Toro 3318 Manual de usuario

Operator’s Manual

IMPORTANT: Read this manual carefully. It contains information about your

safety and the safety of others. Also become familiar with the controls and

their proper use before you operate the product.

FORM NO. 3318–700 Rev A

ProLine Mid-Size

18 HP

Traction Unit

Model No. 30183 – 790001 & UP

The Toro Comany – 1996

Introduction

Thank you for purchasing a Toro product.

All of us at Toro want you to be completely satisfied

with your new product, so feel free to contact your

local Authorized Service Dealer for help with service,

genuine replacement parts, or other information you

may require.

Whenever you contact your Authorized Service

Dealer or the factory, always know the model and

serial numbers of your product. These numbers will

help the Service Dealer or Service Representative

provide exact information about your specific

product. You will find the model and serial number

plate located in a unique place on the product as

shown below.

1m–2149

1. Model and Serial Number Plate

For your convenience, write the product model and

serial numbers in the space below.

Model No:

Serial No.

Read this manual carefully to learn how to operate

and maintain your product correctly. Reading this

manual will help you and others avoid personal injury

and damage to the product. Although we design,

produce and market safe, state-of-the-art products,

you are responsible for using the product properly

and safely. You are also responsible for training

persons, who you allow to use the product, about safe

operation.

The warning system in this manual identifies

potential hazards and has special safety messages that

help you and others avoid personal injury, even death.

DANGER, WARNING and CAUTION are signal

words used to identify the level of hazard. However,

regardless of the hazard, be extremely careful.

DANGER signals an extreme hazard that will cause

serious injury or death if the recommended

precautions are not followed.

WARNING signals a hazard that may cause serious

injury or death if the recommended precautions are

not followed.

CAUTION signals a hazard that may cause minor or

moderate injury if the recommended precautions are

not followed.

Two other words are also used to highlight

information. “Important” calls attention to special

mechanical information and “Note” emphasizes

general information worthy of special attention.

The left and right side of the machine is determined

by sitting on the seat in the normal operator’s

position.

The engine exhaust from this product

contains chemicals known to the State of

California to cause cancer, birth defects,

or other reproductive harm.

Contents

Page

Safety 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safe Operating Practices 2. . . . . . . . . . . . . .

Slope Chart 5. . . . . . . . . . . . . . . . . . . . . . . . .

Safety and Instruction Decals 7. . . . . . . . . .

Gasoline and Oil 8. . . . . . . . . . . . . . . . . . . . . . . .

Recommended Gasoline 8. . . . . . . . . . . . . .

Stabilizer/Conditioner 8. . . . . . . . . . . . . . . .

Filling the Fuel Tank 8. . . . . . . . . . . . . . . . .

Check Engine Oil Level 8. . . . . . . . . . . . . . .

Assembly 9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Loose Parts 9. . . . . . . . . . . . . . . . . . . . . . . . .

Install Shift Lever 10. . . . . . . . . . . . . . . . . . .

Mount Control Panel and Fuel Tank 11. . . . .

Install Upper Handle 11. . . . . . . . . . . . . . . . .

Connect Throttle Cable 12. . . . . . . . . . . . . . .

Connect Choke Cable 12. . . . . . . . . . . . . . . . .

Connect Wire Harness 13. . . . . . . . . . . . . . . .

Install Control Rods 14. . . . . . . . . . . . . . . . . .

Installing the Battery 15. . . . . . . . . . . . . . . . .

Activate the Battery 16. . . . . . . . . . . . . . . . . .

Fill Crankcase with Oil 17. . . . . . . . . . . . . . .

Operation 18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Think Safety First 18. . . . . . . . . . . . . . . . . . .

Controls 18. . . . . . . . . . . . . . . . . . . . . . . . . . .

Parking Brake 19. . . . . . . . . . . . . . . . . . . . . . .

Page

Starting and Stopping the Engine 20. . . . . . .

Operating Mower Blade Control (PTO) 21. .

The Safety Interlock System 21. . . . . . . . . . .

Driving Forward or Backward 22. . . . . . . . . .

Stopping the Machine 22. . . . . . . . . . . . . . . .

Maintenance 23. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Service Interval Chart 23. . . . . . . . . . . . . . . .

Air Cleaner 24. . . . . . . . . . . . . . . . . . . . . . . . .

Engine Oil 25. . . . . . . . . . . . . . . . . . . . . . . . .

Spark Plug 27. . . . . . . . . . . . . . . . . . . . . . . . .

Greasing and Lubrication 28. . . . . . . . . . . . . .

Cleaning the Cooling System 29. . . . . . . . . . .

Tire Pressure 29. . . . . . . . . . . . . . . . . . . . . . . .

Brake 30. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Tank 31. . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Filter 32. . . . . . . . . . . . . . . . . . . . . . . . . .

Replacing the Drive Belt 32. . . . . . . . . . . . . .

Replacing the Traction Belt 33. . . . . . . . . . . .

Adjust Electric Clutch 33. . . . . . . . . . . . . . . .

Battery 34. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Wiring Diagram 36. . . . . . . . . . . . . . . . . . . . .

Cleaning and Storage 37. . . . . . . . . . . . . . . . .

Troubleshooting 38. . . . . . . . . . . . . . . . . . . . . . . . .

Warranty Back Cover. . . . . . . . . . . . . . . . . . . . . . . . . .

       

     

    

         

       

      

 

Safety

This machine meets or exceeds safety

requirements B71.4–1990 of the American

National Standards Institute for commercial

mowers, in effect at time of production. However,

improper use or maintenance by the operator or

owner can result in injury. To reduce the potential

for injury, comply with these safety instructions

and always pay attention to the safety alert

symbol which means CAUTION, WARNING or

DANGER—“personal safety instruction.” Failure

to comply with the instruction may result in

personal injury.

Safe Operating Practices

This product is capable of amputating hands and feet

and throwing objects. Always follow all safety

instructions to avoid serious injury or death.

POTENTIAL HAZARD

•Engine exhaust contains carbon monoxide,

which is an odorless, deadly poison.

WHAT CAN HAPPEN

•Carbon monoxide can kill you and is also

known to the State of California to cause

birth defects.

HOW TO AVOID THE HAZARD

•Do not run engine indoors or in an enclosed

area.

This mower is designed for cutting and recycling

grass or, when equipped with a grass bag, for

catching cut grass. Any use for purposes other than

these could prove dangerous to user or bystanders.

Note: This engine is NOT equipped with a

spark arrester muffler. Use or operation

of this mower in the State of California

on any forest-covered, brush-covered

or unimproved grass-covered land,

without an approved spark arrester

muffler, is a violation of the law. Other

states may have similar laws.

General Operation

1. Read this manual carefully before operating the

mower. Become familiar with the controls and

proper use of the mower. Never allow children

under 16 years of age to operate the mower.

Never allow adults to operate mower without

proper instructions.

2. The operator of the mower is responsible for

keeping everyone, especially children and pets,

away from area of operation. The operator is

responsible for accidents or hazards occurring to

other people or their property.

3. Thoroughly inspect area where mower will be

used and remove sticks, stones, wire, and debris

that could be picked up and thrown by mower.

Watch for foreign objects while mowing.

4. Wear long pants and substantial shoes. Do not

operate mower while wearing open-toed shoes,

jewelry, loose clothing or when barefoot.

5. Check fuel level before starting engine. Because

fuel is highly flammable, handle it carefully.

A. Use an approved fuel container.

B. Fill fuel tank outdoors, not indoors.

NEVER ADD FUEL TO AN ENGINE

THAT IS RUNNING OR HOT.

C. Install gas cap on fuel container and gas

tank, and wipe up any spilled gasoline

before starting engine.

Safety

D. Do not smoke while refueling.

6. Keep all guards, shields, safety devices,

cover-deflector assembly, optional grass catcher,

optional side discharge chute or optional

discharge tunnel plug in place. Repair or replace

damaged parts, including decals. Check all

safety devices before each use.

7. Engine, blade and self–propelled drive

(self-propelled model) are designed to stop when

control bails are released. Ensure control and

brake function properly before each use of

mower.

8. Disengage the self-propelled mechanism or drive

clutch (self-propelled model) before starting the

engine.

9. Before using, always visually inspect to see that

the blades, blade fasteners and cutter assembly

are not worn or damaged. Replace worn or

damaged blades and fasteners in sets to preserve

balance.

While Operating

1. Do not run engine indoors.

2. Start the engine carefully according to

instructions and with feet well away from the

blade.

3. Always maintain secure footing. Keep a firm

grip on the handle and walk; never run. Never

operate mower in wet grass. Mow only in

daylight or in good artificial light.

4. Mow across the face of slopes; never up and

down. Use extreme caution when changing

direction on slopes. Do not mow excessively

steep slopes. Wear skid resistant shoes on slopes.

5. Always wear safety glasses or eye shields during

operation to protect eyes from foreign objects

that may be thrown from the machine.

6. Keep face, hands, and feet away from the mower

housing and cutter blade when the engine is

running. Blade can cause injury to hands and

feet. Stay behind the handle until the engine

stops.

7. Use extreme caution when reversing or pulling

the mower towards you.

8. Since the blade rotates for a few seconds after

the control bar is released, stay behind the

handle until all moving parts stop.

9. After striking a foreign object or if mower

vibrates abnormally, stop engine and remove

wire from spark plug. Check mower for damage

and make all repairs before using mower again.

If major repairs are ever needed or if assistance

is desired, contact your local Authorized TORO

Service Dealer.

10. Stop the engine and wait for all moving parts to

stop before adjusting the height-of-cut.

11. Stop the blade when pushing the mower outside

the lawn area.

12. Stop engine before leaving the operator’s

position—behind the handle. Disconnect wire

from spark plug if mower will be unattended.

13. Do not touch engine while it is running or

shortly after it is stopped because engine will be

hot enough to cause a burn.

14. Refuel only when engine is cool.

15. If mower must be lifted to be transported, turn

off engine and stay behind the handle until all

moving parts stop. Disconnect spark plug wire.

Safety

Maintenance And Storage

1. Perform only those maintenance instructions

described in this manual. If major repairs are

ever needed or if assistance is desired, contact

your local Authorized TORO Service Dealer.

2. Before mower is cleaned, inspected, serviced, or

adjusted, stop engine and disconnect wire from

spark plug. Keep wire away from plug to prevent

accidental starting.

3. To ensure the mower is in safe operating

condition, frequently check and keep all nuts,

bolts, and screws tight. Ensure blade bolt is

tightened to 85–110 ft-lb (115–149 Nm

4. When servicing blade, refer to blade

maintenance section for correct installation and

servicing procedures.

5. To reduce fire hazard, keep engine free of

excessive grease, grass, leaves, and

accumulations of dirt.

6. Allow engine to cool before storing mower in

any enclosure. Do not store mower with gasoline

in fuel tank near any open flame or where

gasoline fumes may be ignited by a spark.

7. Do not overspeed the engine by changing

governor settings.

8. At the time of manufacture, the mower

conformed to the safety standards in effect for

rotary mowers. To assure best performance and

continued safety certification of the mower, use

genuine TORO replacement parts and

accessories. Replacement parts and accessories

made by other manufacturers may result in

non–conformance with the safety standards, and

that could be dangerous.

Safety

Slope Chart

Read all safety instructions on pages 2–7.

Safety

Safety and Instruction Decals

Safety decals and instructions are easily visible to the operator and are located near

any area of potential danger. Replace any decal that is damaged or lost.

ON UPPER CONTROL BAR

(Part No. 82-2290)

ON CONTROL PANEL

(Part No. 82-7740)

ON CONTROL PANEL

(Part No. 71-1280)

ON LOWER CONTROL BAR

(Part No. 82-2280)

ON CONTROL PANEL

(Part No. 65-3090)

ON CONTROL PLATE

(Part No. 82-7750)

ON REAR FRAME

(Part No. 95-2814)

 ON PARKING BRAKE LE ER

(Part No. 52-2010)

Gasoline and Oil

Recommended Gasoline

Use UNLEADED Regular Gasoline suitable for

automotive use (85 pump octane minimum). Leaded

regular gasoline may be used if unleaded regular is

not available.

IMPORTANT: Never use methanol, gasoline

containing methanol, or gasohol containing

more than 10% ethanol because the fuel

system could be damaged. Do not mix oil with

gasoline.

POTENTIAL HAZARD

•In certain conditions gasoline is extremely

flammable and highly explosive.

WHAT CAN HAPPEN

•A fire or explosion from gasoline can burn

you, others, and cause property damage.

HOW TO AVOID THE HAZARD

•Use a funnel and fill the fuel tank outdoors,

in an open area, when the engine is cold.

Wipe up any gasoline that spills.

•Do not fill the fuel tank completely full.

Add gasoline to the fuel tank until the level

is 1/4” to 1/2” (6 mm to 13 mm) below the

bottom of the filler neck. This empty space

in the tank allows gasoline to expand.

•Never smoke when handling gasoline, and

stay away from an open flame or where

gasoline fumes may be ignited by a spark.

•Store gasoline in an approved container

and keep it out of the reach of children.

Never buy more than a 30-day supply of

gasoline.

Stabilizer/Conditioner

Add the correct amount of gas stabilizer/conditioner

to the gas.

•Keeps gasoline fresh during storage

•Cleans the engine while it runs

•Eliminates gum-like buildup in the fuel system,

which causes hard starting

IMPORTANT: Never use fuel additives

containing methanol or ethanol.

Filling the Fuel Tank

1. Shut the engine off.

2. Clean around the fuel tank cap and remove the

cap. Use a funnel and add unleaded regular

gasoline to the fuel tank, until the level is 1/4 to

1/2 inch (6 mm to 13 mm) below the bottom of

the filler neck. This space in the tank allows

gasoline to expand. Do not fill the fuel tank

completely full.

3. Install the fuel tank cap securely. Wipe up any

gasoline that may have spilled.

Check Engine Oil Level

Before you start the engine and use the machine,

check the oil level in the engine crankcase; refer to

Checking Oil Level, page 26.

Tabla de contenidos

Otros manuales de Cortacésped de Toro

Toro

Toro GrandStand 74534 Manual de usuario

Toro

Toro 30353 Manual de usuario

Toro

Toro Titan Z4800 Manual de usuario

Toro

Toro Groundsmaster 4500-D Manual de usuario

Toro

Toro 30440 Manual de usuario

Toro

Toro 3602 Manual de usuario

Toro

Toro Groundsmaster 4100-D Manual de usuario

Toro

Toro Recycler 20960 Manual de usuario

Toro

Toro Greensmaster 1021 Manual de usuario

Toro

Toro 133-2680 Manual de usuario

Toro

Toro 30821 Manual de usuario

Toro

Toro 30809 Groundsmaster 3500-G Manual de usuario

Toro

Toro TITAN ZX6020 Manual de usuario

Toro

Toro 22193 PT21 Manual de usuario

Toro

Toro 414300000 Manual de usuario

Toro

Toro Flex-Force Power System 60V MAX 21in Recycler... Manual de usuario

Toro

Toro wheel horse 8-25 Manual de usuario

Toro

Toro Reelmaster 4000-D 03706 Manual de usuario

Toro

Toro Super Recycler 20837 Manual de usuario

Toro

Toro Recycler II ProLine 21 Manual de usuario

Toro

Toro 74213 Manual de usuario

Toro

Toro Groundsmaster 3320 30307 Manual de usuario

Toro

Toro 139-6623 Manual de usuario

Toro

Toro 30529 Manual de usuario

Manuales populares de Cortacésped de otras marcas

RHINO

RHINO 1958 Manual de usuario

Wolf Garten

Wolf Garten Compact plus 40 B Manual de usuario

Cub Cadet

Cub Cadet LTX 1045 Manual de usuario

Craftsman

Craftsman 917.378461 Manual de usuario

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Manual de usuario

Challenge

Challenge CH18V2 Instrucciones de operación

TALEN TOOLS

TALEN TOOLS AVR HGM30 Manual de usuario

DEWEZE

DEWEZE ATM-725 Manual de operación

Weed Eater

Weed Eater 180083 Manual de usuario

Husqvarna

Husqvarna Poulan Pro PP185A42 Manual de usuario

Better Outdoor Products

Better Outdoor Products Quick Series Manual de usuario

Cub Cadet

Cub Cadet 23HP Z-Force 60 Manual de funcionamiento

MTD

MTD 795, 792, 791, 790 Manual de usuario

Dennis

Dennis FT 610 Manual de usuario

AIRFORCE

AIRFORCE F-15 Gen 3 Manual de usuario

MTD

MTD 126-220-000 Manual de usuario

Stihl

Stihl RMA 443 PV Manual de usuario

Yard-Man

Yard-Man 3700-0 Manual de usuario