Advantech PCM-5825 Manual de usuario

PCM-5825

NS Geode Single Board

Computer with CPU, 4 COMs,

VGA/ CD, Ethernet, and

Audio Interface

This document is copyrighted, 2002. All rights are reserved. The

original manufacturer reserves the right to make improvements to

the products described in this manual at any time without notice.

No part of this manual may be reproduced, copied, translated or

transmitted in any form or by any means without the prior written

permission of the original manufacturer. Information provided in

this manual is intended to be accurate and reliable. However, the

original manufacturer assumes no responsibility for its use, nor for

any infringements upon the rights of third parties which may result

from its use.

Acknowledgements

AMD is a trademark of Advanced Micro Devices, Inc.

Award is a trademark of Award Software International, Inc.

IBM, PC/AT, PS/2 and VGA are trademarks of International

Business Machines Corporation.

Intel and Pentium are trademarks of Intel Corporation.

Microsoft Windows®is a registered trademark of Microsoft Corp.

RTL is a trademark of Realtek Semi-Conductor Co., Ltd.

C&T is a trademark of Chips and Technologies, Inc.

UMC is a trademark of United Microelectronics Corporation.

Winbond is a trademark of WinbondElectronics Corp.

NS is a trademark of National Semiconductor Inc.

CHRONTEL is a trademark of Chrontel Inc.

For more information on this and other Advantech products please

visit our website at: http://www.advantech.com

http://www.advantech.com/epc

For technical support and service for please visit our support

website at: http://support.advantech.com

This manual is for the PCM-5825 Rev. A201

Part No. 2006582501

2nd Edition, Printed in Taiwan, May 2004

iii

Packing list

Before you begin installing your card, please make sure that the

following materials have been shipped:

•1 PCM-5825Series all-in-one single board computer

• 1 startup manual

• 1 utility disk/CD, driver, and manual (in PDF format)

• 1 2.5" IDE flat cable, 44-pin to 44-pin (part no. 1701440351)

• 1 keyboard / PS2 mouse cable (part no. 1700060201)

• 1 secondary serial port cable (part no. 1701140201)

• 1 parallel cable (part no. 1700260650)

• 1 floppy cable, for 3.5" FDD only (part no. 1701340603)

• 1 audio cable (part no. 1700160160)

• 1 USB cable (part no. 1703100260)

If any of these items are missing or damaged, contact your distribu-

tor or sales representative immediately.

Contents

Chapter 1 General nformation ................................. 1

1.1 Introduction.................................................................. 2

1.2 Features ........................................................................ 3

1.3 Specifications ............................................................... 4

1.3.1 Standard SBC functions ........................................ 4

1.3.2 Local-bus flat panel/VGA interface ...................... 5

1.3.3 Audio function ....................................................... 5

1.3.4 Ethernet interface .................................................. 5

1.3.5 Solid state disk ....................................................... 6

1.3.6 Mechanical and environmental .............................. 6

1.4 Board layout and dimensions .................................... 7

Figure 1-1: PCM-5825 dimensions ............................................ 7

Chapter 2 nstallation ................................................ 9

2.1 Jumpers and connectors .............................................. 10

Table 2-1: Jumpers .................................................................. 10

Table 2-2: Connectors ..............................................................11

2.2 Locating jumpers....................................................... 12

Figure 2-1: Jumpers PCM-5825 .............................................. 12

2.3 Locating connectors ................................................. 13

2.3.1 Component side .................................................... 13

Figure 2-2: Connectors - component side .............................. 13

Figure 2-3: Connectors - solder side...................................... 13

2.4 Setting jumpers.......................................................... 14

2.4.1 Introduction...........................................................14

2.4.2 Settings details ...................................................... 14

2.5 Safety precautions ..................................................... 15

J1: Audio power source ........................................................ 15

J2: Clear CMOS ..................................................................... 15

J3: COM2 selector .................................................................. 15

J4: Watchdog timer ................................................................ 15

J5: Buzzer ............................................................................. 15

J6: LCD power ....................................................................... 15

2.6 Installing DRAM (SODIMMs) ................................. 16

2.6.1 Introduction...........................................................16

2.6.2 Installing SODIMMs ............................................16

2.7 IDE hard drive connector (CN15)............................. 17

2.7.1 Connecting the hard drive .................................... 17

2.8 CompactFlash™ disk (CN24) .................................... 18

2.9 Floppy drive connector (CN4) ................................... 18

2.9.1 Connecting the floppy drive ..................................18

2.10 Parallel port connector (CN3) ................................. 19

2.11 Keyboard and PS/2 mouse connector (CN21) ....... 19

2.12 Power connectors ...................................................... 20

2.12.1 Main power connector +5 V, +12 V (CN13) .....20

2.12.2 Auxilary power connector (CN1).......................20

2.12.3 CPU fan power connector (CN6) ......................20

2.13 IR connector (CN12).................................................. 20

2.14 Audio interfaces (CN5, CN9, J1) ............................. 20

2.14.1 Audio connector (CN5) ...................................... 20

2.14.2 CD audio input connector (CN9) ....................... 21

2.14.3 Audio power source setting (J1) ........................ 21

Table 2-3: Audio power source setting .................................. 21

2.15 Serial ports (CN19, CN18, CN2) .............................. 21

2.15.1 COM1 RS-232 port (CN19) ...............................21

2.15.2 COM2 RS-232/422/485 selection (CN18) ......... 22

Table 2-4: COM2 selection (J3) ............................................... 22

2.15.3 COM3/COM4 RS-232 port (CN2) .................... 22

2.15.4 Share IRQ ..........................................................22

Table 2-5: Serial port default settings ..................................... 22

2.16 VGA interface connections ....................................... 23

2.16.1 CRT display connector (CN22) .......................... 23

2.16.2 Flat panel display connector (CN16) .................... 23

2.16.3 LCD power setting (J6)......................................23

Table 2-6: LCD power setting ................................................. 23

2.17 Ethernet interface connections ................................ 24

2.17.1 100Base-T RJ-45 connector (CN20) .................24

2.18 Ethernet LED and HDD/power LEDs ..................... 24

2.18.1 LED1 (Ethernet LED) ....................................... 24

Table 2-7: Ethernet LED setup ................................................ 24

2.18.2 LED2 (Power and HDD LED)..........................24

Table 2-8: HDD/power LED setup ........................................... 24

2.19 Watchdog timer configuration ................................... 25

2.19.1 Watchdog timer action (J4) ................................25

Table 2-9: Watchdog timer action ........................................... 25

2.20 USB connectors (CN7) .............................................. 25

Chapter 3 Software Configuration ......................... 27

3.1 Introduction ................................................................... 28

3.2 Utility CD disk ............................................................... 28

Figure 3-1: Contents of the PCM-5825 utility disk .................. 28

3.3 VGA display software configuration ........................... 29

Figure 3-2: B OS VGA setup screen ...................................... 29

3.4 Connections for two standard LCDs .......................... 31

3.4.1 Connections for 640 x 480 TFT color LCD .........31

3.4.2 Connections for 800 x 600 TFT color LCD .........32

3.5 Ethernet interface configuration ................................. 33

Chapter 4 Award B OS Setup .................................. 35

4.1 System test and initialization ....................................... 36

4.1.1 System configuration verification .........................36

4.2 Award BIOS setup ........................................................ 37

4.2.1 Entering setup .......................................................37

Figure 4-1: B OS setup program initial screen........................ 37

4.2.2 Standard CMOS setup ......................................... 38

Figure 4-2: CMOS setup screen ............................................. 38

4.2.3 BIOS features setup ............................................. 39

Figure 4-3: B OS features setup ............................................. 39

4.2.4 Chipset features setup ..........................................40

Figure 4-4: Chipset features setup ......................................... 40

4.2.5 Power management setup ....................................41

Figure 4-5: Power management setup ................................... 41

4.2.6 PnP/PCI configuration ......................................... 42

Figure 4-6: PnP/PC configuration ........................................... 42

4.2.7 Integrated peripherals ...........................................43

Figure 4-7: ntegrated peripherals .......................................... 43

4.2.8 Load BIOS defaults ............................................. 44

Figure 4-8: Load B OS defaults screen .................................. 44

4.2.9 Change password .................................................45

4.2.10 Auto detect hard disk ......................................... 46

Figure 4-9: DE HDD auto detection screen ............................ 46

vii

4.2.11 Save & exit setup ............................................... 46

4.2.12 Exit without saving ............................................. 46

Chapter 5 SVGA Setup............................................. 47

5.1 Introduction ................................................................... 48

5.1.1 Chipset .................................................................. 48

5.1.2 Display memory ................................................... 48

5.2 Installation of SVGA driver ......................................... 49

5.2.1 Installation for Windows 3.1 ................................. 50

5.2.2 Installation for Cyrix MediaGX ............................53

5.2.3 Installation for Windows NT ................................ 57

5.3 Further information ...................................................... 62

Chapter 6 Audio ....................................................... 63

6.1 Introduction ................................................................... 64

6.2 Installation of audio driver .......................................... 64

6.2.1 Installation for Windows 95/98 .............................65

6.2.2 Installation for Windows NT ................................ 69

Chapter 7 PC Bus Ethernet nterface .................... 73

7.1 Introduction ................................................................... 74

7.2 Installation of Ethernet driver .................................... 74

7.2.1 Installation for MS-DOS and Windows 3.1 ..........74

7.2.2 Installation for Windows 95/98 .............................75

7.2.3 Installation for Windows NT ................................ 78

7.3 Further information ...................................................... 81

Appendix A Pin Assignments ................................. 83

A.1 CRT display connector (CN22) .................................. 84

Table A-1: CRT display connector .......................................... 84

A.2 COM2 RS-232/422/485 serial port (CN18) ............. 84

Table A-2: COM2 RS-232/422/485 series port ....................... 84

A.3 Keyboard and mouse connnector (CN21) ................ 85

Table A-3: Keyboard and mouse connector .......................... 85

A.4 Main power connector (CN3) .................................... 85

Table A-4: Main power connector .......................................... 85

A.5 IDE hard drive connector (CN15) ............................. 86

Table A-5: DE hard drive connector ....................................... 86

viii

A.6 COM1 RS-232 serial port (CN19) ............................ 86

Table A-6: COM1 RS-232 serial port ....................................... 86

A.7 COM3/COM4 Connector (CN2) ............................. 87

Table a-7: COM3/ COM4 RS-232 series Ports ........................ 87

A.8 Ethernet 100Base-T connector (CN20) ................... 87

Table A-8: Ethernet 100Base-T connector ............................. 87

A.9 Auxilary peripheral power connector (CN1) ........... 88

Table A-9: Peripheral power connector ................................. 88

A.10 Floppy drive connector (CN4) ................................. 88

Table A-10: Floppy drive connector ....................................... 88

A.11 Parallel port connector (CN3) .................................. 89

Table A-11: Parallel port connector ......................................... 89

A.12 IR connector (CN12) ................................................. 90

Table A-12: R connector ........................................................ 90

A.13 USB connector (CN7) ............................................... 90

Table A-13: USB connector .................................................... 90

A.14 Audio connector (CN5) ............................................. 90

Table A-14: Audio connector .................................................. 90

A.15 CD audio connector (CN9) ....................................... 91

Table A-15: CD audio connector ............................................. 91

A.16 CPU fan power connector (CN6) ............................. 91

Table A-16: CPU fan power connector .................................. 91

A.17 18-bit LCD display connector (CN16) .................... 92

Table A-17: Flat panel display connector ............................... 92

A.18 CompactFlash™ connector (CN24) ........................ 93

Table A-18: CompactFlash™ card connector (CN24) ........... 93

Appendix B System Assignments ......................... 95

B.1 System I/O ports .......................................................... 96

Table B-1: System /O ports .................................................... 96

B.2 DMA channel assignments......................................... 97

Table B-2: DMA channel assignments .................................... 97

B.3 Interrupt assignments ................................................. 98

Table B-3: nterrupt assignments ............................................ 98

B.4 1st MB memory map ................................................... 99

Table B-4: 1st MB memory map .............................................. 99

Appendix C nstalling PC/104 Modules................ 101

C.1 Installing PC/104 modules ........................................ 102

Figure C-1: PC/104 module mounting diagram ...................... 103

Figure C-2: PC/104 module dimensions (mm) (±0.1) ............ 103

Table C-1: PC/104 connectors (CN14) ................................. 104

Appendix D Programming the Watchdog Timer . 105

D.1 Programming the watchdog timer ........................... 106

Appendix E Mechanical Drawings ....................... 109

E.1 Component side .......................................................... 110

E.2 Solder side ................................................................... 111

Tabla de contenidos

Otros manuales de Placa madre de Advantech

Advantech

Advantech AIMB-252 Manual de usuario

Advantech

Advantech AIMB-232G2-U7A1E Manual de usuario

Advantech

Advantech MIO-2270 Manual de usuario

Advantech

Advantech AIMB-769 Manual de instalación y operación

Advantech

Advantech PCA-6009 Manual de usuario

Advantech

Advantech AIMB-581 Manual de usuario

Advantech

Advantech RS-200-RPS-D Manual de usuario

Advantech

Advantech AIMB-744 Series Manual de usuario

Advantech

Advantech PCI-7031 Manual de usuario

Advantech

Advantech PCM-9365 Manual de usuario

Advantech

Advantech SIMB-U01 Manual de usuario

Advantech

Advantech MIC-3359 Manual de usuario

Advantech

Advantech SIMB-M22 Manual de instalación y operación

Advantech

Advantech PCA-6753F Manual de usuario

Advantech

Advantech PCM-9381 Manual de instalación y operación

Advantech

Advantech PCM-4862 Manual de instalación y operación

Advantech

Advantech AIMB-701 LGA1155 Manual de instalación y operación

Advantech

Advantech PCA-6155V Manual de instalación y operación

Advantech

Advantech PCM-9386 Manual de instalación y operación

Advantech

Advantech AIMB-580 Manual de usuario

Advantech

Advantech GMB-910 Manual de usuario

Advantech

Advantech AIMB-766 Manual de usuario

Advantech

Advantech RSB-4221 Manual de usuario

Advantech

Advantech PCE-7214 Manual de usuario

Manuales populares de Placa madre de otras marcas

DFI

DFI SD170 Manual de usuario

ASROCK

ASROCK ROMED8-2T Manual de usuario

Asus

Asus P2L97A Manual de usuario

Winmate

Winmate IC70 Manual de usuario

Asus

Asus MES-B Manual de usuario

Grantech

Grantech SYS8F377VGGA-3OMN Manual de usuario

Telit Wireless Solutions

Telit Wireless Solutions SL869-3DR Manual de usuario

Gigabyte

Gigabyte GA-9IVDT Manual de usuario

Texas Instruments

Texas Instruments ADS8372EVM Manual de usuario

Commell

Commell MS-C73 Manual de usuario

IBT Technologies

IBT Technologies MB860 Manual de usuario

Nvidia

Nvidia TEGRA DG-04927-001_V01 Manual de usuario

Biostar

Biostar M7VIT Bravo Instrucciones de funcionamiento e instalación

Intel

Intel D33217CK Manual de usuario

Asus

Asus F1A55-M LX PLUS R2.0 Manual de usuario

EPC

EPC EPC9147C Manual de usuario

Asus

Asus EX-B760M-V5 D4 Manual de usuario

EPOX

EPOX MU-8KHA0010 Manual de usuario