Travis Industries 616 GSR Manual de usuario



616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 1 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

WARNINGS

•MakesurethegascontrolvalveisOFFandtheheateriscoolpriortoconductingservice.

•Failuretopositionthepartsinaccordancewiththesediagramsorfailuretouseonlypartsspecificallyapprovedwiththis

appliancemayresultinpropertydamageorpersonalinjury.

•Ifusingpropane(LP),converttheappliancebeforeinstallingthelogs(seetheownersmanualfordetails).

Compatibility

616GSR

Packing List

•8‐PieceTraditionalLogSet

(notshown)



FrontLogSupports,(4)10‐24Kepsnuts

RearAirDeflector,RearLog

Support



BagofRockWool,BagofEmbers

Burner Installation

NOTE:Theinsertshouldbeinplace,withthegaslineandventattachedandthefirebacksinstalled(seeowner’smanualfor

furtherdetails).

1. Removetherearburner.

 

Removethisscrew

(

4”n

utd

riv

)

.



616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 2 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

2. Removethe3screwsfromthebackoftherearburnerusinga¼”nutdriver.

 

3. Attachtherearairdeflectortotherearburnerwiththescrewsremovedinthepreviousstep.

 

4. Replacetherearburnerandsecurewiththeattachmentscrew.





Thetwotabsontherear

burnerrestontopofthe

frontburner.



616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 3 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

5. Installtherearlogshelf.



6. Attachthefrontlogsupportswiththe4includednuts.

NOTE:Theleftfrontlogsupportshouldbepositionedlikethephotobelow:







616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 4 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

Rock Wool Placement

7. Placetherockwoolasfollows:

a. Brushtherockwoolusingastiffbrushinaloose,gauze‐likelayer.



TIP:Holdtherockwoolinatightwadwithonehandwhilebrushingwiththeother.



Notehowtherockwoolisapproximately1/8”thickovertheburnerports.

TIP:Feelfreetoapplyagenerousamountofrockwooltogainadarkerflameandabrightercoalbed.









616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 5 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

Log and Ember Chunks Placement

Thelogsarefragile,especiallyafterbeingexposedtoheat.

•Theburnermustbecorrectlypositionedbeforeinstallingthelogs.Makesuretheburnerisfullyseated.

8. Placetherearlogasshownbelow.

NOTE:Theleftandrightmiddlelogsneedtobepushedbacktightagainsttherearburner.









Movethelogforwarduntilitrestsagainstthetabsontheburners.







616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 6 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

9. Placetheleftmiddlelogasshownbelow.



10. Placetherightmiddlelogasshownbelow.





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 7 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

11. Placetheleftfrontlogasshown.



12. Placetherightfrontlogasshown.





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 8 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

13. Placetheemberchunksasshownbelow.Notethathalfthebagofembersisleftover.



14. Re‐applytherockwoolovertheemberchunksalongthefrontburnerandbetweenthetwofrontlogsforanaturallook.

TIP:Applyingrockwoolinthecracksofthelogs(seebelow)helpstoaddsmallpointsofglow,butmaydampentheoverallglow

ofthelogs.

TIP:Naturalgas(NG)canusemorerockwoolthanpropane(LP).

NOTE:Initialapplicationofrockwoolmaycause“matting”overburnerports.Turningtheunitonandthenoffagainwillloosen

therockwool,resultinginabetterflame.

 





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 9 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

15. Placetheleftcrosslogasshown.

NOTE:Thethreecross‐logsmakeitdifficulttoapplymorerockwool.Addthemafteryouhavefinishedapplyingtherockwool

andemberchunks.



16. Placethemiddlecrosslogasshown.





616 GSR Traditional Log Set

Installation Instructions (SKU94500948)



Page 10 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.



17. Placetherightcrosslogasshown.



18. Theinsertshouldbetest‐burnedwiththeglassframeinplacepriortoleavingtheinstallation.Seetheowner’smanualfordetails

onfinalizingtheinstallation(adjustingtheairshutter,etc.).

19. Checktheexhaustrestrictorsettingbeforefinalizingtheinstallation.

Restrictor Settings

Traditional Logs

Natural Gas Short Vent

(25’ or less)#3 (stock)

Natural Gas Tall Vent

(25’ or more)#3 (stock)

Propane Short Vent

(25’ or less)#1

Propane Tall Vent

(25’ or more)#3 (stock)



Otros manuales para 616 GSR

Tabla de contenidos

Otros manuales de Chimenea de interior de Travis Industries

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Manual de usuario

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Manual de usuario

Travis Industries

Travis Industries Large Flush Wood Insert Manual de usuario

Travis Industries

Travis Industries 864 TRVGreenSmart Manual de usuario

Travis Industries

Travis Industries 864 TRV Manual de usuario

Travis Industries

Travis Industries Space Saver GreenSmart 2 564 Manual de usuario

Travis Industries

Travis Industries GreenSmart 2 Fireplace 564 SS GSR2 Manual de usuario

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Manual de usuario

Travis Industries

Travis Industries 564 SS Deluxe Manual de usuario

Travis Industries

Travis Industries 864 TRV GS Manual de usuario

Travis Industries

Travis Industries GreenSmart 864 HO Manual de usuario

Travis Industries

Travis Industries 864 HO NB Manual de usuario

Travis Industries

Travis Industries 21 DV RV Manual de usuario

Travis Industries

Travis Industries Xtrordinair 44 Elite Manual de usuario

Travis Industries

Travis Industries 21 TRV GreenSmart Manual de usuario

Travis Industries

Travis Industries 21 TRV GreenSmart Manual de usuario

Travis Industries

Travis Industries 864 TRV Manual de usuario

Travis Industries

Travis Industries 564 HO Manual de usuario

Travis Industries

Travis Industries 4415 HO GSR2 Manual de usuario

Travis Industries

Travis Industries GreenSmart Fireplace 564 SS Manual de usuario

Travis Industries

Travis Industries DVL Insert Manual de usuario

Travis Industries

Travis Industries Xtrordinair ProBuilder 36 CleanFace MV Manual de usuario

Travis Industries

Travis Industries 564 HO Manual de usuario

Travis Industries

Travis Industries Xtreme 6020 Manual de usuario

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación