Barbeques Galore Downunder G4DLK Manual de usuario

4 Burner Solid Hotplate

Barbeque With Folding

Legs

G4DLK (BGW4NH007S)

INSTRUCTIONS

For safe use and enjoyment of your new barbeque

1. IMPORTANT HEALTH & SAFETY INFORMATION

( I). WARNING:

FOR OUTDOOR USE ONLY ! DO NOT USE INDOORS

 • Pleasereadtheseinstructionscarefullypriortoassemblyanduse.

 • Failuretofollowtheseinstructionscouldleadtoseriousinjuryand/orsignicantdamagetoproperty.

 • Donotstartthebarbequeifthereisanydoubtoverthecorrectassembly,ignition,gascontrolor

  cookingoftheunit.

 • Theseinstructionsshouldberetainedforfuturereference.

 • ForusewithPropanegascylinderonly.

 • Thebarbequemusthaveaminimumsideclearancefromanycombustiblematerialofatleast

  250mm.Additionallytheremustbeaclearanceofatleast1500mmabovethecookingsurfaceof

  thebarbeque.

 • Flammablematerialsandliquidsmustbestoredwellawayfromthebarbeque.

 • Aerosolsmustnotbeusednearthebarbeque.

 • Thebarbequeshouldnotbemovedwhenlitorhot.

 • Alitbarbequeshouldbeattendedatalltimes.

 • GascylindersMUSTbestoredandusedverticallyonly.

 • Neverattempttoignitethebarbequewiththelidclosed.

 • Avoiddousingthebarbequewithwater.

 • Turnoffthegascylinderwhenthebarbequeisnotinuse;

 • Alwaysallowthebarbequetocompletelycooldownbeforecovering.

 • Forsafetyreasonsitisadvisabletokeepareextinguisherandreblanketclosetohand.

 • Unsupervisedchildren,elderlyandinrmshouldnotbeallowedclosetothebarbequeduringpre-

  heat,cooking,burnofforcoolingdownoftheunit.

 • Pleasedisposeofallpolythenepackingandplasticbagscarefullyandkeepoutofreachof

  children.

( II ). GAS TYPE AND REGULATOR:

 • ThisbarbequeisdesignedtorunfromaPropanegascylinderonly.

 • Toensuremaximumperformanceagascylinderof9kgisrecommended.

 • Theregulatorassuppliedshouldbermlytightenedbutcaremustbetakennottoover-tightenthe

  connections.

 • Theregulatorassuppliedisthecorrectregulatorforthisitem.

 • Donotattempttoconnectgastoabarbequethatisnotproperlysecuredonthegascylinderhook.

( III ). IF YOU SMELL GAS:

DO NOT ATTEMPT TO OPERATE THE BARBEQUE UNTIL THE CAUSE OF THE GAS SMELL HAS

BEEN IDENTIFIED AND ELIMINATED

• Immediatelyisolatethegassupplybyturningthegasoffatthegascylinder.

• Extinguishallnakedames.

• Donotoperateanyelectricaldevicesclosetothebarbeque.

• Checkforleaksasdescribedinsection3 part ( IV ) Precautionary Leak Test.

• Ensurethatlocalareaiswellventilatedtoremoveanyexcessgas.

• Ifthegassmellcontinuesthebarbequeshouldnotbeoperatedunderanycircumstancesanditis

importanttomakeimmediatecontactwiththecustomerservicecentre.

( IV ). PRECAUTIONS:

BEFORE FIRST TIME OPERATION AND AFTER EACH GAS CYLINDER EXCHANGE/REFILL ALL

CONNECTIONS SHOULD BE CHECKED FOR GAS LEAKS

 • Connectionscanbecheckedforleaksbyusingasoapywatersolutionasdescribedinsection3

part ( IV ) Precautionary Leak Test.

 • Nakedames(matchesorotheropenames)mustnotbeusedtocheckforleaks,thisisa

  dangerouspracticetobeavoided.

 • Flammableliquidsofanydescription,includingpetrol,lighteruid,oils,etcmustnotbestored

  closetothebarbeque.

 • SpareorextragascylindersmustNOTbestoredwithincloseproximityofthisbarbequeorany

  othergasorelectricappliance.

 • Spareorextragascylindersshouldnotbestoredwheretheyareexposedtocontinuousdirect

  sunlight,asthisisapotentiallydangerouspractice.

 • Thepositionoftheassembledbarbequeshouldbesuchthatthegascylinderisnotleftexposedto

  directsunlightasthisisapotentiallydangeroussituation.

 • Pleasereadandfollowallinstructionsinthismanual,ifindoubtastoanyoperationalorsafety

  precautioncontactthecustomerservicecentre.

 • PleaseensurethegascylinderispositionedoutsideoftheBarbequeframe.Itmustnotbe

positionedunderneaththebarbeque.

 • Forstorageandgascylinderexchange,disconnectthegascylinderonly.Donotdisconnecthose

fromtheappliance.

2. ASSEMBLY INSTRUCTIONS

( I ) PARTS LIST

ITEM DESCIRPTION QUANITITY PICTURE

1FIRE-BOXASSEMBLY 1

2LEGSUPPORTBRACKET 4

3LEG 4

4LEGCROSSBRACE 2

5GASCYLINDERHOOK 1

6HEATINSULATIONPANEL 1

7HANDLE 2

8GREASECUP 1

ITEM DESCIRPTION QUANITITY PICTURE

AM6X12mmSHORT

PHILLIPSHEADSCREW 12

BM6STEELWASHERS 12

CM6NUTS 8

DM6WINGNUTS 4

EM6X40mmLONG

PHILLIPSHEADSCREW 12

FM6X16mmMEDIUM

PHILLIPSHEADSCREW 4

2. ASSEMBLY INSTRUCTIONS (continued)

( II ) FASTENERS LIST

2. ASSEMBLY INSTRUCTIONS

( III ) ASSEMBLY STEPS

Attachthelegsupportbracketstothereboxusingshortscrew(A).

Eightofthenuts(closesttothehotplate)arepreinstalledforyourconvenience.

Step 1

Attachthelegstothelegsupportbracketusinglongscrews(E),washers(B),

nuts(C)andwingnuts(D).Thenattachthelegcrossbraceusing(E),(B)and(C).

Step 2

8PCS

4PCS

8PCS

12PCS

SHORT SCREWS

WASHERS

NUTS

WING NUTS

LONG SCREWS

Note: Steps1to4arebestdonewiththebarbequecarefullyrestingonitsback

 asshowninStep1

Attachthehandlesfromunderneathusingmediumscrews(F)andwasher(B).

Step 3

Attachthegascylinderhook(5)andheatinsulationpanel(6)atthesametime

usingshortscrews(A),fourofthenuts(closesttotheheatinsulationpanel)are

pre-installedforyourconvenience.

Step 4

4PCS

WASHERS

MEDIUM SCREWS

SHORT SCREWS

Hangthegreasecupontoitshookunderneaththetomiddleburners.

Fullassembly.

Step 5

3. SETTING UP THE BARBEQUE

THIS APPLIANCE SHALL ONLY BE USED IN AN ABOVE GROUND OPEN AIR SITUATION WITH NATURAL

VENTILATION, WITHOUT STAGNANT AREAS, WHERE GAS LEAKAGE AND PRODUCTS OF COMBUSTION

ARE RAPIDLY DISPERSED BY WIND AND NATURAL CONVECTION

(I ) POSITIONING

 • PleasemakesurethatthebarbequeisNOTpositionedunderneathanycombustiblematerialor

  surface.

 • ThereMUSTbeaclearanceofatleast250mmfromthesidesofthebarbequetoanycombustibl

  materialsorsurfaces.Theremustalsobeaclearanceofatleast1500mmabovethecookingsu

  facestoanycombustiblesurface,and500mmclearanceattheback.

 • FlammablematerialsofanydescriptionMUSTbekeptwellawayfromthebarbeque.

 • Thebarbequemustbepositionedsuchthatthegascylinderiskeptawayfromdirectsunlight.

 • Thebarbequemustbepositionedtoavoidwalkways,gangwaysandgeneralpedestrianaccess.

 • Thenatureofabarbequeissuchthatmanyofthesurfacesarehottotouch,thepositioningofthe

  barbequeshouldtakeintoconsiderationthepossibilityofaccidentalhandorbodycontact.

Any enclosure in which the appliance is used shall comply with one of the following:

 • Anenclosurewithwallsonallsides,butatleastonepermanentopeningatgroundlevelandno

  overheadcover.

  SEEEXAMPLE1

 • Withinapartialenclosurethatincludesanoverheadcoverandnomorethantwowalls.

  SEEEXAMPLE2&3

 • Withinapartialenclosurethatincludesanoverheadcoverandmorethantwowalls,thefollowin

  shallapply-

  • atleast25%ofthetotalwallareaiscompletelyopen;and

  • atleast30%oftheremainingwallareaisopenandunrestricted

   SEEEXAMPLE4&5

 • Inthecaseofbalconies,atleast20%ofthetotaloftheside,backandfrontwallareasshallbeand

  remainopenandunrestricted

EXAMPLE 1 EXAMPLE 2 EXAMPLE 3

EXAMPLE 4 EXAMPLE 5

Opensideatleast25%of

totalwallarea

30%ormoreintotal

oftheremainingwallarea

inopenisunrestricted Opensideatleast25%of

totalwallarea

30%ormoreintotal

oftheremainingwallarea

inopenisunrestricted

( II ) PRECAUTIONS

DO NOT OBSTRUCT ANY AIRFLOW PATH OR VENTILATION PATHS OF THE BARBEQUE

 • Donotobstructanyventilationportsonthebodyofthehoodofthebarbeque.

 • Thegascylindermustbesecurelyplacedonthegascylinderhookassupplied.

 • Itisimportantthatthegasculinderisnotpositionedunderthebarbequewheninoperation.

 • Thegascylindermustbekeptoutofdirectsunlightandawayfromanyheatsources.

 • Duringagascylinderswaporre-llensurethatallcontrolknobsareinthe‘OFF’positionandthere 

  arenonakedamesoncloseproximity.

 • GashosesmustNOTbetwistedkinkedorunderanyformoftension,thegashosesshouldhang

  freelywithnobends,folds,orkinks.

 • Nopartoftheexiblehoseshouldcomeintocontactwithanypartofthebarbequethatwill

  becomehotduringoperation.

 • Aregularinspectionofthehoseshouldbemadetoensurethatitisnocracking,breakingcutting

  ordeterioratinginanyotherway.

 • Anydamagetothehoserequiresanimmediatereplacementfromyourlocalagentorgasexpert.

( III ) GAS CYLINDER CONNECTION

DO NOT ATTEMPT TO CONNECT THE GAS CYLINDER TO THE BARBEQUE BEFORE CHECKING AS

DESCRIBED BELOW

 • Checkthatallthecontrolknobsareinthe‘OFF’positionbeforeanyattemptismadetoconnecttheregulator

tothegascylinder.

 • Doublecheckthatthegascylindervalveissecurelyinthe‘off’positionbeforeattemptingto

  connecttheregulatortothegascylinder.

 • Maketheconnectionoftheregulatortothegascylinderitisimportanttonotethatthisconnection

  isa‘LEFT HAND THREAD’.Aleftandthreadistightenedinan‘ANTI-CLOCKWISE DIRECTION’.

 • Shouldtherebeanyconcerninmakingthecorrectregulatorconnectionpleasecontactthe

  customerservicecentre.

( IV ) PRECAUTIONARY LEAK TEST

LEAK TESTS MUST BE CARRIED OUT IN A WELL VENTILATED AREA

 • Conrmallcontrolknobsareinthe‘OFF’position.

 • Openthegascontrolvalveonthecylinderorregulator.

 • Tocheckforgasleaksasolutionofsoapywaterisrequired(50%waterand50%dishwashingliquid).

NEVER USE AN OPEN FLAME TO CARRY OUT A GAS LEAK TEST

 • ThegaspipingsystemMUST becheckedforleaksbybrushingthesoapywatersolutionacross

  eachjointincludingvalveconnections,hoseconnectionsandregulatorconnections.

 • Ifbubblesappearacrossanyjointorconnectionthereisaleak:

   • Immediatelyturnthegasvalve‘OFF’.

   • Checkandretightenallgasconnectionsandjoints.

   • Repeatfromstartofsection3 part ( IV ) PRECAUTIONARY LEAK TEST.

   • Iftheleakhasbeencorrectedthenthebarbequecanbeused.

   • IftheleakhasnotbeenxedDO NOT USE YOUR Barbeque

    contactyourserviceagentaslistedonthewarrantycardforassistance.

POL FITTING

BBQinletFitting

(factorytted)

Tabla de contenidos

Otros manuales de Parrilla de Barbeques Galore

Barbeques Galore

Barbeques Galore UN2616ACT Manual de usuario

Barbeques Galore

Barbeques Galore Billabong Manual de usuario

Barbeques Galore

Barbeques Galore Turbo Charcoal BCH14A Manual de usuario

Barbeques Galore

Barbeques Galore Connoisseur 0 Manual de usuario

Barbeques Galore

Barbeques Galore GBBK/GBBKR Manual de usuario

Barbeques Galore

Barbeques Galore Grand Endevator GE3BSSLP Manual de usuario

Barbeques Galore

Barbeques Galore MC2CBL Manual del operador

Barbeques Galore

Barbeques Galore BEEFMASTER V Series Manual del operador

Barbeques Galore

Barbeques Galore KYQ-G41S-G Manual de lista de piezas

Barbeques Galore

Barbeques Galore Billabong Manual de usuario

Barbeques Galore

Barbeques Galore Turbo BTH2616ALP Manual de usuario

Barbeques Galore

Barbeques Galore B3812ALP Manual de usuario

Barbeques Galore

Barbeques Galore MALIBU Guía de instalación

Barbeques Galore

Barbeques Galore Grand Turbo YN662AGLP Manual de usuario

Barbeques Galore

Barbeques Galore ALFRESCO Series Manual del operador

Barbeques Galore

Barbeques Galore Grand Turbo B4019LP Manual de usuario

Barbeques Galore

Barbeques Galore downunder G2DLK Manual de usuario

Barbeques Galore

Barbeques Galore KET57 Manual de usuario

Barbeques Galore

Barbeques Galore Ziegler & Brown TURBO BABERQUE Manual de usuario

Barbeques Galore

Barbeques Galore STS2611ALP Manual de usuario

Barbeques Galore

Barbeques Galore G5CPBIQ Manual de usuario

Barbeques Galore

Barbeques Galore Grand Turbo B3816ALP Manual de usuario

Barbeques Galore

Barbeques Galore Turbo STS Manual de usuario

Barbeques Galore

Barbeques Galore Turbo select G5STR Manual de usuario

Manuales populares de Parrilla de otras marcas

Orbegozo

Orbegozo GR 2300 Manual de usuario

bora

bora PT11 Manual de usuario

Klarstein

Klarstein 10031664 Manual de usuario

Garland

Garland MWE3W Manual de usuario

Char-Broil

Char-Broil 463722714 Manual de usuario

Nexgrill

Nexgrill 720-0830HK Manual de usuario

Kenmore

Kenmore 415.16123800 Manual de usuario

Camp Chef

Camp Chef PG24CLAU Manual de usuario

Tucker Barbecues

Tucker Barbecues GTR Series Instrucciones de montaje

Monogram

Monogram ZGG540NCP1SS Manual de usuario

Equipex

Equipex Sodir Savoy Manual de usuario

Gaggenau

Gaggenau VR 414 610 Manual de usuario

Miele

Miele KM 408-1 Manual de usuario

George Foreman

George Foreman GGR50B Manual de usuario

AOG

AOG T series Manual de usuario

Gorenje

Gorenje TG2000CB Manual de instrucciones

Weber

Weber Genesis Silver-B Permamount NG 051701 Manual de usuario

Glen

Glen SA 3037 Manual de usuario