Toshiba G2020 Series Manual de usuario

MMS KIT

INSTALLATION MANUAL

480/480 V 500/750 kVA

Document: 4GBH0111 Rev. A

March 2020

G2020 MMS KIT Installation Manual –4GBH0111A i

UNINTERRUPTIBLE POWER SYSTEM

If additional information or technical assistance is required call TOSHIBA Customer Support Center at (877) 867-8773,

or write to: Toshiba International Corporation, 13131 West Little York Road, Houston, TX 77041-9990 Attn: UPS

Product Manager.

Keep this manual with the UPS equipment.

Job Number:

Model Number:

Serial Number:

Application:

Shipping Date:

Date of Installation:

Inspected By:

IMPORTANT NOTICE

Never attempt to install, operate, maintain or dispose of this equipment until you have first read and understood all

of the relevant product warnings and user directions that are contained in this Installation manual.

The installation of this equipment must only be performed by qualified personnel.

The Instructions contained in this manual are not intended to cover all of the details or variations in equipment or to

provide for every possible contingency to be met in connection with installation, operation, or maintenance. Should

further information be required or should particular problems arise which are not covered sufficiently the matter

should be referred to the local TOSHIBA sales office.

Nothing in this manual shall alter Toshiba International Corporation’s standard terms and conditions or the

conditions of any written sales contract.

Any Electrical or mechanical modifications to this equipment without prior written consent of

TOSHIBA will void all warranties and may void UL/CUL listing. Unauthorized modifications may

also result in personal injury, death, or equipment damage.

ii G2020 MMS KIT Installation Manual –4GBH0111A

Purpose and Scope of Manual

This manual provides information on how to safely install, operate, and maintain your TOSHIBA power electronics

product. This manual includes a section on General Safety Instructions that describes the warning labels and symbols

that are used throughout the manual. Read the manual completely before installing, operating, or performing

maintenance on this equipment.

This manual and the accompanying drawings should be considered a permanent part of the equipment and should be

readily available for reference and review. Dimensions shown in the manual are in metric and/or the English equivalent.

TOSHIBA reserves the right, without prior notice, to update information, make product changes, or to discontinue any

product or service identified in this publication.

TOSHIBA is a registered trademark of TOSHIBA INTERNATIONAL CORPORATION. All other product or trade

references appearing in this manual are registered trademarks of their respective owners.

TOSHIBA shall not be liable for technical or editorial omissions or mistakes in this manual. Nor shall it be

liable for incidental or consequential damages resulting from the use of information contained in this manual.

This manual is copyrighted. No part of this manual may be photocopied or reproduced in any form without the prior

written consent of TOSHIBA INTERNATIONAL CORPORATION.

Printed in Japan

Contacting TOSHIBA Customer Support Center

The TOSHIBA Customer Support Center can be contacted to obtain help in resolving any Uninterruptible Power

System problem that you may experience or to provide after sales service support.

Toshiba Customer Support Center

8 a.m. to 5 p.m. (CST) –Monday through Friday

Tel (877) 867-8773

Fax (713) 896-5212

E-mail –TIC-UPSservice@toshiba.com

You may contact TOSHIBA by writing to:

TOSHIBA INTERNATIONAL CORPORATION.

SOCIAL INFRASTRUCTURE SYSTEMS GROUP

POWER ELECTRONICS DIVISION

13131 West Little York Rd.

Houston, TX 77041-9990

Attn: UPS Product Manager

For further information on Toshiba products and services, please visit our website at:

http://www.toshibaups.com/

 
 
 
 
 
G2020 MMS KIT Installation Manual –4GBH0111A iii 
 Table of Contents 
Table of Contents..............................................................................................................................................................iii 
List of Tables.................................................................................................................................................................... iv 
List of Figures................................................................................................................................................................... iv 
1How to use this Manual..............................................................................................................................................1 
1.1 Notice Icons.......................................................................................................................................................1 
1.2 Qualified Personnel...........................................................................................................................................2 
2OVERVIEW................................................................................................................................................................3 
3MMS KIT parts list......................................................................................................................................................4 
4MMS Parts Location...................................................................................................................................................6 
5Installation procedure.................................................................................................................................................9 
5.1 Parallel Control Board (TLCR-E*).....................................................................................................................9 
5.2 Parallel Interface Board (IFAU-09*)................................................................................................................11 
6Dip switch setting on parallel interface board (IFAU-09*)........................................................................................14 
APPENDIX A Parallel operation system connection .................................................................................................15 
 

 
 
 
 
 
iv G2020 MMS KIT Installation Manual –4GBH0111A 
 List of Tables 
Table 3-1 Parts list of MMS KIT......................................................................................................................................4 
Table 6-1 Dip switch setting .........................................................................................................................................14 
 
List of Figures 
Figure 2-1 Parallel-connection between UPSs...............................................................................................................3 
Figure 3-1 MMS KIT parts identification.........................................................................................................................5 
Figure 4-1 MMS parts location (Rear side of door)........................................................................................................6 
Figure 4-2 MMS parts location (Inside of landing cabinet).............................................................................................7 
Figure 4-3 Diagram of MMS kit installation ....................................................................................................................8 
Figure 5-1 Location of ground bus bar (Upper)..............................................................................................................9 
Figure 5-2 Location of parallel control board (TLCR-E*)................................................................................................9 
Figure 5-3 Parallel control board (TLCR-E*) installation procedure.............................................................................10 
Figure 5-4 Location of parallel interface board (IFAU-09*) ..........................................................................................11 
Figure 5-5 Parallel interface board (IFAU-09*) installation procedure.........................................................................11 
Figure 5-6 Parallel interface board (IFAU-09*) installation procedure (continued)......................................................12 
Figure 5-7 Parallel interface board (IFAU-09*) installation procedure (continued)......................................................13 
Figure 6-1 Dip switch location on parallel interface board (IFAU-09*).........................................................................14 
Figure A-1 Diagram of power wire connections (Parallel system configuration)..........................................................15 
Figure A-2 Diagram of power wire and control wire connection (for 2 - 4 units in MMS).............................................16 
Figure A-3 Diagram of communication cable connection (for 2 - 4 units in MMS).......................................................17 
Figure A-4 Diagram of power wire and control wire connection (for 5 - 8 units in MMS).............................................18 
Figure A-5 Diagram of communication cable connection (for 5 - 8 units in MMS).......................................................19 
 

G2020 MMS KIT Installation Manual –4GBH0111A 1

1 How to use this Manual

This manual is designed for ease of use, giving the user easy and quick reference to information.

This manual uses notice icons to draw attention to the user important information regarding the safe operation and

installation of the UPS.

1.1 Notice Icons

The notice icons used in this manual are explained below, and should be taken into account and adhered to

whenever they appear in the text of this manual.

Warning: A warning symbol shows potentially hazardous situation or condition which could result in

personal injury or death, if not avoided.

Caution: A caution symbol shows potentially hazardous situation or condition which could result in

personal injury or equipment damage, if not avoided.

Note: A Note symbol shows the information the user or the service personnel should observe

during the UPS operation or service work.

Prohibit: A prohibit symbol shows the act the user or the service personnel should NEVER perform

during the UPS installation, operation or service work.

Safety Recommendations: If any problems are encountered while following this manual, contact the Toshiba

Customer Support Center.

WARNING

CAUTION

NOTE

PROHIBIT

2 G2020 MMS KIT Installation Manual –4GBH0111A

1.2 Qualified Personnel

Only qualified persons are to install, operate or service this equipment according to all applicable codes and

established safety practices.

A qualified person must:

1) Read this entire instruction manual carefully.

2) Be skilled in the installation, construction or operation of the equipment and aware of the hazards involved.

3) Be trained and authorized to safely energize, de-energize, clear, ground, lockout and tag circuits in

accordance with established safety practices

4) Be trained and authorized to perform the service, maintenance or repair of this equipment

5) Be trained in the proper care and use of protective equipment such as rubber gloves, hard hat, safety glasses,

face shield, flash clothing, etc. in accordance with established practices

6) Be trained in rendering first aid.

G2020 MMS KIT Installation Manual –4GBH0111A 3

2 OVERVIEW

TOSHIBA G2020 Uninterruptible Power Supply Systems (UPS) need an MMS KIT whenever two or more UPSs are

installed in parallel operation configuration.

Every UPS requires an MMS KIT installed to allow it to complete the communication circuit with other UPSs.

All UPSs must be de-energized when the MMS KITs are installed and the parallel

interconnections are established between the UPSs.

Figure 2-1 Parallel-connection between UPSs

CAUTION

MMS

KIT

MMS

KIT

MMS

KIT

UPS-1

UPS-2

UPS-n

4 G2020 MMS KIT Installation Manual –4GBH0111A

3 MMS KIT parts list

Table 3-1 Parts list of MMS KIT

Part #

Part name

Qty

Remarks

Parallel Interface board: IFAU-09* (IF1)

Parallel Control board: TLCR-E* (PC1)

Ferrite Core: E2530MRC

Flat Cable (TLCR-E* - UPHR-X*) 50p

CN91, 350mm

Multi-conductive cable (TLCR-E* - IFAU-09*) 34p

CN92, 1420mm

Multi-conductive cable (TLCR-E* - IFAU-09*) 20p

CN93, 1420mm

Wire (TLCR-E*_GNDC - FG)

Green, 750mm

Wire (TLCR-E*_GNDD - FG)

Green, 750mm

Wire (IFAU-09*_GNDC - FG)

Green, 330mm

Wire (IFAU-09*_GNDD - FG)

Green, 650mm

Wire (TLCR-E* - IFAU-09*) EGND, ZGND (2 twisted)

Yellow/Blue, 1540mm

Spacer: SQ-14

9 for IFAU-09*

9 for TLCR-E*

Screw (M3 x 8)

9 for IFAU-09*

9 for TLCR-E*

Screw (M4 x 8)

For connecting wire to FG

Screw (M5 x 10)

For mounting panel

Spring washer (M3)

9 for spacer of IFAU-09*

9 for spacer of TLCR-E*

Flat washer (M3)

9 for spacer of IFAU-09*

9 for spacer of TLCR-E*

Cable Tie (T30R)

Use as necessary

Label (NOTICE)

Label (MARK)

Panel (2AAA6458P003)

* –PCB revision suffix may be applied.

Otros manuales para G2020 Series

Tabla de contenidos

Otros manuales de Unión Postal Universal de Toshiba

Toshiba

Toshiba 4200FA Series Manual de usuario

Toshiba

Toshiba Satellite 1700 Series Manual de instrucciones

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba 4400 Series Manual de usuario

Toshiba

Toshiba TOSNIC-7000S Manual de usuario

Toshiba

Toshiba 1000 Series Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba UF1A1A015C6(T) Manual de usuario

Toshiba

Toshiba G2020 Series Manual de usuario

Toshiba

Toshiba 4200 FA CT Manual de usuario

Toshiba

Toshiba 1600XP SERIES Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba T90S3S08KS6XSN Manual de usuario

Toshiba

Toshiba G8000U Series Manual de usuario

Toshiba

Toshiba 1800 SERIES Manual de usuario

Toshiba

Toshiba Satellite 1700 Series Manual de usuario

Toshiba

Toshiba 4400 Series Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Toshiba

Toshiba 1600XPi SERIES Manual de usuario

Toshiba

Toshiba G9000 SERIES Manual de usuario

Manuales populares de Unión Postal Universal de otras marcas

Pylontech

Pylontech Victron & Pylontech US5000 Manual de usuario

Tecnoware

Tecnoware EVO DSP PLUS MM 6.8 Manual de usuario

Mecer

Mecer ME-1000-WTU Manual de usuario

Mustek

Mustek PowerMust 530(B) Plus Manual de instalación y operación

Emerson

Emerson Liebert NXL series Manual de usuario

MAKELSAN

MAKELSAN BOXER SERIES Manual de usuario

Block

Block PC-0524-400-0 Manual de usuario

CyberPower

CyberPower CP585LCD Manual de usuario

Eaton

Eaton 3S Instrucciones de montaje

CyberPower

CyberPower Office Tower Series UPS 1000 Manual de usuario

CyberPower

CyberPower BM100 Manual de usuario

Best Power

Best Power 610 Manual de usuario

Best Power

Best Power Unity/I UT3K Manual de usuario

Mustek

Mustek PowerMust 400 Offline Manual de usuario

Xantrex

Xantrex Trace 512 UR-UPS Manual de usuario

Forza

Forza SL-1501UL Manual de usuario

LEGRAND

LEGRAND keor 310081 Manual de usuario

ABB

ABB Conceptpower DPA 500 Manual de usuario