs & Stratton
Briggs & Stratton 40248 Manual de usuario
Briggs & Stratton
Briggs & Stratton 1970 Manual de usuario
Briggs & Stratton
Briggs & Stratton 030360-0 Guía de inicio rápido
Briggs & Stratton
Briggs & Stratton Home Generator Manual de instalación
Briggs & Stratton
Briggs & Stratton 206883GS Manual de usuario
Briggs & Stratton
Briggs & Stratton 1938 Manual de usuario
Briggs & Stratton
Briggs & Stratton 030750 Manual de usuario
Briggs & Stratton
Briggs & Stratton PowerSmart P2000 Manual de usuario
Briggs & Stratton
Briggs & Stratton PRO 7500 Manual de usuario
Briggs & Stratton
Briggs & Stratton Elite 09801 Manual de usuario
Briggs & Stratton
Briggs & Stratton 316916GS Manual de usuario
Briggs & Stratton
Briggs & Stratton P2200 Manual de usuario
