Texas FRANKLIN Manual de usuario
INSTRUCTION MANUAL
FRANKLIN CHARCOAL BBQ
IMPORTANT: Please read these instructions before
using the product and retain for future use.
BBQ-Homebase-BB03024A-IM-21x29.7cm lucy 20181137 20181029
2
Before using the product
After unpacking and before every use, check whether the product shows any signs of damage.
Should this be the case, do not use the item and notify your retailer.
Before assembly, please read through the safety information in this operating manual carefully. Only by doing so will you be able to use all of the functions safely and reliably.
Keep the operating manual and pass it on to any third party that might own the barbecue after you
Components - parts.
PARTS LIST
5
4
3
21
8.1
13
19
20
21
22
23
24 24.1
25
26
29
28
14
27
151617
18
12
810
11
9
7
6
30 31
32
x1
x4
x1
1. Handle for lid
2. Lid handle base
3. Lid
4. Air vent
5. Thermometer x1
6. Upper hinge x2
x4
3
x1
x1
x1
x2
x1
9. Lower hinge
10. Body back plate
x1
11. Body right plate
x1
12. Charcoal bowl
x1
x1
13. Body left plate
x2
x1
7. Warm grid
14. Body front plate
x1
x1
8. Outer cooking grill
15. Lifting handle
x1
x1
8.1 Inner cooking grill
17. Carbon door handle base
x1
16. Carbon door bar
x1
x1
Components - parts
18. Carbon door handle
19. Pulling handle base
20. Pulling handle
21. Bottle openner
22. Ash pan
23. Handle for ash pan
44
x27A. M6 x12 J. D6 x7
x4B. M5 x10 K. M6 x4
x4C. D5 L. M6 x40 x4
x4D. D5 M. M6 x35 x4
x4E. M5 N. M6 x16 x4
x2F. M10 O. D6 x35 x2
x2G. M6 x70 P. M6 x18 x4
x3H. D1.4 Q. Washer M6 x1
x1I. M5 x30
Component - fittings
Please check you have all the fittings listed below.
Note: The quantities below are the correct amount to complete the assembly. In some cases, more fittings may be supplied than are required.
x1
x2
x1
x1
x1
25. Back long leg
26. Bottom plate
x1
27. Back wheel leg
x2
28. Front wheel leg
x2
29. Wheel axle
x1
24. Front long leg
30. Wheel
24.1 Leg cup
31. Wheel cap
32. Right side table
x1
5
Intended use
Use this barbecue to heat, cook and grill food.
This barbecue is intended exclusively for private, outdoor use and not for indoor or commercial use.
Only use the item as described in this operating manual. All other uses are considered improper and can lead to material damage or even to personal injuries.
The manufacturer accepts no liability for damages caused by improper use.
For your safety
Signal symbols
DANGER: High risk!
Failure to observe the warning can lead to potentially fatal injuries.
ATTENTION: Moderate risk!
Disregarding this warning can lead to property damage.
CAUTION: Low risk!
Facts that should be respected when handling the product.
GENERAL SAFETY INSTRUCTIONS
To be observed with each use:
• Do not use indoors!
• WARNING! Do not use spirits or petrol for lighting or relighting!
• Use only firelighters complying to EN 1860-3!
• WARNING! This barbeque will become very hot; do not move it during operation!
• WARNING! Keep children and pets away!
Do not use the barbecue in a confined and/or habitable space, e.g. houses, tents, caravans, motor homes or boats. Danger of carbon
monoxide poisoning fatality!
Do not cook before the fuel has a coating of ash.
Safety instructions
DANGER: Fire hazard!
Live coals and barbecue components get very hot during operation and can start fires.
• It is essential that you have a fire extinguisher and first-aid kit ready and be prepared for an accident or fire.
• Place the barbecue on an even, horizontal, secure, heat-resistant and clean surface.
• Set up the barbecue with at least 1 metre clearance from highly-flammable materials, such as awnings, wooden patios or furniture.
• Do not move the barbecue during use.
• Ignite the charcoal only in a sheltered location.
• Fill the barbecue with a maximum of 1.35kg of charcoal.
• Some foods produce flammable fats and juices. Clean the barbecue regularly, preferably after each use.
• Only tip out the ash once the charcoal has completely burned out and cooled down.
6
DANGER: Risk of burning and accidents!
This product is not intended for use by persons (incl. children) with limited physical, sensory, or mental capacities or lacking experience and/or lacking knowledge.
• Such persons must be informed about the dangers of the product and supervised by a person responsible for their safety.
• Any modifications to the product represent a large safety risk and are forbidden. Do not undertake any unauthorised interventions yourself. In case of damages, repairs or other
problems with the barbecue, contact your local store.
• Keep children and pets away from the product. The barbecue, the charcoal, and the barbecue meat become very hot during use. Any contact can result in serious burns.
• Keep sufficient distance from the hot parts, since any contact can lead to severe burns.
• Always wear oven or barbecue gloves when grilling.
• Use only long-handled utensils with heat-resistant grips.
• Do not wear any clothing with wide sleeves. Tie back long hair.
• Use only firelighters complying to EN 1860-3.
• Let the barbecue cool down completely before cleaning and/or storage.
DANGER: Risk of explosion!
Flammable liquids that are poured on the embers can cause flash flames or explosions.
• Never use flammable liquids, such as petrol or spirits.
• Nor put pieces of charcoal soaked in flammable liquid onto the embers.
DANGER: Risk of poisoning!
When burning charcoal, barbecue briquettes, etc., carbon monoxide is formed. This gas is odourless and can be fatal in enclosed spaces!
Use the grill outdoors only!
DANGER: Health risk!
Do not use any decolourants or thinners to remove stains. These are harmful to health and must not come into contact with food.
DANGER: Risks to children!
• Do not let children play with the packaging films. Remove before assembly and dispose of safely.
• Make sure that children do not put any small assembly parts into their mouths. They could swallow the parts and choke on them.
DANGER: Risk of injury!
Both the barbecue and individual parts may have some sharp edges.
• Be careful with individual parts to prevent accidents and/or injury during assembly and wear protective gloves if necessary.
• Do not set up the barbecue near entryways or high-traffic areas.
• Always exercise extreme caution while grilling. If distracted, you can lose control of the product.
ATTENTION: Risk of injury!
During use, the screws can loosen slowly and impair the barbecue’s stability.
Check the tightness of the screws prior to each use. If necessary, tighten all of the screws again to ensure the barbecue is standing securely.
ATTENTION: Risk of damage!
Use a non-abrasive cloth or pad and clean with hot soapy water. Do not use scouring pads or powders, as they can permanently damage the finish.
Assembly
Preparation
DANGER: Risk of injury!
Failure to follow these instructions can lead to problems and risks while using the barbecue.
Follow all of the assembly instructions listed here:
7
1. First, read through the assembly instructions completely.
2. Allow yourself enough time for assembly and find an even working space of two to three square metres.
3. Small parts, such as handles, will probably be preassembled.
Required tools
1 x Phillips screwdriver
1 x Adjustable spanner
Assembling the BBQ
Unpack BBQ
Unpack the barbecue and safely dispose of all packaging materials. Keep the packaging materials out of the reach of children and dispose of them according to regulations after
assembly.
Take the following steps to assemble the barbecue.
Step 1
Step 2
Step 3
13 10
Ax8
11
14
Ex2
Bx2
Ax8
28
25
24
24.1
27
4
Dx2
Cx2
Step 4
8
Step 5
21
Ax2
Ax6
Fx2
20 19
Gx2
26
29
30
31
9
Step 6
12
Ax4
Hx1
Ax1
10
Step 7Step 7
15
Ix1
Tabla de contenidos
