Weil-McLain SB0203 Manual de referencia

Subject: Water Boiler Installations with Three-Way Valves

Number: SB0203 (Page 1 of 2)

Date: November 22, 2002

Primary/Secondary pumping is the preferred method for system temperature modulation in

commercial hydronic heating installations. Three-way valves are also used on many

installations for this purpose. Without proper system design and control, three-way valves

can cause cold system water to be returned to a hot boiler. This condition could lead to

boiler thermal shock, creating a potential for section failure. With minimal equipment

investment, thermal shock conditions can be reduced on three-way valve installations.

Weil-McLain makes the following design recommendations.

Piping Selection:

1. Use by-pass piping arrangement – See Figure 1 or 2.

2. Follow basic boiler piping instructions in the boiler manual.

Three-Way Valve Selection:

1. Use valves with minimum timing of four minutes from one extreme position to the other.

2. Size to circuit design requirements. Follow manufacturer’s recommendations. Normally

valve will be one or two pipe sizes smaller than recommended boiler piping size.

3. Avoid oversizing to prevent poor control of mixed water.

4. Pressure drop across the valve should be high enough to provide accurate control

without “hunting”.

Circulator Selection:

1. Size system circulator to circuit flow characteristics. Specify gpm and head requirements.

2. Size each by-pass circulator as follows:

1 .

# of boilers used

[1/4 to 1/3 flow (gpm) of system circulator] X

3. All circulators must run at the same time.

EXAMPLE: Specify equipment to by-pass one 1,000,000 btuh Weil-McLain boiler.

Piping: (1) tee, (1) ell, (1) 45° tee (By-pass size and length will vary on each installation.)

Circulator:

1,000,000 btuh .

10,000 btuh

System flow rate with 20° ∆T through boiler = = 100 gpm

1 .

1 boiler

By-pass flow rate = 1/4 X 100 gpm X = 25 gpm

In most cases a standard booster pump can provide the necessary flow at by-pass gpm and

head requirements.

www.weil-mclain.com.

Technical Services Bulletin No: SB0203 (Page 2 of 2)

Subject: Water Boiler Installations with Three-Way Valves

Date: November 22, 2002

BOILER

SYSTEM

VALVE

3-WAY

PUMP

10 TO 20

PIPE

AT LEAST

DIAMETERS

PUMP

FROM SYSTEM

Figure 1

By-Pass Piping Using Three-Way Valve – Single Boiler

10 TO 20

AT LEAST

DIAMETERS

3-WAY

VALVE

SYSTEM

TO P1

BOILER

PUMP

PIPE

PUMP

BOILER

PUMP

AT LEAST

10 TO 20

DIAMETERS

PIPE

FROM SYSTEM

Figure 2

By-Pass Piping Using Three-Way Valve – Multiple Boilers

Tabla de contenidos

Otros manuales de Caldera de Weil-McLain

Weil-McLain

Weil-McLain ECO 70 Manual de usuario

Weil-McLain

Weil-McLain SlimFit Guía

Weil-McLain

Weil-McLain Gold GV Series 4 Manual de usuario

Weil-McLain

Weil-McLain HE (Series 2) Manual de usuario

Weil-McLain

Weil-McLain Gold GV 3 Series Manual de usuario

Weil-McLain

Weil-McLain PEG 5 Series Guía

Weil-McLain

Weil-McLain GOLD CGa Manual de usuario

Weil-McLain

Weil-McLain EGH 5 Series Manual de usuario

Weil-McLain

Weil-McLain Series 4 Manual de usuario

Weil-McLain

Weil-McLain GV90+ Guía

Weil-McLain

Weil-McLain P-35 Steam Manual de usuario

Weil-McLain

Weil-McLain Gold GV 3 Series Manual de usuario

Weil-McLain

Weil-McLain CG Series Manual de usuario

Weil-McLain

Weil-McLain Gold GV 1 series Guía

Weil-McLain

Weil-McLain Series 4 Manual de usuario

Weil-McLain

Weil-McLain Evergreen 220 LP Manual de servicio

Weil-McLain

Weil-McLain GOLD GV Instrucciones de funcionamiento

Weil-McLain

Weil-McLain Ultra Electric Water Heater Manual de instalación y operación

Weil-McLain

Weil-McLain GOLD CGs Guía

Weil-McLain

Weil-McLain GOLD CGS 550-110-260/02002 Manual de usuario

Weil-McLain

Weil-McLain Evergreen 220 Manual de usuario

Weil-McLain

Weil-McLain Ultra Electric Water Heater Manual de usuario

Weil-McLain

Weil-McLain Ultra Oil Manual de usuario

Weil-McLain

Weil-McLain ULTRA Ultra-105 Manual del propietario

Manuales populares de Caldera de otras marcas

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manual de usuario

Radijator

Radijator BIO max 23.1 Manual de usuario

Brunner

Brunner BSV 20 Manual de usuario

Buderus

Buderus Logamax GB062-24 KDE H V2 Manual de usuario

Potterton

Potterton 50e Hoja de datos

UTICA BOILERS

UTICA BOILERS TriFire Manual de usuario

Joannes

Joannes LADY Series Manual

ECR International

ECR International UB90-125 Manual de instrucciones

Froling

Froling FHG Turbo 3000 Manual de usuario

Froling

Froling P4 Pellet 8 - 105 Manual de usuario

U.S. Boiler Company

U.S. Boiler Company K2 Manual de usuario

Henrad

Henrad C95 FF Manual de usuario

NeOvo

NeOvo EcoNox EF 36 Manual de usuario

Potterton

Potterton PROMAX SL 12 Manual de usuario

Eco Hometec

Eco Hometec EC 25 COMPACT Manual de usuario

Viessmann

Viessmann VITODENS 200 Guía

Baxi

Baxi Prime 1.24 Manual de usuario

REXNOVA

REXNOVA ISA 20 BITHERMAL Manual de usuario