BenchMark Wireline ALS4A100 Manual de usuario

benchmarkwireline.com

P. O. BOX850

Fax: 281.342.4848

Phone: 281.342.6415

Simonton,Texas77476

36220 FM 1093

ALS4A100 DATA RECORDER Rev A Aug-2007 Page 1 of 9

ALS4A100 SERIAL DATA RECORDER

USER MANUAL

benchmarkwireline.com

P. O. BOX850

Fax: 281.342.4848

Phone: 281.342.6415

Simonton,Texas77476

36220 FM 1093

ALS4A100 DATA RECORDER Rev A Aug-2007 Page 2 of 9

1.0 DESCRIPTION

This device is typically used to store frac or pumping unit parameters (see example

file on following page). The data is provided from a serial input. No characters

such as line feed or carriage return are added by the data recorder except the

header record (if selected – refer to section 3.2).

The data is stored in a DOS text file format onto a 512MB compact flash card.

The device is certified for use in a zone 2 or Class 1 Div 2 area. It is certified to an

ATEX standard (see certification document on last page).

2.0 DIMENSIONS

benchmarkwireline.com

P. O. BOX850

Fax: 281.342.4848

Phone: 281.342.6415

Simonton,Texas77476

36220 FM 1093

ALS4A100 DATA RECORDER Rev A Aug-2007 Page 3 of 9

3.0 OPERATING AND SETUP INSTRUCTIONS

3.1 MOUNTING

To mount the box, first remove the lid. Locate the hole in each of the four

corners (refer to section 2.0). Insert ¼” socket head screws into these holes.

The screws can then attach it to a plate or screw into matched drilled holes.

3.2 SET THE HEADER RECORD JUMPER

Jumper J2 on the PCB board (see below) determines if the header block

(refer to section 4) is written at the beginning of each date file.

Jumper J1 is used for programming and must remain on for operation.

benchmarkwireline.com

P. O. BOX850

Fax: 281.342.4848

Phone: 281.342.6415

Simonton,Texas77476

36220 FM 1093

ALS4A100 DATA RECORDER Rev A Aug-2007 Page 4 of 9

3.3 CONNECT POWER AND DATA COMMUNICATIONS INPUT

PIN A = 12 – 36 VDC

PIN B = POWER GROUND

PIN C = RS232 SERIAL IN

19,200 BAUD

8DATABITS

NO PARITY

1 STOP BIT

NO HANDSHAKING

PIN D = SIGNAL GROUND

3.4 INSTALL COMPACT FLASH

Make sure the compact flash card is installed and has adequate space.

The maximum size allowed is 512MB. Smaller sizes can be used but not

recommended.

The recommended file system is FAT-16. FAT-32 can be used with some

flash cards but will not work properly with others.

benchmarkwireline.com

P. O. BOX850

Fax: 281.342.4848

Phone: 281.342.6415

Simonton,Texas77476

36220 FM 1093

ALS4A100 DATA RECORDER Rev A Aug-2007 Page 5 of 9

4.0 DATA RECORDS

4.1 TYPICAL RECORD WITH HEADER RECORD

[Serial Port Initialize]

[Communication Restored]

Time: 00:00:02

[Version: 2.5]

[Source:]

[Begin Channels]

Num_Channels=16

Channel1:Circulating Pressure,psi,4,1,2,0,1.5e+04,8.304182e-01,-

7.573697e+01

Channel2:Wellhead Pressure,psi5,1,10,1.5e+04,8.238757e-01,6.301403e+01

Channel3:Stripper 1,psi,01603.e+03,9.84839e-01,-1.424789e+01

Channel4:Stripper 2,psi,01703.e+03,1.022615,-2.774906e+01

Channel5:Top Traction,psi,0,1,10,0,3.e+03,1.026653,7.052422

Channel6:Middle Traction,psi,0,1,9,0,3.e+03,1.,0

Channel7:Bottom Traction,psi,0,1,8,0,3.e+03,1.030046,7.665047e+01

Channel8:Chain Tension,psi,0,1,5,0,3.e+03,1.,0

Channel9:Pipe Heavy,lbs,3,1,3,0,8.e+04,4.3e-01,0

Channel10:Pipe Light,lbs,6,1,4,0,-4.e+04,4.3e-01,0

Channel11:Speed,ft/min,2,3,1,0,3.,1.2e-01,0

Channel12:Fluid Rate,bbl/min,0,3,2,0,8.,1.,0

Channel13:N2 Rate,scfm,0,3,3,0,5.,1.,0

Channel14:Spare,bbl/min,0,3,4,0,1.e+03,1.,0

Channel15:Spare,bbl/min,0,3,5,0,1.5e+03,1.,0

Channel16:Depth,feet,1,4,1,0,1.e+04,2.e-03,0

[End Channels]

[Begin Controllers]

Num_Controllers=0

Controller1:/ORI,234,Cyrano Version 5.0.0,R3.1a

[End Controllers]

[Begin Data Capture]

081605,080646,000003.00, 0000020.00, 0000002.00, 0000003.00, 0000010.00,

0000004.00, 0000008.00, 0000020.00, 0000002.00, 0000008.00, 0000000.00,

0000000.00, 0000000.00, 0000005.00, 0000005.00,

0002471.23081605,080646,081605,080646,081605,080646,081605,080646,081605,0

80646,081605,080647,081605,080648,081605,080649,081605,080650,081605,08065

1,081605,080652,081605,080653,081605,080654,081605,080655,081605,080656,08

1605,080657,081605,080658,081605,080659,081605,080700,081605,080701,081605

,080702,081605,080703,081605,080704,081605,080705,081605,080706,081605,080

707,081605,080708,081605,080709,081605,080710,081605,080711,081605,080712,

081605,080713,081605,080714,081605,080715,081605,080716,081605,080717,0816

05,080718,081605,080719,081605,080720,081605,080721,081605,080722,081605,0

80723,081605,080724,081605,080725,081605,080726,081605,080727,081605,08072

8,081605,080729,081605,080730,081605,080731,081605,080732,081605,080733,08

1605,080734,081605,080735,081605,080736,081605,080737,081605,080738,081605

,080739,081605,080740,081605,080741,081605,080742,081605,080743,081605,080

744,081605,080745,081605,080747,081605,080748,081605,080749,081605,080750,

081605,080751,081605,080752,081605,080753,081605,080754,081605,080755,

benchmarkwireline.com

P. O. BOX850

Fax: 281.342.4848

Phone: 281.342.6415

Simonton,Texas77476

36220 FM 1093

ALS4A100 DATA RECORDER Rev A Aug-2007 Page 6 of 9

4.2 WITHOUT HEADER RECORD