Xylem Rule 56D Manual de usuario

Standard Bilge Pump

INSTRUCTION MANUAL

Manuel d’utilisation pour pompe de cale standard

Bedienungsanleitung für die Standard-Bilgenpumpe

Manuale delle istruzioni per la pompa di sentina

standard

Manual de instrucciones de la bomba de achique

estándar

Användarhandbok för standard länspump

Handleiding voor standaard lenspomp

Purpose of this manual

The purpose of this manual is to provide necessary information for product installation, operation

and maintenance.

CAUTION: Read this manual carefully before installing, using or servicing this

product. Failure to follow the instructions within this manual could result in explosion,

property damage, severe personal injury and/or death.

DANGER: Failure to follow this instruction manual may lead to signicant property

damage or may result in serious injury or death.

About safety messages

It is extremely important that you read,understand and follow the safety messages and regulations

carefully before handling the product.They are published to help prevent these hazards:

WARNING:

• The operator must be aware of safety precautions to prevent physical injury.

• Operating, installing or maintaining the unit in any way that is not covered

in this manual could cause death, serious personal injury or damage to the

equipment. This includes any modication to the equipment or use of parts

not provided by Xylem.If there is a question regarding the intended use of

equipment, please contactXylem representative before proceeding.

• Do not change the service application without the approval of a authorized

Xylem representative.

• Personal accidents and health problems

• Damage to the product

• Product malfunction

NOTICE: Save this manual for future reference, and keep it readily available at the

location of the unit.

Safety

Safety terminology and symbols

Hazard Level:

DANGER

WARNING

CAUTION

NOTICE

Indication:

Ahazardous situation which,if not avoided,will result indeath orserious injury.

Ahazardous situation which,if not avoided,could result indeath orserious injury.

Ahazardoussituationwhich,if notavoided,could resultinminor ormoderateinjury.

Apotential situation which,if not avoided,could result in undesirable conditions.

Apractice notrelatedto personal injury.

ELECTRICAL HAZARD:

Hazard categories can either fall under hazard levels or let specic symbols replace the ordinary

hazard levels symbols. Electrical hazards are indicated by the following specic symbols:

These are examples of other categories that can occur.They fall under the ordinary hazard

levels and may use complementing symbols:

Hazard categories

• Crush hazard

• Cutting hazard

• Arc ash hazard

General safety rules

These are safety rules apply:

• Always keep work area clean

• Pay attention to the risks presented by gas and vapors in the work area.

• Avoid all electrical dangers. Pay attention to the risks of electric shock or arc ash hazards

• Always bear in mind the risk of drowning, electrical accidents and burn injuries

User safety

Safety equipment

Usesafetyequipment according tothecompany regulations.Use this safety equipmentwithin the work area:

Electrical connections

Electrical connections must be made by certied electricians in compliance with all

international, national,state and local regulations. For more information about requirements,

see sections dealing specically with electrical connections.

• Hard hat

• Safety goggles, preferably with side shields

• Protective shoes

• Protective gloves

• Gas mask

• Hearing protection

• First-aid kit

• Safety devices

NOTICE: Never operate a unit unless safety devices are installed.

Precautions before work

Observe these safety precautions before you work with the product or are in connection with the product:

• Provide a suitable barrier around the work area, for example, a guard rail

• Make sure that all safety guards are in place and secure

• Make sure that you have a clear path of retreat

• Make sure that the product cannot roll or fall over and injure people or damage property

The work area

Always keep the station clean

Waste and emissions regulations

Observethesesafety regulations regardingwaste and emissions:

Wash the skin and eyes

Followthese proceduresfor chemicals or hazardousfluids that have come intocontact with your eyes orskin:

• Make sure that the lifting equipment is in good condition

• Use a lifting harness,a safety line and a breathing device as required

• Allow all system and pump components to cool before you handle them

• Make sure that the product has been thoroughly cleaned

• Disconnect and lock out power before you service the pump

• Check the explosion risk before you weld or use electric hand tools

• Appropriately dispose of all waste

• Handle and dispose of the processed liquid in compliance with applicable

environmental regulations

• Clean up all spills in accordance with safety and environmental procedures

• Report all environmental emissions to the appropriate authorities

Environmental safety

Electrical installation

For electrical installation recycling requirements, consult your local electric utility

Recycling guidelines

Always follow local laws and regulations regarding recycling

WARNING: Radiation Hazard.Do NOT send the product to Xylem if it has been

exposed to any nuclear radiation

Condition

Chemicals or

hazardous uids

in eyes

Chemicals or

hazardous uids

on skin

Action

1. Hold your eyelids apart forcibly with your ngers

2. Rinse the eyes with eyewash or running water for al least 15 minutes

3. Seek medical attention

1. Remove contaminated clothing

2.Wash the skin with soap and water for a least 1 minute

3. Seek medical attention, if necessary

DANGER: This product is not intended for damage control or to deal with ooding result-

ing from hull damage.This product is intended to be used in Bilge Pumping Systems for small

craft with a hull length up to 24 meters,as described within the introduction and scope of ISO

15083. Bilge Pumping Systems, as specied in ISO 15083, are limited to normal amounts of

water in an intact boat due to spray, rain,seepage, spillage, and occasional small amounts of

water shipped from boat movements in heavy weather. Use of product in any other way could

result in ooding, catastrophic damage to craft, serious personal injury, or death.

WARNING: This pump is designed for use with fresh water and salt water ONLY. Use with

any other hazardous, caustic,or corrosive material could result in damage to the pump and

the surrounding environment,possible exposure to hazardous substances and injury.

WARNING: Check the function of all bilge pumps at regular intervals. Clear pump

inlets from debris. If seacocks are tted in the fore and aft peak bulkheads, they shall be

kept closed and shall only be opened to let water drain into the main bilges.

STOP

ARRÊT

STOPP

ALTO

Rated Flow Open Flow

Output @ 0ft/0m

(0 kPa) GPH (LPH)

Open Flow

Output @ 3.35ft/1m

(10 kPa) GPH (LPH)

Open Flow

Output @ 6.7ft/2m

(20 kPa) GPH (LPH)

Débit nominal

Débit libre

Sortie à 0 pied/0m

(0 kPa) GPH (LPH)

Débit libre

Sortie à 3,35 pieds/1m

(10 kPa) GPH (LPH)

Débit libre

Sortie à 6,7 pieds/2m

(20 kPa) GPH (LPH)

Gemessener

Durchuss

Offener Durchuss

Pumpleistung bei 0m

(0kPa) GPH (LPH)

Offener Durchuss

Pumpleistung bei 1m

(10kPa) GPH (LPH)

Offener Durchuss

Pumpleistung bei 2m

(20kPa) GPH (LPH)

Flusso

nominale

Flusso aperto

Uscita @ 0ft/0m

(0 kPa) GPH (LPH)

Flusso aperto

Uscita @ 3,35ft/1m

(10 kPa) GPH (LPH)

Flusso aperto

Uscita @ 6,7ft/2m

(20 kPa) GPH (LPH)

Nominaal

debiet

Open debiet

Uitvoer @ 0ft/0m

(0 kPa) GPH (LPH)

Open debiet

Uitvoer @ 3,35ft/1m

(10 kPa) GPH (LPH)

Open debiet

Uitvoer @ 6,7ft/2m

(20 kPa) GPH (LPH)

Nominellt öde

Öppet öde

Effekt @ 0ft/0m

(0 kPa) GPH (LPH)

Öppet öde

Effekt @ 102,11cm/1m

(10 kPa) GPH (LPH)

Öppet öde

Effekt @ 204,22cm/2m

(20 kPa) GPH (LPH)

Caudal Nominal

CaudalAbierto

Salida @ 0 pies/0 m

(0 kPa) GPH (LPH)

Caudal Abierto

Salida @ 3.35 pies/1 m

(10 kPa) GPH (LPH)

Caudal Abierto

Salida @ 6.7 pies/2 m

(20 kPa) GPH (LPH)

360 360 (1362) 265 (1003) 190 (719)

500 500 (1892) 360 (1362) 260 (984)

700 700 (2649) 562 (2127) 330 (1249)

800 800 (3028) 615 (2328) 425 (1608)

1000 1000 (3785) 725 (2744) 450 (1703)

1100 1100 (4164) 860 (3255) 550 (2081)

1500 1500 (5678) 1200 (4542) 680 (2574)

2000 2000 (7570) 1620 (6132) 1300 (4921)

3700 3700 (14006) 2900 (10977) 2450 (9274)

4000 4000 (15142) 3527 (13351) 2952 (11174)

Note: Output is based on 10 hour break-in period and at 13.6V(12V models) or 27.2V (24Vmodels)

3800 GPH (14384 LPH)

(14006 LPH)

(15141 LPH)

(30283 LPH)

Pump Performance - Large RULE Pumps

(15141) (22712) (30283)

3785

Pump Performance - Small RULE Pumps

360

1000 GPH (3785 LPH)

Pump Performance - Small RULE Pumps

Pump Performance - Large RULE Pumps

+12"

(+30cm)

Este manual sirve para los siguientes modelos

Tabla de contenidos

Idiomas:

Otros manuales de Bomba de agua de Xylem

Xylem

Xylem JABSCO 11810 Series Manual de usuario

Xylem

Xylem GOULDS AC8743 Manual de usuario

Xylem

Xylem FLYGT APP 412 Manual de usuario

Xylem

Xylem GOULDS XBGR Series Manual de usuario

Xylem

Xylem Rule-Mate 500 Manual de usuario

Xylem

Xylem LOWARA SEKAMATIK 408 E Series Manual de servicio

Xylem

Xylem GOULDS NPO Manual de usuario

Xylem

Xylem FLOJET 4105 Series Manual de usuario

Xylem

Xylem Lowara Smart Pump Series Guía de solución de problemas

Xylem

Xylem GOULDS 2GFK2412H Manual de usuario

Xylem

Xylem LOWARA e-SV Series Manual de usuario

Xylem

Xylem GSP0311 Manual de usuario

Xylem

Xylem e-MPA Manual de usuario

Xylem

Xylem Bell & Gossett e-80SCXL Series Manual de usuario

Xylem

Xylem Goulds MCC Manual

Xylem

Xylem FLOJET Triplex Series Manual de usuario

Xylem

Xylem Lowara Micro PRESFIX Manual de usuario

Xylem

Xylem Flygt 3127 Manual de usuario

Xylem

Xylem Bell & Gossett Domestic CU Series Manual de usuario

Xylem

Xylem JABSCO 2620 Series Manual de usuario

Xylem

Xylem JABSCO 11860 Series Manual de usuario

Xylem

Xylem JABSCO 50890 Manual de usuario

Xylem

Xylem LOWARA e-LNEEE Guía de solución de problemas

Xylem

Xylem Flygt Concertor 6020 Manual de usuario

Manuales populares de Bomba de agua de otras marcas

Neptun

Neptun NPHW 5500 Manual de usuario

Sensidyne

Sensidyne Gilian BDX-II Instrucciones de instalación y funcionamiento

Draper

Draper 47808 Manual de usuario

Trolla

Trolla 12820 Manual de usuario

Sunfab

Sunfab SVH Series Manual de usuario

WilTec

WilTec 50740 Manual de usuario

Fieldmann

Fieldmann FVC 5015 EK Manual de usuario

Everbilt

Everbilt EFSUB5-122HD Manual de usuario

Graco

Graco Husky 3300e Manual de usuario

esotec

esotec 101018 Manual de usuario

moyno

moyno 2000 CC Manual de usuario

Becker

Becker BASIC VASF 2.80/1-0.AC230 Manual de usuario

Sykes AmeriPumps

Sykes AmeriPumps GP100M Guía de solución de problemas

DUROMAX

DUROMAX XP WX Series Manual de usuario

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Manual de usuario

Franklin Electric

Franklin Electric IPS Manual de usuario

Milton Roy

Milton Roy PRIMEROYAL Manual de usuario

STA-RITE

STA-RITE ST33APP Manual de usuario