Yard force GM A46 Manual de usuario
WARNING!
Read this manual carefully before using your lawn mower
and keep it in a safe place for future reference.
Hotline:1300 418 640
Monday/Friday: 9.00am to 4.30pm
Saturday: 9.00am to 3.00pm
Email: [email protected]
Model GM A46
OPERATOR’S MANUAL
PETROL LAWN MOWER
1
1
TABLE OF CONTENTS
DESCRIPTION OF PRODUCT PARTS 2
TECHNICAL SPECIFICATIONS 4
INTENDED USE 4
SAFETY INFORMATION 5
ASSEMBLY 9
ADJUSTMENT 13
OPERATION 14
MAINTENANCE AND STORAGE 17
TROUBLESHOOTING 21
WARRANTY 22
GM A46 Operating Manual
PREPARING THE ENGINE 11
2
DESCRIPTION OF PRODUCT PARTS
As shown in Fig. 1
1. Throttle lever
2. Upper handle
3. Engine start handle
4. Rope guide
5. Rear ap
6. Grass catcher
7. Oil ller cap and dipstick
8. Rear wheel
9. Height adjusting handle
10. Front wheel
11. Deck
12. Spark plug cap
13. Fuel tank cap
14. Throttle control cable
15. Lower handle
16. Cable clip
17. Fixing knob
Fig. 1
3
DESCRIPTION OF PRODUCT PARTS
Check the delivery parts
As shown in Fig. 2
Carefully remove the lawn mower from its packaging and check as the following parts are
complete:
1pc
1pc
1pc
1pc
1pc
2pcs
2pcs
4pcs
4pcs
A. Main mower deck (with upper handle)
B. Grass catcher filter
C. Grass catcher upper cover
D. Grass catcher handle
E. Grass catcher lower case
F. Cross recessed pan head tapping screws ST4.8X25 mm
G. Self tapping screw ST4.8X16 mm
H. Fixing knob with M8 nut
I. Cup head square neck bolts M8X45mm
J. Lower handle
K. Cable clip
L. Spark plug spanner
M. Manual
1pc
WARNING: If any parts are damaged or missing, please contact Action
Spares 1300 418 640. Do not operate this mower until the parts are replaced.
Fig. 2
1pc
1set
1pc
A
B
C
D
E
FG
H
J
KLM
I
4
TECHNICAL SPECIFICATIONS
Engine type Single cylinder 4-stroke
Engine displacement 144.3 cc
Nominal power: 2.4kW @3100rpm
Engine speed 3100rpm
Cutting width 46cm
Grass catcher capacity 55L
Ignition TCI
Fuel tank capacity 800ml
Oil tank capacity 400ml
Spark plug type TORCH/F5RTC
Net weight 28kg
Fuel recommendations UNLEADED FUEL (PETROL), 90 OCTANE
OR BETTER - Do NOT use E10 or Ethanol
blends.
Oil type SAE 10W-30
INTENDED USE
This Petrol lawn mower has been designed for cutting lawn areas in private homes and
gardens.
This lawn mower must be used only for its intended purpose. Any other use is deemed
to be a case of misuse. The user/operator (not the manufacturer) will be liable for any
damage or injuries of any kind caused as a result.
Note: This lawn mower is designed for domestic use. It is not designed for or warranted
for use in commercial, trade or industrial applications.
5
SAFETY INFORMATION
Description of Symbols
Symbols are used in this manual to attract your attention to possible risks. These safety
symbols and their explanations must be fully understood. The warning themselves do not
prevent the risks and can not be a substitute for proper methods of avoiding accidents.
Warning symbols
WARING! To reduce the risk of injury all users must read the operator’s manual
before using the lawn mower.
This symbol, before a safety comment indicates a precaution, a warning or a
danger. Ignoring this warning can lead to an accident for yourself or for others.
To limit the risk of injury, re, or electrocution always follow the recommendations
indicated.
Debris can be thrown by the cutting blades
Keep bystanders away
Risk of injury from the cutting blades. Keep hands and feet clear.
Remove spark plug lead before maintenance.
Risk of re.
Never refuel while the engine is running.
WARNING ! Hot surface - burn hazard to hands.
Do not open or remove safety shields while engine is running.
Before every use check the engine oil level and fuel.
Always wear ear and eye protection when using the lawn mower.
6
SAFETY INFORMATION
Warning! The lawn mower exhaust gas contains toxic substances.
Do not run the engine in closed or poorly ventilated areas.
Throttle positions indicator STOP, SLOW and FAST.
Rated sound power level.
Australian Regulatory Compliance Mark.
Safety instructions
Training
1. Read the instructions carefully. Be familiar with the controls and the proper use of the
equipment;
2. Never allow children or people unfamiliar with these instructions to use the lawn mower.
Local regulations can restrict the age of the operator;
3. Never mow while people, especially children or pets are nearby;
4. Keep in mind that the operator or user is responsible for accidents or hazards occurring
to other people or their property.
Preparation
1. While mowing, always wear safety footwear and long trousers. Do not operate the
equipment when barefoot or wearing open sandals; The use of safety glasses and
hearing protection is also recommended.
2. Thoroughly inspect the area where the equipment is to be used and remove all objects
which can be thrown by the lawn mower;
3. Warning - petrol is highly ammable.
- Store fuel in containers specically designed for this purpose;
- Refuel outdoors only and do not smoke while refueling;
- Add fuel before starting the engine. Never remove the cap of the fuel tank or add
petrol while the engine is running or when the engine is hot;
- If petrol is spilled, do not attempt to start the engine but move the lawn mower away
from the area of spillage and avoid creating any source of ignition until petrol vapors
have dissipated;
- Replace all fuel tank and container caps securely;
4. Before using, always visually inspect to see that the blades, blade bolts and cutter
assembly are not worn or damaged. Replace worn or damaged blades and bolts in
96
sets to preserve balance;
7
5. On multi-bladed lawn mowers, take care as rotating one blade can cause other blades
to rotate.
Operation
1. Do not operate the engine in a conned space where dangerous carbon monoxide
fumes can collect;
2. Mow only in daylight or in good articial light;
3. Avoid operating the equipment in wet grass, where possible;
4. Always be sure of your footing on slopes;
5. Walk, never run;
6. For wheeled rotary lawn mowers, mow across the face of slopes, never up and down;
7. Exercise extreme caution when changing direction on slopes;
8. Do not mow excessively steep slopes;
9. Use extreme caution when reversing or pulling the lawn mower towards you;
10. Stop the blade(s) if the lawn mower has to be tilted for transportation when crossing
surfaces other than grass, and when transporting the lawn mower to and from the
area to be mowed;
11. Never operate the lawn mower with defective guards, or without safety devices, for
example deectors and/or grass catchers, in place;
12. Do not change the engine governor settings or over speed the engine;
13. Disengage all blade and drive clutches before starting the engine;
14. Start the engine or switch on the motor carefully according to instructions and with
feet well away from the blade(s);
15. Do not tilt the lawn mower when starting the engine or switching on the motor, except
if the lawn mower has to be tilted for starting. In this case, do not tilt it more than
absolutely necessary and lift only the part which is away from the operator;
16. Do not start the engine when standing in front of the discharge chute;
17. Do not put hands or feet near or under rotating parts. Keep clear of the discharge
opening at all times;
18. Never pick up or carry a lawn mower while the engine is running;
19. Stop the engine and disconnect the spark plug wire , make sure that all moving parts
have come to a complete stop and, where a key is tted remove the key:
- Before clearing blockages or unclogging chute;
- Before checking, cleaning or working on the lawn mower;
- After striking a foreign object. Inspect the lawn mower for damage and make
repairs before restarting and operating the lawn mower;
- If lawn mower starts to vibrate abnormally (check immediately);
20. Stop the engine and disconnect the spark plug wire, make sure that all moving parts
SAFETY INFORMATION
8
have come to a complete stop and, where a key is tted remove the key:
- Whenever you leave the lawn mower;
- Before refueling;
21. Reduce the throttle setting during engine shut down and, if the engine is provided
with a shut-off valve, turn the fuel off at the conclusion of mowing;
22. Go slow when using a trailing seat.
Maintenance and storage
1. Keep all nuts, bolts and screws tight to be sure the equipment is in safe working
condition;
2. Never store the equipment with petrol in the tank inside a building where fumes can
reach an open ame or spark;
3. Allow the engine to cool before storing in any enclosure;
4. To reduce the re hazard, keep the engine, silencer and petrol storage area free of
grass, leaves, or excessive grease;
5. Check the grass catcher frequently for wear or deterioration;
6. Replace worn or damaged parts for safety;
7. If the fuel tank has to be drained, this should be done outdoors.
SAFETY INFORMATION
ASSEMBLY
Assembling the handle
As shown in Fig.3
1. Attach the lower handles (J) onto the lower handle brackets with the round head bolt (I)
NOTE: Make sure the rope guide is on the right handle when you stand behind
the mower.
Fig. 3
J
H
I
and fixing knob (H).
9
2. Fix the upper handle to the lower handle (J) with cup head square neck bolts (I) and
ASSEMBLY
Tidy the cable throttle control Fig. 6
Fig. 7-1
B
C
Fig. 4Fig. 5
Assembling the grass catcher (Fig. 7)
Align the holes of the grass catcher filter
(B) with the corresponding lugs on the
grass catcher upper cover (C), then
push it until it is locked in place
securely. (Fig. 7-1)
K
J
H
I
J
H
I
fixing locks (H).
Fix the cable throttle control cord to the handle with the cable clip (K).
Fig. 6
1.
Tabla de contenidos
Otros manuales de Cortacésped de Yard force
Yard force
Yard force YF22-3N1SP-SC Manual de usuario
Yard force
Yard force ROBOMOWER SA800PRO Manual de usuario
Yard force
Yard force LM G40B Manual de usuario
Yard force
Yard force YF22-3N1SP Manual de usuario
Yard force
Yard force MowBest 805 Manual de usuario
Yard force
Yard force LM C34 Manual de usuario
Yard force
Yard force HM A30 Manual de usuario
Yard force
Yard force EM N34A Manual de usuario
Yard force
Yard force YF60VRX18-LT Manual de usuario
Yard force
Yard force LM C32A Manual de usuario
Yard force
Yard force Y0LMX22S300 Manual de usuario
Yard force
Yard force LM G34A Manual de usuario
Yard force
Yard force EasyMow 260B Manual de usuario
Yard force
Yard force LUV1000Ri Manual de usuario
Yard force
Yard force EM U32 Manual de usuario
Yard force
Yard force Revola X4E Manual de usuario
Yard force
Yard force YF22-3N1SPF Manual de usuario
Yard force
Yard force GT5664 Instrucciones de operación
Yard force
Yard force YF22-3N1 Manual de usuario
Yard force
Yard force LM F23 Manual de usuario
Manuales populares de Cortacésped de otras marcas
TALEN TOOLS
TALEN TOOLS AVR HGM30 Manual de usuario
DEWEZE
DEWEZE ATM-725 Manual de operación
Weed Eater
Weed Eater 180083 Manual de usuario
Husqvarna
Husqvarna Poulan Pro PP185A42 Manual de usuario
Better Outdoor Products
Better Outdoor Products Quick Series Manual de usuario
Cub Cadet
Cub Cadet 23HP Z-Force 60 Manual de funcionamiento
