Turboair TD-4R Manual de usuario

CONTENTS

INTRODUCTION

SAFETY STICKERS

INSTALLATION INSTRUCTIONS

Inspection for damage

Location of DELI-CASE

Leveling of DELI-CASE

PACKAGING MATERIAL

LIGHTS

SHELVES

ELECTRICAL INFORMATION

WIRING DIAGRAM

OPERATING IBSTRUCTIONS

Controls

Anti Moisture

How to place product

Shelf placement

Replacement of light

MAINTENANCE & CLEANING

Cleaning daily

Cleaning weekly

Condenser Coil

TROBLE SHOOTING

DELI-CASE not working

DELI-CASE warm

Glass sweating

Light not working

WARRANTY STATEMENT

Load Line

SPECIFICATIONS

DELI-CASE Unit

* TD-4, TD-5(Non Refrigerated)

7~8

12~15

MODEL

TD-4R

TD-5R

TD-4

TD-5

COMP H.P

1/2

V/Hz

115V/60Hz

REFERIGERANT

R-134a

AMPS

1.1

WEIGHT

750 lbs

825 lbs

640 lbs

695 lbs

INTRODUCTION

This owner’s manual has important information. Please read the entire manual before

installing your new Turbo air refrigerated DELI-Case.

After reading manual if you have any questions, please fill free to call:

CUSTOMER SERVICE DEPARTMENT

TURBO AIR

1250 VICTORIA ST.

CARSON, CA 90746

1-800-381-7770

1-800-627-0032

Please write down model and serial number for making any reference to this unit.

CASE MODEL SERIAL NUMBER

WARNING!

Failure to read this manual completely can result in personal injury or damage to the unit.

Keep manual in a safe place to refer to in the future.

WARNING!

Electrical must be installed by a licensed electrician.

On page 6 and 16 is information for electrician.

WARNING!

All electrical wiring must be done in accordance with all applicable standards.

Improper connections of electrical can result in death or severe injury.

Thank you for purchasing Turbo Air!

SAFETY STICKERS

The following signs are thru out Turbo Air DELI-Case. If any are missing, Pleae

call Customer Service so the sticker can be sent to you.

DANGER HIGH VOLTAGE-

This sticker is on back of DELI-Case.

CAUTION-

This sticker is below the DELI display pan.

! CAUTION-

This sticker is on back of DELI-Case.

Please follow all safety warnings on stickers. Make sure all employees understand

warnings. Have all employees read manual for your and their safety.

Please be sure person who installs DELI-Case understands safety warnings and

has read manual.

If service technician services unit make sure they understand safety warning on

stickers. Please keep manual handy for future use for technician.

All stickers are pleaced for your protection. Please never remove stickers. If stickers

become lost or damaged call Customer Service so the stickers can be replaced.

!!! When you see this symbol, please be alerted. This will be seen thru the manual

and on stickers.

WARNING!

Please follow all instructions and all warnings for your safety.

INSTALLATION INSTRUCTIONS

INSPECTION FOR DAMAGE

Customer is responsible for checking for damage. First inspect crate as soon sa it arrives. Prior

to signing if crate is damaged make sure you note that on bill of lading.

If after uncrating there is concealed damaged and crate was in good condition you must call

Customer Service at Turbo Air. Concealed damage must be reported within 24 hours of receiving

unit. bill of lading will be requested faxed to claim department. Pictures may be requested of unit

and crating.

LOCATION OF DELI-CASE

Installation clearance:

86 inch at the top, 20 inch at the rear and 12 inch at the each side.

! CAUTION;

Damage to case and glass can result if pushed on. Do not push curved

glass, end glass, doors or door frames.

Do not place DELI-Case in the following locations; near source of heat, excessive air movement,

open doors, and direct sunlight.

Move the DELI-Case to the final location before removing shipping skid.

Condenser is in back of DELI-Case. Do not block inlet.

LEVELING OF DELI-CASE

Four leveling legs are provided for leveling DELI-Case.

Use a leveler to make sure unit is leveled on all four corners.

If unit is not leveled drainage of water will not drain properly and doors will not close properly.

Leveling legs can be adjusted accordingly.

PACKAGING MATERIAL

Remove all tape that holds lift up glass and doors in place. Some residue will be left and

this can be removed with glass cleaner.

Remove all plastic ties that hold shelves and brackets for shelves.

LIGHTS

Make sure lights are in their lamp holders. Also make sure plugs for lamp holders are

completely plugged in. If they are loose it may cause lamp holder to burn.

SHELVES

To install shelves in desired position front glass must be open and rear doors removed.

Where shelf height is desired install the shelf support in shelf standard slot (see drawing)

Install shelves on rear shelf support as shown. Curved part of shelf must be toward rear

of case if not air flow will be blocked. Snap shelf into retainer clip on the shelf support,

this keeps shelf from moving (see drawing)

ELECTRICAL INFORMATION

!!! DELI-CASE MUST BE GROUNDED

Only a licensed electrician must install all electrical on DELI-Case.

All electrical must be done in accordance with applicable electrical standards.

A dedicated breaker is to be used for each DELI-Case.

Electrical must be grounded upon installation

An access hole is provided thru base of case for running electrical up through floor. Also

a hole is provided in the back of unit to run electrical. Unit is designed to be hardwired

by electrician. Electrical data is located next to electrical junction box (see drawing)

The DELI-Case comes with a power with a power cord. Cord is 9.8 feet long. the plug is a

!!! Improper electrical connections can result in servere injury or death.

!!! Do not operate DELI-Case with panels or grill removed.

There are two back panels.

Right side panel has light switch, power switch, thermostat, and thermometer. Also

compressor service ports, electrical condensate drain pan, fuses, and main board are

accessible.

Left side panel allows access to electrical connection box, ballast, and also allows

condenser unit to be pulled out.

Front panel is removable to have access to fans.

WIRING DIAGRAM(TD-4R, TD-5R)

WIRING DIAGRAM(TD-4, TD-5)

OPERATING INSTRUCTIONS

After installing unit and all electrical to DELI-Case, unit is ready to start up.

CONTROLS

POWER SWITCH

It is labeled with on/off position. It controls power to the entire

DELI-Case.

LIGHT SWITCH

The switch controls the power to the lighting circuit.

The switch rocker is red in the “on” position, black in the “off” position.

TEMPERATURE CONTROL

TD-4R

TD-5R

1. The controller(thermostat) is locatef at the right inside of the unit.

2. The factory setting for the control is Normal

3. To lower temperature, depress down button to incrase temperature, depress up button

4. This product is for controlling temperature from 34 ᵻto 48ᵻ

5. The thermostat controls compressor’s on/off by sensing inside temperature.

THERMOMETER

Display changes temperature approximately every two seconds.

NOTE

Before placing goods to DELI-Case wait for unit to reach desired temperature. Product

must be could before placing in DELI-Case.

ANTI MOISTURE FANS

These fans run continuously when power switch is on. Two

fans are at front bottom of unit. The fans blew warm air through vents and prevent

from glass from getting moisture. Do not block vents because front glass will get moisture.

HOW TO PLACE PRODUCT

Check that display pans are positioned correctly before

placing goods in DELI-Case(see drawing). Do not overstock shelves. Display pans

should not hang over shelf. This will cause pan to block air flow and DELI-Case will

warm up in temperature. This will cause product to spoil.

Otros manuales para TD-4R

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Refrigerador de Turboair

Turboair

Turboair PRO-12R-N Manual de usuario

Turboair

Turboair PUR-48-D2-N Manual de usuario

Turboair

Turboair TGM-11WR Manual de usuario

Turboair

Turboair J series Manual de usuario

Turboair

Turboair TST-28SD-D2 Manual de usuario

Turboair

Turboair MST-28 Manual de usuario

Turboair

Turboair MUR-28 Manual de usuario

Turboair

Turboair ADR042 Manual de usuario

Turboair

Turboair TSR-23SD Manual de usuario

Turboair

Turboair PRO-26R-N Manual de usuario

Turboair

Turboair MSR-23NM Manual de usuario

Turboair

Turboair PRO-77R-GSH-N Manual de usuario

Turboair

Turboair TSR-23SD-N6 Manual de usuario

Turboair

Turboair Super Deluxe Series Manual de usuario

Turboair

Turboair TGM-69R Manual de usuario

Turboair

Turboair MUR-20S-N6 Manual de usuario

Turboair

Turboair JUR-44D-N Manual de usuario

Turboair

Turboair TGM-22R Manual de usuario

Turboair

Turboair Super Deluxe TSR-23SD-N Series Manual de usuario

Turboair

Turboair PRCBE Series Manual de usuario

Turboair

Turboair MUR-28-N Manual de usuario

Turboair

Turboair TGM-11R Manual de usuario

Turboair

Turboair TGM-35R Manual de usuario

Turboair

Turboair Premiere Pro Series Manual de usuario

Manuales populares de Refrigerador de otras marcas

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Manual de usuario

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Manual de usuario

Sharp

Sharp SJ-BA31IEXW2-EU Manual de usuario

CORBERO

CORBERO CC2300MCW Manual de usuario

KitchenAid

KitchenAid 2205264 Manual de usuario

Stengel

Stengel KU 1101 A++ Manual de usuario

NEFF

NEFF KI181 Series Manual de usuario

Hoshizaki

Hoshizaki Reach-In Manual de usuario

Amana

Amana ASD2524VES00 Manual de usuario

BOMANN

BOMANN KGC 213 Manual de usuario

Danby

Danby DAR044A1SLDD Instrucciones de montaje

Samsung

Samsung RF323TE Manual de usuario

Beko

Beko CSA31022 Manual de usuario

IKEA

IKEA FROSTIG C 185 E Manual de usuario

Electrolux

Electrolux ER 6821 D Manual de usuario

True

True TS-28 Manual de usuario

Frigidaire

Frigidaire FSC23R5DW9 Manual de usuario

Beko

Beko LSP4579W Manual de usuario