Thrane&Thrane SAILOR 6120 Manual de usuario

INSTALLATION MANUAL

SAILOR 6120/30/40/50 System

Installation manual

Document number: 98-131589-A

Release date: May 16, 2011

Disclaimer

Any responsibility or liability for loss or damage in connection with the use of this

product and the accompanying documentation is disclaimed by Thrane & Thrane. The

information in this manual is provided for information purposes only, is subject to

change without notice and may contain errors or inaccuracies.

Manuals issued by Thrane & Thrane are periodically revised and updated. Anyone

relying on this information should acquire the most current version e.g. from

http://www.thrane.com or from the distributor.

Thrane & Thrane is not responsible for the content or accuracy of any translations or

reproductions, in whole or in part, of this manual from any other source.

Trademark Acknowledgements

•Thrane & Thrane is a registered trademark of Thrane & Thrane A/S in the European

Union and the United States.

•Inmarsat is a registered trademark of the International Maritime Satellite

Organisation (IMSO) and is licensed by IMSO to Inmarsat Limited and Inmarsat

Ventures plc.

•SAILOR is a registered trademark of Thrane & Thrane A/S in the European Union, the

United States and other countries.

• Other product and company names mentioned in this manual may be trademarks or

trade names of their respective owners.

iii

Safety summary 1

The following general safety precautions must be observed during all

phases of operation, service and repair of this equipment. Failure to comply

with these precautions or with specific warnings elsewhere in this manual

violates safety standards of design, manufacture and intended use of the

equipment. Thrane & Thrane assumes no liability for the customer's failure

to comply with these requirements.

Observe marked areas

Under extreme heat conditions do not touch areas of

units that are marked with this symbol, as it may

result in injury.

Microwave radiation hazards

During transmission the antenna in this system radiates Microwave

Power.This radiation may be hazardous to humans close to the antenna.

When the system is powered, make sure that nobody gets closer than the

recommended minimum safety distance of 0.3 m (1 ft.).

Keep away from live circuits

Operating personnel must not remove equipment covers. Only qualified

maintenance personal must make component replacement and internal

adjustment. Under certain conditions, dangerous voltages may exist even

with the cable removed. To avoid injuries, always disconnect power and

discharge circuits before touching them.

Compass safe distance

Minimum safety distance: 5 m from the Mini-C Terminal.

About the manual 2

Naming conventions

This manual covers four different types of system. For information

that applies to all four types, the following naming conventions are

used:

Intended readers

This manual is an installation manual for the SAILOR

6120/30/40/50 Mini-C Systems. The manual is intended for

installers of the system and service personnel. Personnel installing

or servicing the system must be properly trained and authorized by

Thrane & Thrane. It is important that you observe all safety

requirements listed in the beginning of this manual, and install

the system according to the guidelines in this manual.

Common name Used for

Mini-C System SAILOR 6120 SSA System

SAILOR 6130 LRIT System

SAILOR 6140 Maritime System

SAILOR 6150 Non-SOLAS System

Mini-C Terminal SAILOR 3027 SSA Terminal

SAILOR 3027 LRIT Terminal

SAILOR 3027 Maritime Terminal

SAILOR 3027 Non-SOLAS Terminal

Manual overview

Note that this manual does not cover how to use the system. For

information on usage refer to the user manual. Part numbers for

related manuals are listed in the next section.

This manual has the following chapters:

•Introduction contains an overview of the system.

•Installing the system explains how to mount the units.

•Connecting the system explains how to connect the units in the

system and shows wiring, pin-out and cable requirements.

•Configuration describes the tools available and explains the

initial configuration of the system.

•Installation check and test contains a check list for verifying the

physical installation and guidelines for testing the installation.

•Service and maintenance contains guidelines for handling,

maintaining and repacking the SAILOR 6120/30/40/50 system.

Related documents

The below list shows the documents related to this manual and to

the SAILOR 6120/30/40/50 Mini-C System.

Ref Title and description Document

number

[1] SAILOR 6120/30/40/50 System,

User manual

98-131590

[2] SAILOR 6006 and 6007 Message Terminal,

Installation manual

98-130088

[3] THRANE 6194 Terminal Control Unit,

Installation and user manual

98-131593

Typography

In this manual, typography is used as indicated below:

Bold is used for the following purposes:

• To emphasize words.

Example: “Do not touch the antenna”.

• To indicate what the user should select in the user interface.

Example: “Select SETTINGS > LAN”.

Italic is used to emphasize the paragraph title in cross-references.

Example: “For further information, see Connecting Cables on

page...”.

COURIER is used to indicate low level commands or text in the

display.

Example: “The display shows Distress”.

Online training for Thrane & Thrane partners

As a Thrane & Thrane Partner you have access to free of charge

technical training in this SAILOR product covering installation,

commissioning and repair.

For details on available training classes please consult the Thrane

Academy at http://extranet.thrane.com/Training.aspx.

To learn more on CAN-bus as used with this product you may take

the eLearning course “Introduction to CAN-bus” available at

http://extranet.thrane.com/Training.aspx

[4] THRANE 6194 Software Interface

Reference Manual

98-132853

[5] SAILOR 3027 Software Interface Reference

Manual

98-132852

Ref Title and description Document

number

vii

Table of contents

Chapter 1 Introduction

1.1 SAILOR 6120/30/40/50 system overview .....................2

1.2 Units in the system ....................................................6

Chapter 2 Installing the system

2.1 Unpacking ................................................................ 11

2.2 General installation requirements .............................13

2.3 Installing the SAILOR 3027 ........................................14

Chapter 3 Connecting the system

3.1 Connecting the units .................................................21

3.2 Grounding the units .................................................28

3.3 The CAN backbone ....................................................31

3.4 Connecting power .................................................... 32

3.5 Connectors and pin-out ...........................................38

Chapter 4 Configuration

4.1 Registering your SAILOR 3027 ..................................46

4.2 Configuration tools ..................................................48

4.3 Configuration using easyMail ..................................49

4.4 Configuration using commands ...............................54

Chapter 5 Installation check and test

5.1 Installation check list ...............................................58

5.2 Testing the SAILOR 6130 LRIT System .......................59

Table of contents

viii

5.3 Testing the system with easyMail ............................ 60

Chapter 6 Service and maintenance

6.1 Updating software ....................................................63

6.2 Maintenance guidelines ...........................................65

6.3 Service and repair ....................................................66

6.4 Available parts .........................................................67

App. A Technical specifications

A.1 SAILOR 6120/30/40/50 system specifications ........... 69

A.2 SAILOR 3027 specifications .......................................70

Glossary .........................................................................................73

Index .........................................................................................77

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Antena de Thrane&Thrane

Thrane&Thrane

Thrane&Thrane SAILOR 6110 Manual de usuario

Thrane&Thrane

Thrane&Thrane TT-3084A Sailor Fleet77 Manual de usuario

Thrane&Thrane

Thrane&Thrane Explorer 300 Manual de usuario

Thrane&Thrane

Thrane&Thrane SAILOR TT-3084A Fleet 77 Manual de usuario

Thrane&Thrane

Thrane&Thrane EXPLORER 500 Manual de usuario

Thrane&Thrane

Thrane&Thrane EXPLORER 700 Manual de usuario

Thrane&Thrane

Thrane&Thrane SAILOR 900 Manual de usuario

Thrane&Thrane

Thrane&Thrane EXPLORER 500 Manual de usuario

Thrane&Thrane

Thrane&Thrane SAILOR 900 VSAT System Manual de usuario

Thrane&Thrane

Thrane&Thrane SAILOR 150 Manual de usuario

Thrane&Thrane

Thrane&Thrane TT-3720A EXPLORER 700 Manual de usuario

Thrane&Thrane

Thrane&Thrane Explorer 727 Manual de usuario

Thrane&Thrane

Thrane&Thrane SAILOR 900 VSAT System Manual de usuario

Thrane&Thrane

Thrane&Thrane Explorer 325 Manual de usuario

Thrane&Thrane

Thrane&Thrane Explorer 527 Manual de usuario

Manuales populares de Antena de otras marcas

Alfa Network

Alfa Network APA-L01 Manual de usuario

Naval

Naval PR-422CA Manual de usuario

Feig Electronic

Feig Electronic ID ISC.ANTH200/200 Series Manual de usuario

TERK Technologies

TERK Technologies TV44 Manual de usuario

Directive Systems & Engineering

Directive Systems & Engineering DSE2324LYRMK Manual de usuario

HP J8999A Manual de usuario

MobilSat

MobilSat MSP-S Manual de usuario

Steren

Steren ANT-UHF 13 Manual de usuario

Novatel

Novatel 600-G Manual de operación

Radio Shack

Radio Shack Amplified VHF/UHF/FM Indoor Antenna Manual de usuario

TRENDnet

TRENDnet TEW-AO12O Manual de usuario

Radio Shack

Radio Shack 15-1837 Manual de usuario

CommScope

CommScope CMAX-OMFX-43M-I53 Manual de usuario

Ramsey Electronics

Ramsey Electronics DAP25 Manual de usuario

COBHAM

COBHAM SAILOR 800 VSAT Manual de uso y cuidado

Trango Systems

Trango Systems AD900-9 Manual de usuario

Steren

Steren ANT-100 Manual de usuario

Proxim

Proxim 5054-PA-23 Manual de usuario