Blue Sky Network HawkEye 5500 Manual de usuario
HawkEye 5500
Install Guide
Version 3.4
BSN-300503
HawkEye 5500 Installation Guide - 6/23/2020 Notice
Page 2 of 37 © 2020 Blue Sky Network, All Right Reserved.
HawkEye 5500 Installation Guide - 6/23/2020 Notice
Page 3 of 37 © 2020 Blue Sky Network, All Right Reserved.
NOTICE
This guide is published and copyrighted by Blue Sky Network (BSN). All information and specifications in
this document are subject to change without notice. Nothing in this document is intended to create addi-
tional or separate warranties or guarantees.
Blue Sky Network, 5333 Mission Center Rd. #220, San Diego, CA 92108
Phone: +1 858-551-3894 | Fax: +1 858-225-0794
E: support@blueskynetwork.com | W: www.blueskynetwork.com
© 2020 Blue Sky Network, All Right Reserved.
HawkEye 5500 Installation Guide - 6/23/2020 Revision History
Page 4 of 37 © 2020 Blue Sky Network, All Right Reserved.
REVISION HISTORY
Date Rev. By Description
28-Jan-2020 1 CR Initial Release
15-Feb-2020 1.1 CR Update diagnostic section to match new commands
17-Feb-2020 3.0 CR Added wiring diagrams to appendix C
18-Feb-2020 3.1 CR Added photos and expanded installation requirements
15-Jun-2020 3.2 CR Updated wiring diagrams
16-Jun-2020 3.3 CR Changed behavior of waypoint LED
23-Jun-2020 3.4 CR Grammar corrections, added note about SOS pins, led behavior
HawkEye 5500 Installation Guide - 6/23/2020 Revision History
Page 5 of 37 © 2020 Blue Sky Network, All Right Reserved.
TABLE OF CONTENTS
Notice .............................................................................................................................. 3
Revision History .............................................................................................................. 4
Introduction ..................................................................................................................... 8
HawkEye 5500 .......................................................................................................................................... 8
Installation components ............................................................................................................................ 8
Extending Wiring Assemblies ................................................................................................................ 9
Rear Panel Description ........................................................................................................................... 10
Control Panel Description ....................................................................................................................... 11
Powering unit on via front pannel ........................................................................................................ 11
Sending a waypoint ............................................................................................................................. 11
Activating / Deactivating Emergency via front pannel ......................................................................... 11
Bottom Panel Description ........................................................................................................................ 12
Mounting & Installation .................................................................................................. 13
Installation Equipment ............................................................................................................................. 13
Location Requirements ........................................................................................................................... 14
Location Suggestions .............................................................................................................................. 14
Mounting.................................................................................................................................................. 14
Mounting with Just Unit ....................................................................................................................... 15
Mounting with Bracket ......................................................................................................................... 15
Installation Procedure .................................................................................................... 16
Step 1 - Install Battery & SIM .................................................................................................................. 16
Step 2 – Attach Power ............................................................................................................................ 17
PIN 1 ................................................................................................................................................... 17
PIN 2 ................................................................................................................................................... 17
PIN 3 ................................................................................................................................................... 17
Step 3 – Attach Antennas ....................................................................................................................... 18
HawkEye 5500 Installation Guide - 6/23/2020 Revision History
Page 6 of 37 © 2020 Blue Sky Network, All Right Reserved.
Tamper Indicator ................................................................................................................................. 18
External Antenna requirements........................................................................................................... 18
Iridium & GPS Antenna ....................................................................................................................... 19
Cellular Antenna .................................................................................................................................. 19
Step 4 – OBD Vehicle BUS Integration ................................................................................................... 20
Passenger vehicles ............................................................................................................................. 20
Commercial Vehicles .......................................................................................................................... 20
Step 5 – Install The Emergency Switch .................................................................................................. 21
Step 6 – Digitial & Analog Input/OUTPUT & 1-Wire & RS-232 ............................................................... 21
Step 7 – Attach Speaker Output ............................................................................................................. 21
First Power On Procedure ............................................................................................. 22
Activate Unit ............................................................................................................................................ 22
Power On Unit ......................................................................................................................................... 22
Configure Unit ......................................................................................................................................... 23
Confirm Unit Status ................................................................................................................................. 23
Power OFF Unit ...................................................................................................................................... 23
Replacing the SIM ......................................................................................................... 24
Configure cellular settings ....................................................................................................................... 24
Replacing or Removing the Battery ............................................................................... 25
Appendix A - FAQ ......................................................................................................... 26
Appendix B – Troubleshooting ...................................................................................... 27
DIAGNOSTIC TESTS ............................................................................................................................. 27
Perform a Full system test .................................................................................................................. 27
READ DIAGNOSTIC SYSTEM INFORMATION..................................................................................... 27
Connecting to BT command server .................................................................................................... 27
Sending SMS commands .................................................................................................................... 27
Issuing commands .............................................................................................................................. 27
HawkEye 5500 Installation Guide - 6/23/2020 Revision History
Page 7 of 37 © 2020 Blue Sky Network, All Right Reserved.
Appendix C – Cable Diagrams ...................................................................................... 29
Support .......................................................................................................................... 36
HawkEye 5500 Installation Guide - 6/23/2020 Introduction
Page 8 of 37 © 2020 Blue Sky Network, All Right Reserved.
INTRODUCTION
This installation guide covers the process to installing the HawkEye 5500 on a vehicle.
HAWKEYE 5500
The HawkEye 5500 is a dual-mode tracking, telemetry, and communication system designed to be installed
in vehicles. The dual-mode tracking capability enables the unit to switch back and forth between 2G/3G/LTE
cellular and Iridium satellite networks for uninterrupted tracking coverage. By utilizing the OBDII port on the
vehicle, the unit can also collect telemetry for transmission to the SkyRouter platform. The unit can also be
utilized with a variety of accessories and antenna kits in order to provide the preferred configuration for
each user.
INSTALLATION COMPONENTS
The list of components for installation are based on the desired configuration for each unit. Parts may be
purchased separately, and custom cable lengths can be specified during ordering. Please contact us for
more information about available accessories and installation kits.
The list below describes some of the most common options available in the kit or purchased.
Power cable assembly
o Pigtail (2 foot length)
Audio cable assembly - Optional
o Pre-assembled 6 foot length
o Self-assembly kit
Emergency/IO cable assembly – Optional
o Pre-assembled 6ft length
o Self-assembly kit
o Splitter kit (2/4-way split)
Vehicle cable assembly (standard OBD connector) – Optional
o Pre-assembled 1ft length
o Extension Kit
o Commercial / heavy duty adapter
Driver identification RFID reader - Optional
o Pre-assembled 3ft length
o Self-assembly kit
Dual-Band antenna (GPS – Iridium)
o Dash mount patch antenna
o Roof mount installed antenna (multiple options available)
Tri-Band antenna (GPS – Iridium – 2G/3G/LTE)
o Dash mount patch antenna
o Roof mount installed antenna (multiple options available)
HawkEye 5500 Installation Guide - 6/23/2020 Introduction
Page 9 of 37 © 2020 Blue Sky Network, All Right Reserved.
EXTENDING WIRING ASSEMBLIES
All wiring assemblies come with a length of cable that is acceptable for typically installations. If a longer
length is needed, you can order the cables made to the appropriate length (additional charge may apply)
or extend the cables by cutting the middle of the cable harness and applying soldered or solderless (e.g.
crimped) extensions. Please ensure that extension wire is the same or thicker gauge wire to prevent
possible issues with wire overheating.
HawkEye 5500 Installation Guide - 6/23/2020 Introduction
Page 10 of 37 © 2020 Blue Sky Network, All Right Reserved.
REAR PANEL DESCRIPTION
#1, 2, 7
Antennas
1
Cellular (Optional External Antenna)
2
Iridium
3
GPS (Active)
#3
Emergency Switch
& IO
1
Emergency Switch +
2
Analog IN
3
Emergency Switch IN
4
Digital IN #1 2.5VDC = Active
5
Emergency Switch LED
6
Digital IN #2 2.5VDC = Active
7
Emergency Switch Ground
8
1-Wire RFID Interface
9
RS-232 OUT
10
RS-232 IN
#4 Audio Out
1
+10-32 VDC Power
2
Speaker -
3
Speaker +
4
Ground
#5 OBD (Vehicle Interface)
1
Single Wire CAN (GMW 3089)
2
SAE J1850 Bus +
3
MS CAN High
4
Chassis Ground
5
Signal Ground
6
CAN (J-2234) High
7
ISO 9141-2 (K-Line)
8
SAE J1850 Bus -
9
MS CAN Low
10
CAN (J-2243) Low
11
ISO 9141-2 (L-Line)
12
Battery Power
#6
Power & Ignition
1
+10 – 32 VDC IN
2
Power Ground
3
10 – 32 VDC Ignition IN
4
Digital OUT #1
5
Spare
6
Digital OUT #2
NOTE: See Appendix C – Cable Diagrams for information regarding cable construction requirements.
1
6
1 1 1
4 7
3
1
6
1
3
1
7
1
4
Otros manuales para HawkEye 5500
1
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Otros manuales de Accesorios para automóviles de Blue Sky Network
