Xylem Bell & Gossett e-1510 Series Manual de usuario

1 Introduction

NOTICE:

Read the installation, operation and maintenance instructions located

on the Xylem website before use. Improper use of the product can

cause personal injury and damage to property and may void the war‐

ranty. See e1510 Instruction Manual for complete Product Warranty.

WARNING:

Personal protective equipment should be worn when

handling this equipment. Only use properly sized certi‐

fied lifting equipment & lifting devices, including slings,

suitably rated for the weights to be lifted. Slings, when

used, must be of identical materials to avoid differences

in stretch rates. Do not use lifting devices that are frayed,

kinked, unmarked, or worn.

WARNING:

Always lock out power to the driver before you perform

any installation of maintenance tasks. Failure to discon‐

nect and lock out driver power will result in serious injury.

WARNING:

This product can expose you to chemicals including

Lead, which is known to the State of California to cause

cancer and birth defects or other reproductive harm. For

more information go to: www.P65Warnings.ca.gov.

2 Transportation Requirements

QUICKSTART GUIDE

P2004388 Rev A

Series e-1510 THE MANUAL IS AVAILABLE AT:

https://qr.xylemsales.com/c8poit

For safety and correct product usage, read the manual before this

product is used.

3 Foundation Requirements

1”

1. Pour grout here up to top surface / plane of base plate

2. Nut

3. Washer

4. Base plate

5. Shims or levelling wedges

6. Bolt sleeve

7. Anchor bolt

8. Concrete foundation

9. Position levelling wedges / shims on both sides of each anchor bolt

Notes:

• Distance from the base plate to the edge of the foundation to be greater than or equal to

1.5”.

• Foundation weight should be greater than or equal to 2.5 times of pump weight.

4 Piping Requirements

1. Check that a section of straight pipe, with a length that is a minimum of five times its di‐

ameter, is installed between the suction side of the pump and the first elbow, or that a

B&G Suction Diffuser is installed.

2. Check that there is a strong, rigid support for the suction and discharge lines.

3. Check that the suction or discharge lines are not forced into position.

4. Check that flexible piping is used on both the suction and discharge sides of the pump

when you use an isolation base.

5. Check that a B&G Triple Duty® valve is installed in the discharge line.

6. Check that the pipeline has isolation valves around the pump and has a drain valve in the

suction pipe.

5 Coupling Alignment

WARNING:

• Follow shaft alignment procedures in order to prevent cata‐

strophic failure of drive components or unintended contact of

rotating parts. Follow the coupling installation and operation

procedures from the coupling manufacturer.

• Always disconnect and lock out power to the driver before

you perform any installation or maintenance tasks. Failure to

disconnect and lock out driver power will result in serious

physical injury.

NOTICE:

Proper alignment is the responsibility of the installer and the user of the unit. Check the align‐

ment of frame-mounted units before you operate the unit. Failure to do so can result in equip‐

ment damage or decreased performance.

6 Checking Rotation

1. Lock out power to the driver.

2. Make sure that the coupling hubs are fastened securely to the shafts.

3. Unlock power to the driver.

4. Make sure that everyone is clear, and then jog the driver long enough to determine that

the direction of rotation corresponds to the arrow on the pump.

5. Lock out power to the driver.

For safety and correct product usage, read the manual before this product is used.

Xylem Inc.

8200 N. Austin Avenue, Morton Grove, IL 60053

Tel: (847) 966–3700, Fax: (847) 965–8379

www.xylem.com/bellgossett

Xylem and Bell & Gossett are registered trademarks of Xylem Inc. or one of its subsidiaries.

All other trademarks or registered trademarks are property of their respective owners.

P2004388_Rev A_en-US_2022-05_QG_Series e-1510

Otros manuales para Bell & Gossett e-1510 Series

Otros manuales de Bomba de agua de Xylem

Xylem

Xylem LOWARA VOGEL Series Manual

Xylem

Xylem rule Rule-Mate Manual de usuario

Xylem

Xylem Flygt 2190 Manual de usuario

Xylem

Xylem LOWARA e-SV Series Manual

Xylem

Xylem LOWARA F 1-2 Manual

Xylem

Xylem Lowara LSB Series Manual

Xylem

Xylem LOWARA e-LNEEE Manual de usuario

Xylem

Xylem Lowara Sekamatik 200 Series Instrucciones generales

Xylem

Xylem Rule Mate RM500A Manual de usuario

Xylem

Xylem Goulds J Series Manual de usuario

Xylem

Xylem Flojet U55 Series Manual de usuario

Xylem

Xylem Bell & Gossett 1510 Series Manual de usuario

Xylem

Xylem Flygt 5530 Manual de usuario

Xylem

Xylem Lowara Smart Pump Series Guía de solución de problemas

Xylem

Xylem GOULDS e-SVI Series Manual de usuario

Xylem

Xylem FLOJET R3426-500 Manual de usuario

Xylem

Xylem FLOJET Duplex II Series Manual de usuario

Xylem

Xylem Lowara GHV1 Manual de usuario

Xylem

Xylem Bell & Gossett GLC Series Manual de usuario

Xylem

Xylem Lowara Scuba Manual

Xylem

Xylem ecocirc XL Manual de usuario

Xylem

Xylem GOULDS MCS Manual

Xylem

Xylem Lowara MPB Manual

Xylem

Xylem FLOJET BW5000 Series Manual de usuario

Manuales populares de Bomba de agua de otras marcas

Neptun

Neptun NPHW 5500 Manual de usuario

Sensidyne

Sensidyne Gilian BDX-II Instrucciones de instalación y funcionamiento

Draper

Draper 47808 Manual de usuario

Trolla

Trolla 12820 Manual de usuario

Sunfab

Sunfab SVH Series Manual de usuario

WilTec

WilTec 50740 Manual de usuario

Fieldmann

Fieldmann FVC 5015 EK Manual de usuario

Everbilt

Everbilt EFSUB5-122HD Manual de usuario

Graco

Graco Husky 3300e Manual de usuario

esotec

esotec 101018 Manual de usuario

moyno

moyno 2000 CC Manual de usuario

Becker

Becker BASIC VASF 2.80/1-0.AC230 Manual de usuario

Sykes AmeriPumps

Sykes AmeriPumps GP100M Guía de solución de problemas

DUROMAX

DUROMAX XP WX Series Manual de usuario

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Manual de usuario

Franklin Electric

Franklin Electric IPS Manual de usuario

Milton Roy

Milton Roy PRIMEROYAL Manual de usuario

STA-RITE

STA-RITE ST33APP Manual de usuario