Advantech PCM-5864 Manual de usuario

PCM-5864/E/L

All-in-one multimediaPentium®

processor-based single board

computer with audio, SVGA,

Ethernet and PCI expansion slot.

User's Manual

This document is copyrighted, 1999. All rights are reserved. The

original manufacturer reserves the right to make improvements to the

products described in this manual at any time without notice.

No part of this manual may be reproduced, copied, translated or

transmitted in any form or by any means without the prior written

permission of the original manufacturer. Information provided in this

manual is intended to be accurate and reliable. However, the original

manufacturer assumes no responsibility for its use, nor for any

infringements upon the rights of third parties that may result from

such use.

For more information on this and other Advantech products, please

visit our websites at: http://www.advantech.com

http://www.advantech.com/epc

For technical support and service, please visit our support website at:

http://support.advantech.com

This manual is for the PCM-5864, PCM-5864E, and PCM-5864L.

Part No. 2006586402

2nd Edition Printed in Taiwan June 2000

Acknowledgments

AMD is a trademark of Advanced Micro Devices, Inc.

Award is a trademark of Award Software International, Inc.

C&T is a trademark of Chips and Technologies, Inc.

Cyrix is a trademark of Cyrix Corporation.

IBM, PC/AT, PS/2 and VGA are trademarks of International

Business Machines Corporation.

Intel and Pentium are trademarks of Intel Corporation.

Microsoft Windows®is a registered trademark of Microsoft Corp.

RTL is a trademark of Realtek Semi-Conductor Co., Ltd.

SiS is a trademark of Silicon Integration Systems Corporation

UMC is a trademark of United Microelectronics Corporation.

Creative is a trademark of Creative Technology LTD.

All other product names or trademarks are properties of their respec-

tive owners.

Packing list

Before you begin installing your card, please make sure that the

following materials have been shipped:

•1 PCM-5864/E/L all-in-one single board computer

• 1 CD disk for utility and drivers

• 1 startup manual

• 1 CPU cooling fan

If any of these items are missing or damaged, contact your distributor

or sales representative immediately.

Please refer to Appendix E, Section E.1 for the optional interface

wiring kit.

The PCM-5864 Series Model Comparison Table

ni-oediVtuo-VTSDVLoiduA

4685MCP XXXX

E4685MCP X

L4685MCP

Contents

Chapter 1 General Information ....................1

1.1 Introduction.................................................................................... 2

Highly integrated multimedia SBC................................................. 2

1.2 Features........................................................................................... 3

1.3 Specifications.................................................................................. 4

1.3.1 Standard SBC functions......................................................... 4

1.3.2 PCI SVGA/flat panel interface .............................................. 5

1.3.3 LVDS interface (PCM-5864 only) ........................................ 5

1.3.4 Audio function (PCM-5864 only) ......................................... 6

1.3.5 Video function (PCM-5864 only) ......................................... 6

1.3.6 PCI bus Ethernet interface ..................................................... 6

1.3.7 Mechanical and environmental .............................................. 6

1.4 Board layout and dimensions ....................................................... 7

Chapter 2 Installation....................................9

2.1 Jumpers ........................................................................................ 10

2.2 Connectors.................................................................................... 11

2.3 Locating jumpers ......................................................................... 12

2.4 Locating connectors..................................................................... 13

2.4.1 Component side ................................................................... 13

2.4.2 Solder side............................................................................ 14

2.5 Setting jumpers ............................................................................ 15

2.6 CPU installation and upgrading ................................................ 16

2.6.1 Installing a CPU in the PGA type socket ............................ 16

2.6.2 System clock setting (J5, J9, and J10) ................................. 17

2.6.3 CPU voltage setting (J3) ...................................................... 19

2.6.4 CMOS clear (J7) .................................................................. 20

2.6.5 Buzzer enable/disable (J18) ................................................. 20

2.7 Installing system memory (DIMMs) .......................................... 21

2.7.1 Installing DIMMs ................................................................ 21

2.8 IDE hard drive connector (CN12).............................................. 21

2.8.1 Connecting the hard drive.................................................... 22

2.8.2 CompactFlash (CN501) ....................................................... 22

2.9 Floppy drive connector (CN10) .................................................. 23

2.9.1 Connecting the floppy drive ................................................ 23

2.10 Parallel port connector (CN14) .................................................. 24

2.11 Keyboard and PS/2 mouse connector (CN9)............................. 24

2.12 Front panel connector (CN15).................................................... 25

2.12.1 Speaker............................................................................... 25

2.12.2 LED interface..................................................................... 25

2.12.3 Watchdog output................................................................ 25

2.12.4 Reset switch ....................................................................... 25

2.13 Power connectors (CN1, CN2, CN8, CN22) .............................. 26

2.13.1 Peripheral power connector, -5 V, -12 V (CN22) ............. 26

2.13.2 Main power connector, +5 V, +12 V (CN8) ..................... 26

2.13.3 CPU Fan power supply connector (CN1).......................... 26

2.13.4 Motherboard fan power supply connector (CN2) ............. 26

2.14 ATX power control connector (JP1, J1).................................... 27

2.14.1 ATX feature connector (J1) and soft power switch

connector (JP1) .................................................................. 27

2.15 IR connector (CN17).................................................................... 28

2.16 Audio interfaces (CN4, CN6, CN7, CN502) (PCM-5864 only) 28

2.16.1 Audio connector (CN4) ..................................................... 28

2.16.2 CD audio input connector (CN6)....................................... 28

2.16.3 Aux line-in connector (CN7) ............................................. 28

2.16.4 Speaker-out connector (CN502) ........................................ 28

2.16.5 Audio power source setting (J23) ...................................... 29

2.17 COM port connector (CN23) ...................................................... 29

2.17.1 COM2 RS-232/422/485 setting (J19, J20, J21) ................ 29

2.17.2 COM3/COM4 RI pin setting (J11, J12) ............................ 30

2.17.3 COM1/COM2 RI pin setting (J14, J15) ............................ 31

2.18 VGA interface connections ......................................................... 32

2.18.1 CRT display connector (CN18) ......................................... 32

2.18.2 Flat panel display connector (CN20) ................................. 32

2.18.3 Extension flat panel connector (CN21) ............................. 32

2.18.4 LCD power setting (J16) ................................................... 33

2.19 Ethernet configuration ................................................................ 34

2.19.1 100Base-T connector (CN3) .............................................. 34

2.19.2 Network boot ..................................................................... 35

2.20 Watchdog timer configuration ................................................... 35

2.20.1 Watchdog timer action (JP2) ............................................. 35

2.21 USB connectors (CN16)............................................................... 36

2.22 Video interfaces (CN19, CN30) (PCM-5864 only).................... 37

Chapter 3 Software Configuration.............39

3.1 Introduction.................................................................................. 40

3.2 Connections for five standard LCDs ......................................... 40

3.2.1 Connections to Sharp LM64183P, LM64P89

(640 x 480 DSTN MONO LCD)......................................... 40

3.2.2 Connections to PLANAR EL (640 x 480 AD4 EL)............ 41

3.2.3 Connections to Toshiba LTM10C042

(640 x 480 TFT color LCD) ................................................ 42

3.2.4 Connections to Sharp LM64C142

(640 x 480 DSTN color LCD)............................................. 43

3.2.5 Connections to Toshiba LTM12C275A

(800 x 600 TFT color LCD) ................................................ 44

3.3 Ethernet software configuration ................................................ 45

Chapter 4 Award BIOS Setup.....................47

4.1 System test and initialization ...................................................... 48

4.1.1 System configuration verification........................................ 48

4.2 AWARD BIOS setup ................................................................... 49

4.2.1 Entering setup ...................................................................... 49

4.2.2 Standard CMOS setup ......................................................... 50

4.2.3 BIOS features setup ............................................................. 51

4.2.4 Chipset features setup .......................................................... 52

4.2.5 Power management setup .................................................... 53

4.2.6 PnP/PCI configuration ......................................................... 54

4.2.7 Integrated peripherals .......................................................... 55

4.2.8 Load BIOS defaults ............................................................. 56

4.2.9 Change password ................................................................. 57

4.2.10 Auto detect hard disk ......................................................... 58

4.2.11 Save & exit setup ............................................................... 58

4.2.12 Exit without saving ............................................................ 58

Chapter 5 PCI SVGA Setup ........................59

5.1 Before you begin .......................................................................... 60

5.2 Introduction.................................................................................. 60

5.2.1 Chipset ................................................................................. 60

5.2.2 Display memory................................................................... 61

5.2.3 Display types........................................................................ 61

5.3 Installation of SVGA driver........................................................ 61

5.3.1 Installation for Windows 95/98 ........................................... 62

5.3.2 Installation for Windows 3.1 ............................................... 65

5.3.3 Installation for Windows NT ............................................... 67

5.4 Further information .................................................................... 70

Chapter 6 Video...........................................71

6.1 Introduction.................................................................................. 72

6.2 Installation of video driver ......................................................... 72

6.2.1 Installation for Windows 95/98 ........................................... 73

6.3 Installation of Chips-TV utility .................................................. 75

Chapter 7 Audio ..........................................77

7.1 Introduction.................................................................................. 78

7.2 Installation of audio driver ......................................................... 78

7.2.1 Installation for Windows 95/98/NT..................................... 79

Chapter 8 PCI Bus Ethernet Interface .......81

8.1 Introduction.................................................................................. 82

8.2 Installation of Ethernet driver.................................................... 82

8.2.1 Installation for MS-DOS and Windows 3.1 ........................ 82

8.2.2 Installation for Windows 95 ................................................ 83

8.2.3 Installation for Windows NT ............................................... 85

8.3 Further information .................................................................... 87

Appendix A Programming the Watchdog

Timer.........................................................89

A.1 Programming the watchdog timer ............................................. 90

Appendix B Installing PC/104 Modules .....93

B.1 Installing PC/104 modules .......................................................... 94

Appendix C Pin Assignments ....................97

CPU fan power connector (CN1).......................................................... 98

Motherboard fan connector (CN2) ...................................................... 98

Ethernet 10/100Base-T connector (CN3) ............................................. 99

Audio connector (CN4)........................................................................ 100

Speaker out connector (CN502).......................................................... 100

CD audio input connector (CN6)........................................................ 101

Aux line-in connector (CN7) ............................................................... 101

Main power connector (CN8) ............................................................. 102

Keyboard and PS/2 mouse connector (CN9) ..................................... 103

Floppy disk drive connector (CN10) .................................................. 104

PC/104 connectors (CN11) .................................................................. 105

IDE HDD connector (CN12) ............................................................... 106

Parallel port connector (CN14)........................................................... 108

Front panel connector (CN15) ............................................................ 109

USB connector (CN16) ........................................................................ 109

IR connector (CN17) ............................................................................ 110

CRT display connector (CN18) .......................................................... 110

Video-out connector (CN19) ............................................................... 111

Flat panel connector (CN20) ............................................................... 112

Ext. flat panel connector (CN21) ........................................................ 113

Peripheral power connector (CN22) .................................................. 113

COM port connector (CN23) .............................................................. 114

Video-in (capture) connector (CN30)................................................. 115

CompactFlash card connector (CN501) ............................................ 116

ATX power feature connector (J1)..................................................... 117

ATX soft power switch connector (JP1) ............................................ 117

LVDS connector (JP3) ......................................................................... 118

Appendix D System Assignments...........119

D.1 System I/O ports ........................................................................ 120

D.2 1st MB memory map ................................................................. 121

D.3 DMA channel assignments........................................................ 121

D.4 Interrupt assignments ............................................................... 122

Appendix E Optional Extras.....................123

E.1 PCM-10586-3 cable kit for PCM-5864/L ................................ 124

E.2 Optional LCD cables for 9.4" MONO, 10.4" TFT LCD

panel (CN20) .............................................................................. 125

E.3 Optional USB cable (CN16) ...................................................... 125

E.4 Optional IrdA adapter (CN17) ................................................. 125

E.5 Optional LVDS cables (JP3) ..................................................... 125

E.6 Optional PCI riser cards ........................................................... 126

Appendix F Mechanical Drawings ...........127

F.1 Component side.......................................................................... 128

F.2 Solder side................................................................................... 129

Tables

Table 2-1: Jumpers ............................................................................................... 10

Table 2-2: Connectors .......................................................................................... 11

Table 2-3: CPU speed references ......................................................................... 17

Table 2-4: System/PCI clock setting (J9)............................................................. 17

Table 2-5: CPU frequency ratio (J5) .................................................................... 18

Table 2-6: PCI/clock setting (J10) ....................................................................... 18

Table 2-7: CPU voltage setting (J3) ..................................................................... 19

Table 2-8: CMOS clear (J7) ................................................................................. 20

Table 2-9: Buzzer enable/disable (J18) ................................................................ 20

Table 2-10: CompactFlash enable/disable (J13) .................................................. 22

Table 2-11: Audio power source setting .............................................................. 29

Table 2-12: COM2 RS-232/422/485 settings (J19, J20, J21).............................. 30

Table 2-13: Serial port default settings ................................................................ 30

Table 2-14: COM3 RI pin settings (J12) ............................................................. 31

Table 2-15: COM4 RI pin settings (J11) ............................................................. 31

Table 2-16: COM1 RI pin settings (J14) ............................................................. 31

Table 2-17: COM2 RI pin settings (J15) ............................................................. 31

Table 2-18: LCD power setting............................................................................ 33

Table 2-19: LCD shift clock setting ..................................................................... 33

Table 2-20: LCD backlight signal setting (J8) ..................................................... 34

Table 2-21: Watchdog timer action (JP2) ............................................................ 35

Table 2-22: TV-out format select (J25)................................................................ 37

Table 3-1: Connections to Sharp LM64183P & LM64P89 ................................. 40

Table 3-2: Connections to PLANAR EL ............................................................. 41

Table 3-3: Connections to Toshiba LTM10DC042 ............................................. 42

Table 3-4: Connections to Sharp LM64C142 ...................................................... 43

Table 3-5: Connections to Toshiba LTM12C2775A ........................................... 44

Table C-1: CPU fan power connector (CN1)....................................................... 98

Table C-2: Motherboard fan connector (CN2)..................................................... 98

Table C-3: Ethernet 10/100Base-T connector (CN3) .......................................... 99

Table C-4: Audio connector (CN4).................................................................... 100

Table C-5: Speaker out connector (CN502)....................................................... 100

Table C-6: CD audio input connector (CN6) ..................................................... 101

Table C-7: Aux line-in connector (CN7) ........................................................... 101

Table C-8: Main power connector (CN8) .......................................................... 102

Table C-9: Keyboard and mouse connector (CN9)............................................ 103

Table C-10: Floppy disk drive connector (CN10) ............................................. 104

Table C-11: PC/104 connectors (CN11) ............................................................ 105

Table C-12: IDE HDD connector (CN12) ......................................................... 107

Table C-13: Parallel port connector (CN14) ...................................................... 108

Table C-14: Front panel connector (CN15) ....................................................... 109

Table C-15: USB connector (CN16) .................................................................. 109

Table C-16: IR connector (CN17)...................................................................... 110

Table C-17: CRT display connector (CN18) ..................................................... 110

Table C-18: Video-out connector (CN19) ......................................................... 111

Table C-19: Flat panel connector (CN20).......................................................... 112

Table C-20: Ext. flat panel connector (CN21) ................................................... 113

Table C-21: Peripheral power connector (CN22) .............................................. 113

Table C-22: COM port connector (CN23) ......................................................... 114

Table C-23: DSUB-9 connector pin assignments .............................................. 115

Table C-24: Video-in (capture) connector (CN30) ............................................ 115

Table C-25: CompactFlash card connector (CN501)......................................... 116

Table C-26: ATX power feature connector (J1) ................................................ 117

Table C-27: ATX soft power switch connector (JP1)........................................ 117

Table C-28: LVDS connector (JP3) ................................................................... 118

Table D-1: System I/O ports .............................................................................. 120

Table D-2: 1st MB memory map ....................................................................... 121

Table D-3: DMA channel assignments .............................................................. 121

Table D-4: Interrupt assignments ....................................................................... 122

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Placa madre de Advantech

Advantech

Advantech AIMB-787 Manual de instalación y operación

Advantech

Advantech ASMB-784 Manual de instalación y operación

Advantech

Advantech AIMB-787 Manual de usuario

Advantech

Advantech AIMB-701 LGA1155 Manual de usuario

Advantech

Advantech PCM-9588 Manual de instalación y operación

Advantech

Advantech ROM-DB3900 Manual de usuario

Advantech

Advantech SOM-DB5920 A1 Manual de usuario

Advantech

Advantech AKMB-G41M Manual de usuario

Advantech

Advantech AIMB-226 Manual de usuario

Advantech

Advantech PCA-6752 Manual de instalación y operación

Advantech

Advantech PCA-6155V Manual de instalación y operación

Advantech

Advantech AIMB-273 Manual de usuario

Advantech

Advantech UPGRD-KIT-48UXP Manual de usuario

Advantech

Advantech AIMB-286 Manual de usuario

Advantech

Advantech PCI-7030 Manual de instalación y operación

Advantech

Advantech PCA-6277V-00A1 Manual de usuario

Advantech

Advantech PCA-6029 Manual de usuario

Advantech

Advantech AIMB-760 Manual de instalación y operación

Advantech

Advantech SOM-7567 Manual de usuario

Advantech

Advantech RSB-4210 Evaluation Kit Manual de usuario

Advantech

Advantech PCM-9365 Manual de usuario

Advantech

Advantech AIMB-706 Manual de usuario

Advantech

Advantech AIMB-502 Manual de usuario

Advantech

Advantech POD-6552 Manual de instalación y operación

Manuales populares de Placa madre de otras marcas

DFI

DFI SD170 Manual de usuario

ASROCK

ASROCK ROMED8-2T Manual de usuario

Asus

Asus P2L97A Manual de usuario

Winmate

Winmate IC70 Manual de usuario

Asus

Asus MES-B Manual de usuario

Grantech

Grantech SYS8F377VGGA-3OMN Manual de usuario

Telit Wireless Solutions

Telit Wireless Solutions SL869-3DR Manual de usuario

Gigabyte

Gigabyte GA-9IVDT Manual de usuario

Texas Instruments

Texas Instruments ADS8372EVM Manual de usuario

Commell

Commell MS-C73 Manual de usuario

IBT Technologies

IBT Technologies MB860 Manual de usuario

Nvidia

Nvidia TEGRA DG-04927-001_V01 Manual de usuario

Biostar

Biostar M7VIT Bravo Instrucciones de funcionamiento e instalación

Intel

Intel D33217CK Manual de usuario

Asus

Asus F1A55-M LX PLUS R2.0 Manual de usuario

EPC

EPC EPC9147C Manual de usuario

Asus

Asus EX-B760M-V5 D4 Manual de usuario

EPOX

EPOX MU-8KHA0010 Manual de usuario