American Dryer Corp. ML-75DIII Manual de usuario

For replacement parts, contact the reseller

from which the dryer was purchased or

American Dryer Corporation

88 Currant Road

Fall River MA 02720- 781

Telephone: (508) 678-9000 / Fax: (508) 678-9 7

E-mail: techsupport@amdry.com

www.amdry.com

092101MS/mcronan ADC Part No. 1133 3

WARNING: For your safety the

information in this manual must be

followed to minimize the risk of fire or

explosion or to prevent property dama e,

personal injury or death.

Do not store or use asoline or other flammable

vapor and liquids in the vicinity of this or any

other appliance.

WHAT DO YOU DO IF YOU SMELL GAS

* Do not try to li ht any appliance.

* Do not touch any electrical switch; do not use

any phone in your buildin .

* Clear the room, buildin or area of all

occupants.

* Immediately call your as supplier from a

nei hbor's phone. Follow the as supplier's

instructions.

* If you cannot reach your as supplier, call the

fire department.

Installation and service must be performed by a

qualified installer, service a ency or the as

supplier.

AVERTISSEMENT: Assurez-vous de bien

suivre les instructions données dans cette

notice pour réduire au minimum le risque

dincendie ou dexplosion ou pour éviter tout

domma e matériel, toute blessure ou la mort.

Ne pas entreposer ni utiliser dessence ni

dautres vapeurs ou liquides inflammables dans

le voisina e de cet appareil ou de tout autre

appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR

DE GAZ:

* Ne pas tenter dallumer dappareil.

* Ne touchez à aucun interrupteur. Ne pas

vous servir des téléphones se trouvant dans

le bâtiment où vous vous trouvez.

* Évacuez la pièce, le bâtiment ou la zone.

* Appelez immédiatement votre fournisseur de

az depuis un voisin. Suivez les instructions

du fournisseur.

* Si vous ne pouvez rejoindre le fournisseur

de az, appelez le service des incendies.

Linstallation et lentretien doivent être assurés

par un installateur ou un service dentretien

qualifié ou par le fournisseur de az.

ML-75DIII

(Gas/Electric/Steam)

Installation Manual

Retain This Manual In A Safe Place For Future Reference

American Dryer Corporation products embody advanced concepts in engineering, design, and safety. If this product is

properly maintained, it will provide many years of safe, efficient, and trouble-free operation.

ONLY qualified technicians should service this equipment.

OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment or specified in the installation manual included with

the dryer.

The following FOR YOUR SAFETY caution must e posted near the dryer in a prominent location.

ML-75DIII

IMPORTANT NOTE TO PURCHASER

Information must be obtained from your local as supplier on the instructions

to be followed if the user smells as. These instructions must be posted in a

prominent location near the dryer.

FOR YOUR SAFETY

Do not store or use asoline or

other flammable vapors or

liquids in the vicinity of this or

any other appliance.

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser dessence

ni dautres vapeurs ou liquides

inflammables dans le voisina e de cet

appareil ou de yout autre appareil.

We have tried to make this manual as complete as possible and hope you will find it useful. ADC reserves the right to make

changes from time to time, without notice or obligation, in prices, specifications, colors, and material, and to change or

discontinue models.

Important

For your convenience, log the following information

DATE OF PURCHASE ____________________________ MODEL NO. __________________________________________

RESELLERS NAME _______________________________________________________________________________________

Serial Number(s) ________________________________________________________________________________________

________________________________________________________________________________________

Replacement parts can be obtained from your reseller or the ADC factory. When ordering replacement parts from the factory,

you can FAX your order to ADC at (508) 678-9 7 or telephone your order directly to the ADC Parts Department at

(508) 678-9000. Please specify the dryer model number and serial number in addition to the description and part number, so

that your order is processed accurately and promptly.

IMPORTANT

YOU MUST DISCONNECT AND LOCKOUT THE ELECTRIC SUPPLY AND THE GAS

SUPPLY OR THE STEAM SUPPLY BEFORE ANY COVERS OR GUARDS ARE

REMOVED FROM THE MACHINE TO ALLOW ACCESS FOR CLEANING,

ADJUSTING, INSTALLATION, OR TESTING OF ANY EQUIPMENT PER OSHA

(Occupational Safety and Health Administration) STANDARDS.

CHILDREN SHOULD NOT BE ALLOWED TO PLAY ON OR NEAR THE DRYER(S).

WARNING

CHILDREN SHOULD BE SUPERVISED IF NEAR DRYER(S) IN OPERATION.

DRYER(S) SHOULD NE ER BE LEFT UNATTENDED WHILE IN OPERATION.

CAUTION

FOR YOUR SAFETY

DO NOT DRY MOP HEADS IN THE DRYER.

DO NOT USE DRYER IN THE PRESENCE OF DRY CLEANING FUMES.

WARNING

UNDER NO CIRCUMSTANCES sh uld the dryer d r switches, lint d r switch, heat

safety circuit ever be disabled.

Caution: Label all wires prior to

disconnection when servicing controls. Wiring

errors can cause improper operation.

«Attention: Lor des opérations dentretien

des commandes étiqueter tous fils avant

de les déconnecter. Toute erreur de

câblage peut étre une source de danger et

de panne.»

WARNING

The dryer must never be perated with any f the back guards, uter t ps, r service

panels rem ved. PERSONAL INJURY r FIRE COULD RESULT.

IMPORTANT

PLEASE OBSERVE ALL SAFETY PRECAUTIONS displayed n the equipment and/ r

specified in the installati n manual included with the dryer.

Dryer(s) must n t be installed or stored in an area where it will be exposed to water and/or

weather.

The wiring diagram for the dryer is located in the front electrical control box area.

DRYER MUST NEVER BE OPERATED WITHOUT THE LINT FILTER/SCREEN IN

PLACE...EVEN IF AN EXTERNAL LINT COLLECTION SYSTEM IS USED.

WARNING

Table of Contents

SECTION I

IMPORTANT INFORMATION ............................................................................... 3

A. Receivin and Handlin ................................................................................................................. 3

B. Safety Precautions ........................................................................................................................ 4

SECTION II

SPECIFICATIONS/COMPONENT IDENTIFICATION .................................... 6

A. Specifications ............................................................................................................................... 6

B. Component Identification .............................................................................................................. 8

SECTION III

INSTALLATION PROCEDURES ......................................................................... 10

A. Location Requirements ...............................................................................................................10

B. Unpackin /Settin Up .................................................................................................................11

C. Dryer Enclosure Requirements ....................................................................................................12

D. Fresh Air Supply .........................................................................................................................13

E. Exhaust Requirements .................................................................................................................14

F. Electrical Information ..................................................................................................................19

G. Gas Information ..........................................................................................................................27

H. Steam Information ......................................................................................................................30

I. Preparation For Operation/Start-Up ...........................................................................................35

J. Preoperational Tests ...................................................................................................................36

K. Preoperational Instructions ..........................................................................................................38

L. Shut Down Instructions ...............................................................................................................39

SECTION IV

SERVICE/PARTS INFORMATION ...................................................................... 40

A. Service .......................................................................................................................................40

B. Parts ..........................................................................................................................................40

SECTION V

WARRANTY INFORMATION .............................................................................. 41

A. Returnin Warranty Cards ...........................................................................................................41

B. Warranty ....................................................................................................................................41

C. Returnin Warranty Parts ............................................................................................................41

SECTION VI

ROUTINE MAINTENANCE .................................................................................. 43

A. Cleanin .....................................................................................................................................43

B. Adjustments ...............................................................................................................................44

C. Lubrication .................................................................................................................................45

SECTION VII

PROCEDURE FOR FUNCTIONAL CHECK OF REPLACEMENT

COMPONENTS ....................................................................................................... 46

SECTION VIII

REVERSING TIMER SPIN/DWELL ADJUSTMENTS .................................... 48

SECTION I

DATA LABEL INFORMATION ............................................................................. 49

A. Data Label .................................................................................................................................49

SECTION

BURNER AND BASKET (TUMBLER)/LINT CHAMBER MANUAL RESET

HI-LIMIT INSTRUCTIONS ................................................................................... 51

Phase 7 Models Only ....................................................................................................................... 51

Dual Timer Models Only ..................................................................................................................52

SECTION I

FIRE SUPPRESSION SYSTEM (F.S.S.) .............................................................. 53

F.S.S. In Action ....................................................................................................................................53

Installation ............................................................................................................................................54

Water Connections ...............................................................................................................................55

Electrical Requirements ......................................................................................................................... 57

System Reset ........................................................................................................................................ 57

Parts List ..............................................................................................................................................59

SECTION I

IMPORTANT INFORMATION

A. RECEIVING AND HANDLING

The dryer is shipped in a protective stretch wrap cover with protective cardboard corners and top cover (or

optional box) as a means of preventing damage in transit. Upon delivery, the dryer and/or packaging, and

wooden skid should be visually inspected for shipping damage. f any damage whatsoever is noticed, inspect

further before delivering carrier leaves.

Dryers damaged in shipment:

1. ALL dryers should be inspected upon receipt and before they are signed for.

2. f there is suspected damage or actual damage, the truckers receipt should be so noted.

3. f the dryer is damaged beyond repair, it should be refused. Those dryers which were not damaged in a

damaged shipment should be accepted, but the number received and the number refused must be noted

on the receipt.

4. f you determine that the dryer was damaged after the trucker has left your location, you should call the

delivering carriers freight terminal immediately and file a claim. The freight company considers this

concealed damage. This type of freight claim is very difficult to get paid and becomes extremely difficult

when more than a day or two passes after the freight was delivered. t is your responsibility to file freight

claims. Dryer/parts damaged in transit cannot be claimed under warranty.

5. Freight claims are the responsibility of the consignee, and ALL claims must be filed at the receiving end.

ADC assumes no responsibility for freight claims or damages.

6. f you need assistance in handling the situation, please contact the ADC Traffic Manager at (508)

678-9000.

IMPORTANT: The basket (tumbler) section of the dryer must be transported and handled in an

upright position at ALL times.

B. SAFETY PRECAUTIONS

WARNING: For your safety, the information in this manual must be followed to minimize the risk of

fire or explosion or to prevent property damage, personal in ury, or loss of life.

WARNING: The dryer must never be operated with any of the back guard , outer top , or

ervice panel removed. PERSONAL INJURY or FIRE COULD RESULT.

1. DO NOT store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other

appliance.

2. Purchaser/user should consult the local gas supplier for proper instructions to be followed in the event the

user smells gas. The instructions should be posted in a prominent location.

3. WHAT TO DO F YOU SMELL GAS...

a. DO NOT try to light any appliance.

b. DO NOT touch any electrical switch.

c. DO NOT use any phone in your building.

d. Clear the room, building, or area of ALL occupants.

e. mmediately call your gas supplier from a neighbors phone. Follow the gas suppliers instructions.

f. f you cannot reach your gas supplier, call the fire department.

4. nstallation and service must be performed by a qualified installer, service agency, or gas supplier.

5. Dryer(s) must be exhausted to the outdoors.

6. Although ADC produces a very versatile dryer, there are some articles that, due to fabric composition or

cleaning method, should not be dried in it.

WARNING: Dry only water washed fabrics. DO NOT dry articles spotted or washed in dry

cleaning solvents, a combustible detergent, or all purpose cleaner.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry rags or articles coated or contaminated with gasoline, kerosene, oil, paint,

or wax.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry mop heads. Contamination by wax or flammable solvents will create a

fire hazard.

WARNING: DO NOT use heat for drying articles that contain plastic, foam, sponge rubber, or

similarly textured rubber materials. Drying in a heated basket (tumbler) may damage

plastics or rubber and also may be a fire hazard.

7. A program should be established for the inspection and cleaning of lint in the heating unit area, exhaust

ductwork, and inside the dryer. The frequency of inspection and cleaning can best be determined from

experience at each location.

WARNING: The collection of lint in the burner area and exhaust ductwork can create a potential fire

hazard.

8. For personal safety, the dryer must be electrically grounded in accordance with local codes and/or the

National Electrical Code ANS /NFPA NO. 70-LATEST ED T ON or in Canada, the Canadian Electrical

Codes Parts 1 & 2 CSA C22.1-1990 or LATEST ED T ON.

NOTE: Failure to do so will VOID THE WARRANTY.

9. UNDER NO CIRCUMSTANCES should the dryer door switches, lint door switch, heat safety circuit

ever be disabled.

WARNING: PERSONAL INJURY or FIRE COULD RESULT.

10. This dryer is not to be used in the presence of dry cleaning solvents or fumes.

11. Remove articles from the dryer as soon as the drying cycle has been completed.

WARNING: Articles left in the dryer after the drying and cooling cycles have been completed can

create a fire hazard.

12. DO NOT operate steam dryers with more than 125 PS (8.62 bars) steam pressure. Excessive steam

pressure can damage steam coil and/or harm personnel.

13. Replace leaking flexible hoses or other steam fixtures immediately. DO NOT operate the dryer with

leaking flexible hoses. PERSONAL INJURY MAY RESULT.

14. The normal PH level for copper type steam coils must be maintained between a value of 8.5 to 9.5. For

steel type steam coils the PH level must be maintained between a value of 9.5 to 10.5. These limits are set

to limit the acid attack of the steam coils.

IMPORTANT: Coil failure due to improper PH level will VOID THE WARRANTY.

15. READ AND OLLOW ALL CAUTION AND DIRECTION LABELS ATTACHED TO THE

DRYER.

16. For safety, proper operation, and optimum performance, the dryer must not be operated with a load less

than sixty-six percent (66%), 50 pounds (22.67 kg) of its rated capacity.

WARNING: YOU MUST DISCONNECT AND LOCKOUT THE ELECTRIC SUPPLY AND

THE GAS SUPPLY OR THE STEAM SUPPLY BEFORE ANY COVERS OR

GUARDS ARE REMOVED FROM THE MACHINE TO ALLOW ACCESS

FOR CLEANING, ADJUSTING, INSTALLATION, OR TESTING OF ANY

EQUIPMENT PER OSHA (Occupational Safety and Health Administration)

STANDARDS.

SECTION II

SPECIFICATIONS/COMPONENT IDENTIFICATION

A. SPECIFICATIONS

IMPORTANT: Steam dryers must be provided with clean, dry, and regulated 80 PSI +/- 10 PSI

(5.51 bars +/- 0.69 bars) air supply.

NOTE: ADC reserves the right to make changes in specifications at any time without notice or

obligation.

BASKET (TUMBLER) DIAMETER 37” 94 cm

BASKET (TUMBLER) DEPTH 36” 91.5 cm

BASKET (TUMBLER) MOTOR 1 HP* 0.746 kw

DOOR OPENING (DIAMETER) 31-3/8” 79.7 cm

BASKET (TUMBLER) VOLUME 22.4 cu. ft. 0.634 cu. m.

DRYERS PER 20’/40’ CONTAINER 10/20

DRYERS PER 45’/48’ TRUCK 24/24

VOLTAGE AVAILABLE 120-460v 1ø-3ø 50/60 Hz

APPROX. WEIGHT (UNCRATED) 721 lbs. 327 kg

APPROX. WEIGHT (CRATED) 771 lbs. 349.7 kg

HEAT INPUT 200,000 btu/hr 50,400 kcal/hr

AIRFLOW 1,200 cfm 33.98 cmm

INLET PIPE SIZE 3/4” N.P.T.**

VOLTAGE AVAILABLE 208-460v 1ø-3ø 50/60 Hz

APPROX. WEIGHT (UNCRATED) 721 lbs. 327 kg

APPROX. WEIGHT (CRATED) 771 lbs. 349.7 kg

AIRFLOW 1,200 cfm 33.98 cmm

VOLTAGE AVAILABLE 120-460v 1ø-3ø 50/60 Hz

APPROX. WEIGHT (UNCRATED) 757 lbs. 343.4 kg

APPROX. WEIGHT (CRATED) 807 lbs. 366.1 kg

AIRFLOW 1,350 cfm 38.23 cmm

COMPRESSED AIR VOLUME 0.75 cfh 0.02 cmh

AIR CONNECTION 1/8” F.P.T.

STEAM CONSUMPTION BOILER HP NORMAL

LOAD

238.7 lbs./hr 108.3 kg/hr 7

OPERATING STEAM PRESSURE STEAM SUPPLY STEAM RETURN

125 PSI max 8.6 bars 1” F.P.T. 1” F.P.T.

Shaded areas are stated in metric equivalents

* For non-reversing models.

** A minimum of 3/4-inch pipe must be supplied to the gas inlet for each dryer.

Gas

ElectricSteam

Tabla de contenidos

Otros manuales de Secadora de American Dryer Corp.

American Dryer Corp.

American Dryer Corp. AD-100 Manual de usuario

American Dryer Corp.

American Dryer Corp. ML-122 Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-120ES II Manual de usuario

American Dryer Corp.

American Dryer Corp. Gas/HSI & Steam ID-120 Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-30V Manual de usuario

American Dryer Corp.

American Dryer Corp. Non-Tilting AD-200 Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-115ES II Manual de usuario

American Dryer Corp.

American Dryer Corp. ADG-215 Manual de usuario

American Dryer Corp.

American Dryer Corp. Phase 7 Gas/Steam AD-464 Manual de usuario

American Dryer Corp.

American Dryer Corp. PHASE 7 OPL Manual de usuario

American Dryer Corp.

American Dryer Corp. Gas DSI/Electric/ Steam AD-78 II Manual de usuario

American Dryer Corp.

American Dryer Corp. ML-96D Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-285 Manual de usuario

American Dryer Corp.

American Dryer Corp. ML-78 Phase 7 (DSI) Manual de usuario

American Dryer Corp.

American Dryer Corp. ES35 Guía del administrador

American Dryer Corp.

American Dryer Corp. AD-24 Phase 7 Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-120ES II Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-236 Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-410 Manual de usuario

American Dryer Corp.

American Dryer Corp. ML-175 Manual de usuario

American Dryer Corp.

American Dryer Corp. Gas/Electric/Steam AD-75HS Manual de usuario

American Dryer Corp.

American Dryer Corp. ML-122 Manual de usuario

American Dryer Corp.

American Dryer Corp. AD-81 Manual de usuario

American Dryer Corp.

American Dryer Corp. Dyer AD-26 Manual de usuario

Manuales populares de Secadora de otras marcas

Bosch

Bosch WTA79200GB Manual de usuario

Amana

Amana W10233410A Manual de usuario

Miele

Miele TWH 780 WP Manual de usuario

Asko

Asko T760 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Manual de usuario

Bosch

Bosch Logixx 10 WTB76556GB Hoja de especificaciones

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manual de instrucciones

Electrolux

Electrolux EW2H328R2 Manual de usuario

Beko

Beko DS8433RX1M Manual de usuario

Dawlance

Dawlance Spinner DS 6000 C Manual de usuario

Electrolux

Electrolux TP5080TW Manual de usuario

AEG

AEG TR838P4OB Manual de usuario

Indesit

Indesit IDV 75 Manual de usuario

Infiniton

Infiniton SD-DG85C Manual de usuario

BOMANN

BOMANN WT 5019 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Manual de usuario

Asko

Asko T793C Manual de usuario

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manual de usuario