Vego SX600 Manual de usuario
TABLE OF CONTENTS
Safety Information 1
Table of Contents 2
Notice 3
Scooter Diagram 4
Setup Guide 5-9
Charging Instructions 10
Pre-Ride Checklist 11
Specifications 12
Trouble Shooting 13-14
Maintenance Schedule 15-18
Limited Warranty 19-22
SX600 Manual 1/1/04 12:44 AM Page 1
YOUR INSURANCE POLICIES MAY
NOT PROVIDE COVERAGE FOR
ACCIDENTS INVOLVING THE USE OF
THIS SCOOTER. TO DETERMINE IF
COVERAGE IS PROVIDED, YOU
SHOULD CONTACT YOUR
INSURANCE COMPANY.
NOTICE
SX600 Manual 1/1/04 12:44 AM Page 2
SCOOTER DIAGRAM
•Rear brake
•Front brake
•Handlebar
quick
release
• Handlebar
release button
•Throttle
(rotates
clockwise)
•Brake cut-
off sensor
(signals
motor to stop
when brake
is applied)
• Circuit
breaker on
opposite side
of scooter
• Charge port
• Battery
gauge
• On/Off
switch
•Quick
release
lever
•Gray
locking
lever
SX600 Manual 1/1/04 12:44 AM Page 3
SETUP GUIDE
1Unfold Scooter
Install Handlebars
2CAUTION:
If you are not familiar
with bicycle assembly
techniques please bring
your scooter to a qualified
mechanic for proper
assembly and tightening
of all components.
See next page for
further instructions
on how to properly
tighten the handle-
bars.
(a) Loosen
quick release
lever and pull the
gray locking lever
upwards.
(b) Unfold scooter.
Note: The gray locking
lever will not move
freely if you are putting
presure on the steering
tube.
b
a
SX600 Manual 1/1/04 12:44 AM Page 4
SETUP GUIDE
3Adjust Handlebar Height
Tighten Handlebars
4
Tighten the quick release lever
to lock the handlebars in place. You
may need to adjust the tensioner nut
on the quick release lever to hold the
handlebar firmly in position. Check
for proper tightness by holding the
front wheel stationary in between
your feet while wiggling the handle-
bars. If the handlebars are loose,
open the quick release lever, tighten
the tensioner nut, close the quick
release lever and check again for
tightness.
Press
the small sil-
ver button
while insert-
ing the han-
dlebar into
the steer tube.
Make sure the
silver button
is locked into
one of the four
preset height
settings.
•Tensioner
Nut
SX600 Manual 1/1/04 12:44 AM Page 5
SETUP GUIDE
Fully insert the seat assem-
bly and tighten quick release lever
at the base of the seat tube. Adjust
seat height using the upper quick
release lever. Do not adjust seat
height at the base of the seat tube or
extend the seat post past warning
line.
Caution: The seat tube must be fully
inserted into the scooter frame.
Leaving the seat tube partially insert -
ed in the frame could cause the seat
tube to dislodge unexpectedly and
cause serious injury to the rider.
Securely
tighten the fold-
ing mechanism
quick release
lever and the
seat tube quick
release lever.
Remember to
adjust the ten-
sioner nuts if
necessary.
5Install Seat
6Tighten Quick Release Levers
SX600 Manual 1/1/04 12:44 AM Page 6
SETUP GUIDE
Inflate Tires
7Make sure to
add air to the tires
before riding. Use
the pump included
with your Vego
scooter. Fasten the
pump head to the
air valve on the
wheels. Your scooter
rides best with 50
psi in the tires. You
should use a tire
pressure gauge to
check the exact
pressure monthly.
8Install Batteries
Unpack the two battery
packs for your SX 600. Unlock
and remove the battery door
and place both batteries in the
battery compartment. Plug
both batteries into the power
panel.
Note: You may ride the scooter with a
single battery pack but the powerful SX
600 motor may drain the battery too
quickly and significantly reduce life span
of that battery pack. It is recommended
to always use both battery packs.
Power
Panel
SX600 Manual 1/1/04 12:44 AM Page 7
SET UP GUIDE
9Wear a Helmet
Turn Power On
10
In order to
have a safe ride
and abide by
federal law you
must wear a hel-
met every time
you ride your
Vego scooter.
Please wear
your helmet
every time you
ride!
Turn the scooter power
on using the key. The power
gauge will illuminate, indicat-
ing the scooter power is on.
Be careful- the scooter will
start moving once you twist
the throttle. All three lights
will be on when the battery is
full. The green light will go
out at 70% charge and the
yellow light will go out at 30%
charge. Warning: completely
discharging the battery signif-
icantly reduces its usable life.
• Key
Switch
•Power
Gauge
SX600 Manual 1/1/04 12:44 AM Page 8
You can recharge the batteries one of two ways.
• On board charging. With the batteries installed in the
scooter plug the charger into the charge port on the side of
the scooter. On board charging simultaneously charges
both batteries.
• Off board charging. Remove the batteries from the scoot-
er and charge each battery pack individually using the
charge ports on the batteries.
Note: Both battery packs cannot be charged simultaneously when
charged off board.
Charging Instructions
1. Plug your smart charger into a household outlet. The
green power light will blink indicating the charger is ready.
2. Plug the charger into the charge port located on the side
of the scooter or into the charge port on a battery pack
which has been removed from the scooter. The charger fan
will come on and the red light will begin blinking.
3. Once the battery charge is complete the red light will
become solid and the charger fan will shut off . Your scoot-
er will be fully charged in 5-6 hours. The smart charger
may be left plugged in for extended periods of time and will
never overcharge the battery.
CHARGING
• Battery
Charge Port
• Scooter
Charge Port
SX600 Manual 1/1/04 12:44 AM Page 9
Warning : If you do not perform these simple
saftey checks before each ride, you risk serious
injury due to improperly maintained equipment.
•Read and understand all safety instructions.
•Check all four quick release levers for tightness.
a. Handlebar quick release lever
b. Folding mechanism quick release lever
c. Seat tube quick release lever
d. Seat height adjustment release lever
•Check the brakes for proper function. If you can
pull the brake lever all the way down to the handle
grip you should have the brakes adjusted before rid-
ing.
•Make sure the tires are properly inflated.
PRE-RIDE CHECKLIST
a
bc
d
SX600 Manual 1/1/04 12:44 AM Page 10
Tabla de contenidos
Otros manuales de Scooter de Vego
