Swisher ZT2460 Z-MAX Manual de usuario

OWNER’S MANUAL

ZT2460

24 HP – 60” CUT

1602 CORPORATE DRIVE, P.O. BOX 67, WARRENSBURG, MISSOURI 64093

PHONE 660-747-8183 FAX 660-747-8650

Manufacturing quality lawn care equipment since 1945

Made In The

USA

CELEBRATING60YEARSOFINNOVATION

1945-2005

10277 Rev 05-010 STARTING SERIAL # L505-040001

LIMITED WARRANTY

The manufacturer’s warranty to the original consumer purchaser is: This product is free

from defects in materials and workmanship for a period of two (2) years from the date of

purchase by the original consumer purchaser. We will repair or replace, at our discretion,

parts found to be defective due to materials or workmanship. This warranty is subject to the

following limitations and exclusions:

In the event you have a claim under this warranty, you must return the product to an

authorized service dealer. All transportation charges, damage, or loss incurred during

transportation of parts submitted for replacement or repair under this warranty shall be borne

by the purchaser. Should you have any questions concerning this warranty, please contact

us toll-free at 1-800-222-8183. The model number, serial number, date of purchase, and the

name of the authorized Swisher dealer from whom you purchased the mower will be needed

before any warranty claim can be processed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME

PERIODS STATED HEREIN FOR ALL EXPRESSED WARRANTIES. Some states do not

allow the limitation of consequential damages or limitations on how long an implied warranty

may last, so the above limitations or exclusions may not apply to you. This warranty gives

you specific legal rights and you may have other rights, which vary from state-to-state. This is

a limited warranty as defined by the Magnuson-Moss Act of 1975.

1) Engine Warranty All engines utilized on our products have a separate warranty

extended to them by the individual engine manufacturer. Any

engine service difficulty is the responsibility of the engine

manufacturer and in no way is Swisher Mower Co., Inc. or its

agents responsible for the engine warranty. The Briggs &

Stratton Engine Service Hot-Line is 1-800-233-3723. The

Tecumseh Engine Service Hot-Line is 1-800-558-5402.

2) Commercial Use This product is not intended for commercial use and

carries no commercial warranty.

3) Limitation This warranty applies only to products which have been

properly assembled, adjusted, and operated in accordance

with the instructions contained within this manual. This

warranty does not apply to any product of Swisher Mower

Co., Inc., that has been subject to alteration, misuse, abuse,

improper assembly or installation, shipping damage, or to

normal wear of the product.

4) Exclusions Excluded from this warranty are normal wear, normal

adjustments, and normal maintenance.

CONTENTS

LIMITED WARRANTY……….

OPERATION………………..……

…

INTRODUCTION………………

4 Features……………………… 16

General………………………… 4 Starting………………………. 19

Before Operating………………… 4 Grass Height of Cut…………. 19

Uncrating & Assembly………. 5 Controls………...……..……… 20

SYMBOLS & DECALS……….

SERVICE & ADJUSTMENTS..

SAFETY INSTRUCTIONS….

8 Adjusting Deck Height……. 21

General use and safety rules… 8 Deck Level………………… 21

Slope Operation……………… 10 Deck Belt Replacement…. 22

Children Safety……………… 10 Hydro Belt Replacement…. 23

SPECIFICATIONS…………..

11 Seat Adjustment………….. 24

CUSTOMER

Parking Brakes…………… 25

RESPONSIABLITY…………

WIRING SCHEMATIC………

Operator Presence………. 12

PARTS BREAKDOWN………

Tires………………………….. 12

TROUBLESHOOTING……….

Blade Maintenance………… 13

MOWER IDENTIFICATION….

Battery………………………… 13

REPLACEMENT PARTS……

V-belts………………………. 14

MAINTENCE LOG……………

Engine………………………. 14

SWISHER HISTORY………..

Overall Unit Care………….... 14

Transporting Safety………… 14

Maintenance……….………… 15

INTRODUCTION

Introduction

Congratulations

Thank you for purchasing a Swisher Zero Turn mower. This machine is built for the greatest

efficiency and rapid mowing of large areas. Conveniently located controls and dual

commercial grade hydrostatic transmissions regulated by steering levers, contribute to the

machine’s performance.

This manual is a valuable document. Following the instructions for use, service,

maintenance, etc. can greatly increase the life-span of your machine .

General

In this operator’s manual, left and right, backward and forward are used in relation to the normal

operators position.

Read Before Operating

This machine is constructed only for mowing grass on lawns and other free and even ground

without obstacles. This machine is not intended for commercial use. The manufacturer’s

directions concerning operation, maintenance, and repairs must be carefully followed.

This machine must only be operated, maintained, and repaired by persons that are familiar

with the machine’s special characteristics and who are well versed in safety instructions.

Accident prevention regulations, other general safety regulations, occupational safety rules,

and traffic regulations must be followed without fail.

Unauthorized modifications to the design of the machine may absolve the manufacturer

from liability for any resulting personal injury or property damage.

¾Read engine manufacturer’s

operating and maintenance

instructions.

¾Read and observe all safety

instructions on your mower and in the

manual

¾Check engine oil.

¾Check fuel caps to sure that they

are in place.

¾Set control handles outward – setting parking

brake

¾Be sure mower blades are turned off –

PTO switch pushed down.

¾Know how to stop the engine – Turn key to

off

¾Know how to stop the unit – Return control

handles to neutral

NOTE:

If you have never used a Zero Turn mower before, refer to

the Operation Controls section of this manual before

attempting to operate one for the first time.

INTRODUCTION

Uncrating & Assembly

¾Dispose of top and side panels of the crate.

¾Remove loose parts and packing material

¾Cut any banding or strapping that may be holding the mower to the crate.

¾Disengage spark plug wire and place where it cannot make a connection.

¾Raise the mower deck to its highest position..

¾Disengage the parking brakes by placing the handle controls in the upright position.

¾Open the transmission valves at the rear of the unit by pulling the release rods and

locking them in place. SEE INSTRUCTION DECAL AT THE REAR OF THE UNIT.

¾Carefully push the mower off the crate to a safe and level area.

¾Check engine oil. All engines are filled with oil and tested at the factory. Verify oil level

and add if necessary before starting engine. SEE ENGINE OWNER’S MANUAL

¾Check the battery. If the battery is put into service after the “month & year” of the date

on the battery, then it may need to be charged with a 12 volt charger for a minimum of 1

hour, but no more than 2 hours at a rate of 6 to 10 amps.

¾Attach battery cables to battery. Always attach the positive terminal first.

¾Install steering levers. Remove the bolts from the control arms on the mower. Align

the holes in the lever with the holes in the control arms and attach with the bolts provided.

Make sure both bolts on both handles are tight.

¾Close the transmission valves at the rear of the unit. SEE INSTRUCTION DECAL AT

THE REAR OF THE UNIT.

¾Reconnect spark plug wire.

¾Check tire pressure on all four wheels. REFER TO UNIT SPECIFICATIONS TABLE

TOOLS REQUIRED:

92 - ½” Wrenches or ½” Socket with drive ratchet

9Tire pressure gauge

9Nail bar or claw hammer

9Wire snips

To Remove The Mower From The Crate

SYMBOLS & DECALS

Triangle Danger Decal – OD55

Swisher Flag U.S.A.– OD39 Notice Do Not Alter Wiring Decal– OD74

Operator Must Be Seated Decal– OD73

Flying Debris Decal – OD43 No Step Decal – OD11

OD45- Warning Decal

SYMBOLS & DECALS cont.

Decals Not Shown

OD99128 60” Deck White Decal

10275 ZT2460 Decal Small

10281 Height Adjust Decal

10542 Replacement Parts Decal

10274 Z-Max Decal

OD99125 Medium Swisher Decal

Hydro Release - 10280

Danger/Warning Decal - 10276

Throttle/Choke Decal - 10271

Parking Brake Decal

Right - 10279

Parking Brake Decal

Left - 10270 Key/PTO Decal - 10273

SAFETY INSTRUCTIONS

Safety Instructions

These instructions are for your safety. Read them carefully.

General Use

¾Read all instructions in this operator’s manual

and on the machine before starting it. Ensure that

you understand them and then abide by them.

¾Learn how to use the machine and its controls

safely and learn how to stop quickly. Also learn to

recognize the safety decals.

¾Only allow the machine to be used by adults

who are familiar with its use.

¾Make sure nobody else is in the area of the

machine when you start the engine, engage the

drive, or run the machine.

¾Stop the machine if someone enters the work

area.

¾Clear the area of objects such as stones, toys,

steel wire, etc. that may become caught in the

blades and thrown out.

¾Do Not Use this machine without the

Discharge Chute in place.

This Safety Alert Symbol indicates important messages in

this manual. When you see this symbol, carefully read the

message that follows and be alert to the possibility of

personal injury.

NOTE:

If you have never used a Zero

Turn mower before, refer to the

Operation Controls section of

this manual before attempting to

operate one for the first time.

¾Stop the engine and disconnect the spark plug

before cleaning the discharge deck.

¾Never take passengers. The machine is only

intended for use by one person.

¾Always look around before and during reversing

maneuvers.

¾Slow down before turning.

¾Shut down the mower deck when not mowing.

¾Be careful when rounding fixed objects, so that

the blades do not hit them.

¾Only operate the machine in daylight or other

well-lit conditions.

¾Keep the machine a safe distance from holes or

other irregularities in the ground.

¾Never use the machine if you are tired, if you

have consumed alcohol, or if you are taking other

drugs or medications that can affect your vision,

judgment, or coordination.

¾Beware of traffic when working near or crossing

a road.

SAFETY INSTRUCTIONS

General Use Continued Remember

The operator is

responsible for

avoiding dangers or

accidents.

¾Never leave the machine unsupervised with the

engine running. Always shut down the blades,

engage the parking brakes, stop the engine, and

remove the ignition key before leaving the machine.

¾Never allow children or other persons not

trained in the use of the machine to use or service

it. Local laws may regulate the age of the user.

¾Make sure that you have first aid equipment close

at hand when using the machine.

¾Never use the machine when barefoot. Always

wear protective shoes or boots.

¾Always wear approved protective glasses or a full

visor when assembling or driving.

¾Ear Protection is recommended

¾Never wear loose clothing that can get caught in

moving parts.

WARNING

When using the

machine, approved

personal protective

equipment shall be

used. Personal

protective

equipment cannot

eliminate the risk of

injury, but it will

reduce the degree of

injury if an accident

does occur. Ask

your retailer for help

in choosing the right

equipment.

SAFETY INSTRUCTIONS

Slope Operation

¾Remove obstacles such as stones, tree branches, etc.

¾Mow up and down, not side to side. Never drive the rider on

terrain that slopes more than 10 degrees.

¾Avoid starting or stopping on a slope. If the tires begin to

slip, shut down the blades and drive slowly down the slope.

¾Always drive evenly and slowly on slopes.

¾Make no sudden changes in speed or direction.

¾Avoid unnecessary turns on slopes, and if it proves

necessary, turn slowly and gradually downward, if possible.

¾Watch for holes, ruts, or bumps. On uneven terrain, the

machine can tip more easily. Long grass can hide obstacles.

¾Drive slowly and use small movements of the steering

controls.

¾Do not mow wet grass. It is slippery, and the tires can loose

their grip, so that the machine slides.

¾Do not try to stabilize the machine by putting a foot on the

ground.

¾Serious accidents may occur if you fail to be on guard for

children in the area of the machine. Children are often attracted

to the machine and mowing work. Never assume that children

will stay put where you last saw them.

¾Keep children away from the mowing area and under close

supervision by another adult.

¾Shut off the machine if children enter the work area.

¾Never allow a child to ride with you.

¾Never allow children to operate the machine.

¾Be extra cautious near corners, bushes, trees, or other

objects that block your view.

Children

Remember

The operator is

responsible for

avoiding dangers or

accidents.

Tabla de contenidos

Otros manuales de Cortacésped de Swisher

Swisher

Swisher ST60022Q Manual de usuario

Swisher

Swisher FC1966BS Manual de usuario

Swisher

Swisher ZTR2454BS Manual de usuario

Swisher

Swisher TRAILMOWER POL14560X Manual de usuario

Swisher

Swisher L118-236001 Manual de usuario

Swisher

Swisher ZT1436B, ZT18542, ZT2250 Manual de usuario

Swisher

Swisher Trim-N-Mow Plus STS67522BS Manual de usuario

Swisher

Swisher POL 14560 Manual de usuario

Swisher

Swisher RESPONSE ZTR2354KA Manual de usuario

Swisher

Swisher ST60022Q Manual de usuario

Swisher

Swisher Z-MAX ZT2350A Manual de usuario

Swisher

Swisher Commercial Pro Response Z21554CPHO-CA Manual de usuario

Swisher

Swisher ST67522CC Manual de usuario

Swisher

Swisher ST60022Q Manual de usuario

Swisher

Swisher Response Commercial Pro ZTR2766CP Manual de usuario

Swisher

Swisher RT10544, RT80044 Manual de usuario

Swisher

Swisher ST50022STDQ Manual de usuario

Swisher

Swisher Trim-N-Mow Manual de usuario

Swisher

Swisher T11044, T11544, T10544BSPB, T1 Manual de usuario

Swisher

Swisher ZT2760B Manual de usuario

Swisher

Swisher POL10544C Manual de usuario

Swisher

Swisher ZTR2460BS-CA Manual de usuario

Swisher

Swisher 97-056001 Manual de usuario

Swisher

Swisher ZT2866 Manual de usuario

Manuales populares de Cortacésped de otras marcas

RHINO

RHINO 1958 Manual de usuario

Wolf Garten

Wolf Garten Compact plus 40 B Manual de usuario

Cub Cadet

Cub Cadet LTX 1045 Manual de usuario

Craftsman

Craftsman 917.378461 Manual de usuario

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Manual de usuario

Challenge

Challenge CH18V2 Instrucciones de operación

TALEN TOOLS

TALEN TOOLS AVR HGM30 Manual de usuario

DEWEZE

DEWEZE ATM-725 Manual de operación

Weed Eater

Weed Eater 180083 Manual de usuario

Husqvarna

Husqvarna Poulan Pro PP185A42 Manual de usuario

Better Outdoor Products

Better Outdoor Products Quick Series Manual de usuario

Cub Cadet

Cub Cadet 23HP Z-Force 60 Manual de funcionamiento

MTD

MTD 795, 792, 791, 790 Manual de usuario

Toro

Toro Groundsmaster 3505-D Manual de usuario

Dennis

Dennis FT 610 Manual de usuario

AIRFORCE

AIRFORCE F-15 Gen 3 Manual de usuario

MTD

MTD 126-220-000 Manual de usuario

Toro

Toro 74806 Manual de usuario