Yard Craft Hyperion Manual de usuario

Assembly Manual

Hyperion Vinyl Playset

Tools Required for Job

One 4' Step

Ladder

Cordless Drill

& 1/2" drill bit

25’Tape

Measure

Hyperion Vinyl Playset

Assembly Manual

Thank you for your purchase of this playset.

This manual is designed to simplify the assembly process, however we recommend having an experienced

carpenter involved in the project. Please read through the entire manual before starting!

Take a deep breath and get at it; the satisfaction and enjoyment of this hideout is only a few minutes away.

Have fun!

You have purchased a product that consists of bulky pieces. With your purchase, you assume full

responsibility to have the necessary manpower available to assemble the product. We reccomend at least

two able-bodied men for this assembly. You also agree that any damage that happens to the product during

the entire construction process is your responsibility, and neither the seller, nor the manufacturer, will be

held liable for any such damage.

9/16th Wrench

#2 Square

Drive Tip

(included)

T30 Star

Drive Tip

(included)

Parts List

note numbers on these six pieces

Hyperion Vinyl Playset Assembly Manual

Begin by positioning two 2x6x90's and two 2x6x40's on

a flat surface.

Place 4x4x128" labeled "1" in corner.

Note pre-drilled hole pattern.

Align pre-drilled holes on 4x4 with pre-drilled holes on

2x6. Using 6 7/8" bolts, begin fastening 2x6's to tower

4x4. Thread acorn nut onto rod as you can, then back

off several turns. Be sure to place on flat washer

between acorn nut and vinyl.

Bolts should be flush with outside of 2x6 before putting

on the bracket.

6WHS:

6WHS4:

6WHS3:

6WHS2:

Place washer and acorn nut on bolt. Only finger tighten

at this point.

Place 4x4x128" labeled "2" in position as shown.

Very important to note drilling patterns on 4x4's.

Fasten using 6 7/8 bolts. Finger tighten acorn nuts at

this point.

Place 4x4x108" labeled "3" in this position. Notice

the pre-drilled hole patterns, especially at the 5' and

7' height.

6WHS5:

6WHS8:

6WHS7:

6WHS6:

Hyperion Vinyl Playset Assembly Manual

Align pre-drilled holes on 4x4 with pre-drilled holes on

2x6. Using 6 7/8" bolts, begin fastening 2x6's to tower

4x4/ Thread acorn nut onto rod as far as you can, then

back off several turns. Be sure to place flat washer

between acorn nut and vinyl. Bolts should be flush with

outside of 2x6 before putting on the bracket.

Repeat previous step in this corner, using 4x4x108"

labeled "4."

Place 4x4x128" labeled "5" in position as shown.

Very important to note drilling patterns on 4x4's.

Fasten using 6 7/8" bolts. Finger tighten acorn nuts at

this point.

6WHS9:

6WHS12:

6WHS11:

6WHS10:

Hyperion Vinyl Playset Assembly Manual

Place 4x4x128" labeled "6" in corner. Align pre-drilled

holes on 4x4 with pre-drilled holes on 2x6. Using 6 7/8"

bolts, begin fastening 2x6's to tower 4x4. Thread acorn

nut onto rod as far as you can, then back off several

turns. Be sure to place flat washer between acorn nut

and vinyl. Bolts should be flush with outside of 2x6

before putting on the bracket.

Lay out four 2x6x44" as shown. Also notice the pre-

drilled hole pattern on this 2x6. You can also place 6

7/8" bolts with an acorn nut and washer on one side, in

the pre-drilled holes, as shown. This will be the

placement of the framing for 7' and 5' decks. Lower deck

framing consists of two 2x6x50 (with joist hangers

attached) and one 2x6x44.

Notice two outside 2x6x50" with joist hangers attached. Begin fastening 2x6x44." (This should have joist

hangers attached on inside). Fasten with acorn nuts

and washer at this end only for now.

6WHS13:

6WHS16:

6WHS15:

6WHS14:

Hyperion Vinyl Playset Assembly Manual

Bolts should be flush with outside of 2x6 before putting

on the bracket.

Continue fastening 2x6x44."

Only finger tighten acorn nuts at this point.

After four 2x6x44's are in their proper place, your set

should appear like this.

Tighten all the acorn nuts on the framing for the 7' deck.

Use a 9/16" deep socket and a 9/16" open end wrench.

Keep in mind that over-tightening can damage the acorn

nut.

6WHS17:

6WHS20:

6WHS19:

6WHS18:

Hyperion Vinyl Playset Assembly Manual

Then install second 2x6x44" with no joist hanger.

6WHS21:

6WHS24:

6WHS23:

6WHS22:

Identify two 2x6x50" with joist hangers attached. Install one 2x6 with joist hanger, then install 2x6x44"

with no joist hanger.

Install second 2x6 with joist hanger.

Hyperion Vinyl Playset Assembly Manual

These two corners do not get corner brackets. Set should look like this at this point. All acorn nuts

should be tightened at this point, using a 9/16" deep

socket and a 9/16" open end wrench.

Keep in mind that over-tightening can damage the acorn

nut.

You will receive two sandbox seats with your playset.

The can be installed at any corner using 1 1/2" screws

provided.

Install floor joists as pictured. Two on upper deck and

two on lower deck.

6WHS25:

6WHS28:

6WHS27:

6WHS26:

Hyperion Vinyl Playset Assembly Manual

Tabla de contenidos

Otros manuales de Juegos y equipos de juegos infantiles de Yard Craft

Yard Craft

Yard Craft Titan Manual de usuario

Yard Craft

Yard Craft Backyard Cliff Climb Manual de usuario

Yard Craft

Yard Craft Orion Manual de usuario

Yard Craft

Yard Craft Titan Playset Manual de usuario

Yard Craft

Yard Craft Nova Playset Manual de usuario

Yard Craft

Yard Craft Cydonia Vinyl Playset Manual de usuario

Yard Craft

Yard Craft Pluto Manual de usuario

Yard Craft

Yard Craft Polaris Manual de usuario

Yard Craft

Yard Craft Lunar Vinyl Playset Manual de usuario

Yard Craft

Yard Craft Phobos Vinyl Playset Manual de usuario

Yard Craft

Yard Craft Pluto Vinyl Playset Manual de usuario

Yard Craft

Yard Craft Polaris Vinyl Playset Manual de usuario

Manuales populares de Juegos y equipos de juegos infantiles de otras marcas

Ledon

Ledon 302040 Manual de usuario

FUNormous

FUNormous Disney Junior MICKEY MOUSE Manual de usuario

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Manual de usuario

PoolMaster

PoolMaster 72775 Manual de usuario

Palmako

Palmako 4743142009857 Manual del instalador

BOERPLAY

BOERPLAY PSTE000.019 Manual de usuario

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Guía del usuario

stilum

stilum Erika Manual de usuario

Costway

Costway NP10816 Manual de usuario

Trigano

Trigano VABI Manual de usuario

Outward

Outward OUT116 Manual de usuario

GALOPIN

GALOPIN ARC02 Manual de usuario

stilum

stilum levis Especificaciones técnicas

Ledon

Ledon BASIC Bai LB012 Manual de usuario

BOERPLAY

BOERPLAY PSTE115.002 Manual de usuario

Europlay

Europlay S306 Manual de programación

SportsPlay Equipment

SportsPlay Equipment 361-509H Manual de usuario

Ledon

Ledon 302250 Manual de usuario