Sunna Design Sol EVERGEN M Series Manual de usuario

SINGLE PANEL SIDE MOUNT USER MANUAL

EVERGEN M SERIES

Sol by Sunna Design | 990 Biscayne Boulevard, Office 701, Miami, FL 33132, USA | 1.800.959.1329 | customerservice@solarlighting.com

87604_Single_Panel_Side_Mount_Manual_RevA

SINGLE PANEL SIDE MOUNT USER MANUAL

COMPONENTS

Sol by Sunna Design | 990 Biscayne Boulevard, Office 701, Miami, FL 33132, USA | 1.800.959.1329 | customerservice@solarlighting.com

Item Description Quantity

1Large Bucket 2

2Clips 4

3PV Rails 2

4Support Rails (combine to create 2 rails) 4

5Banding (for up to 4.5” OD) 4

Hardware:

•Buck and Clip Hardware

•5/16-18 ¾” Bolts, Washers, Lock Washers, Nuts

•Support Rail Hardware

•5/16-18 ¾” Bolts, Washers, Lock Washers, Nuts

•Panel Hardware

•1/4-20 ¾” Bolts, Washers, Lock Washers, Nuts

•Spare Hardware

•5/16-18 ¾” Bolts, Washers, Lock Washers, Nuts

16 Sets

6 Sets

4 sets

2 set

Tools:

•5/16 and 1/2 inch socket and wrench

•Torque Wrench

•Banding Tools

•Tape Measure

•Compass

Notes:

•This mount is designed to be installed on a variety of pole sizes achieving 30 or 45 degree

panel tilt.

•The provided banding will work on 2” to 4.5” poles. For Poles with diameter greater then

4.5” you will need to source your own 1/2” banding materials.

SINGLE PANEL SIDE MOUNT USER MANUAL

INSTALLATION

Sol by Sunna Design | 990 Biscayne Boulevard, Office 701, Miami, FL 33132, USA | 1.800.959.1329 | customerservice@solarlighting.com

Step 1

A. Using banding, install top support bucket at the desired height on the pole facing it directly

south towards the equator. Use a compass to verify.

B. From the center of the top bucket, install the center of the bottom bucket 32.75 inches below,

facing the same direction.

C. Install all clips in the proper orientation; all clips face in, top clips have the arc facing down,

bottom clips have the arc facing up. Using 5/16-18 hardware, hand tighten all nuts and bolts

for adjustment later.

32.75in

SINGLE PANEL SIDE MOUNT USER MANUAL

INSTALLATION

Sol by Sunna Design | 990 Biscayne Boulevard, Office 701, Miami, FL 33132, USA | 1.800.959.1329 | customerservice@solarlighting.com

Step 2

A. Install PV support rails, channels facing out, on the outside of the top clips using 5/16

hardware and hand tighten.

B. Adjust top clips evenly so that the center of the PV rail mounting slots are 33.5in apart at

the top of the PV rail.

33.5in

Step 3

A. Combine two smaller support rails to make one large rail. Rails should nest into each

other so the holes line up using 5/16 hardware. Tighten all hardware to 144 in-lbs.

A-30) For 30 degrees tilt, rails should overlap 7 inches in the middle with the total

length being 31 inches.

A-45) For 45 degrees tilt, rails should overlap 13 inches in the middle with the total

length being 25 inches.

31 in

7 in

25 in

13 in

SINGLE PANEL SIDE MOUNT USER MANUAL

INSTALLATION

Sol by Sunna Design | 990 Biscayne Boulevard, Office 701, Miami, FL 33132, USA | 1.800.959.1329 | customerservice@solarlighting.com

Step 4

A. Attach support rail on the inside of the PV rail depending on your tilt

A-30) For 30 degrees tilt, use the 4th hole up from the bottom of the PV rail with a

31in support rail, secure with 5/16 hardware and hand tighten.

A-45) For 45 degrees tilt, use the 1st hole up from the bottom of the PV rail with a

25in support rail, secure with 5/16 hardware and hand tighten.

B. Attach support rail to the bottom clips using 5/16 hardware and hand tighten.

C. Adjust bottom clips evenly so that the center of the PV rail mounting slots are 33.5in

apart at the bottom of the PV rail.

33.5in

*30 Degree Setup Shown

SINGLE PANEL SIDE MOUNT USER MANUAL

INSTALLATION

Sol by Sunna Design | 990 Biscayne Boulevard, Office 701, Miami, FL 33132, USA | 1.800.959.1329 | customerservice@solarlighting.com

Step 5

A. Insert washer and 1/4-20 3/4in bolt into the non rivnut hole in the back of the solar

panel frame.

B. Mount PV panel onto the bottom section of the rail. Secure with remaining

hardware and tighten to 84 in-lbs.

C. Secure loose PV harnessing with ties.

D. Tighten all loose hardware to 144 in-lbs. Double check previously tightened

hardware.

*30 Degree Setup Shown

SINGLE PANEL SIDE MOUNT USER MANUAL

WARRANTY

Sol by Sunna Design | 990 Biscayne Boulevard, Office 701, Miami, FL 33132, USA | 1.800.959.1329 | customerservice@solarlighting.com

Warranty

This product is covered by the Sol warranty. Visit

www.solarlighting.com for additional information or

contact the customer service department.

Before contacting Sol’s customer service department,

please have the serial number of your system available, a

brief description of the problem, as well as all details of the

installation.

To contact Sol’s customer service department:

Mail: Sol by Sunna Design

990 Biscayne Boulevard, Office 701,

Miami, FL 33132, USA

Phone: 1.772.286.9461

1.800.959.1329 (Toll Free in U.S. and Canada)

Email: customerservice@solarlighting.com

Website: solarlighting.com

Otros manuales para Sol EVERGEN M Series

Tabla de contenidos

Otros manuales de Panel solar de Sunna Design

Sunna Design

Sunna Design Sol EVERGEN M Series Manual de usuario

Sunna Design

Sunna Design Sol EVERGEN M Series Manual de usuario

Sunna Design

Sunna Design Sol EVERGEN M Series Manual de usuario

Sunna Design

Sunna Design Sol EVERGEN M Series Manual de usuario

Sunna Design

Sunna Design Sol EVERGEN M Series Manual de usuario

Sunna Design

Sunna Design Sol EVERGEN M Series Manual de instrucciones

Manuales populares de Panel solar de otras marcas

Navitron

Navitron HFC-2 Manual de usuario

AXITEC

AXITEC 60-CELL Manual de usuario

thermital

thermital TSOL 20 N BLU Manual de usuario

AZO Digital

AZO Digital MPPT-3000 Manual de usuario

Clenergy

Clenergy PV-ezRack SolarTripod Manual de usuario

Beretta

Beretta SCF-20N Manual de usuario

moovo

moovo KSM001 Manual del producto

solarwatt

solarwatt EasyIn 60M Series Manual de usuario

Solarland

Solarland Portable Series Manual

Ubiquiti

Ubiquiti sunMAX Manual de usuario

Lippert

Lippert Furrion FSFP37MW-BL Manual de usuario

Sonnenkraft

Sonnenkraft GK5-HP Manual de usuario

REC

REC TwinPeak 2S Mono 72 Series Manual de usuario

Sunforce

Sunforce 50039 Manual de usuario

Flexsolar

Flexsolar C100 Guía

Süd Solar

Süd Solar 03005 Manual de usuario

Kodak

Kodak SP21 Manual de usuario

Carmanah

Carmanah Go Power! Solar Flex GP-FLEX-30 Manual de usuario