Stilum Silva villa Especificaciones técnicas

Maintenance instructions for wendyhouse „silva villa“

Item No. 51 5530 601

State: 16.10.2020 p. 1

Quarterly operative inspection:

1. Check the play and safety area for obvious safety hazards and cleanliness

(e.g. exposed foundations, missing or damaged parts, missing or insu󰀩cient

impact absorption, broken pieces, dirt etc.).

2. Check the play area for cleanliness and damages.

Protruding elements, if there are any, have to be removed. Check the installa-

tion depth. If necessary ll up the installation depth to the mark „play level“.

3. Check the equipment for cleanliness, correct functioning, wear, stability and

damages. Check all the xing elements and retighten them if necessary. In

case of damages, replace the damaged elements.

4. Clean the surfaces of the wooden elements if necessary. Check ssures,

chipping, moss-coveringg, etc. Trimm splittings if necessary.

5. The structural constitution of wood may change in the course of its useful life.

This is why it is advisable to tighten the screws in the wooden elements in

regular intervals.

Attention!

The maintenance intervals mentioned above are to be understood as recommen-

dations. The frequency of inspections has to be increased accordingly in case of

intensive use of the equipment, extreme weather conditions, installations near the

coast or in places which are often subject to vandalism and depending on the age

of the equipment.

In addition to the maintenance recommendations given by the manufacturer, it is

also absolutely necessary to follow the regulations stipulated in DIN EN 1176-7!

When exchanging or repairing elements, please always use original spare parts

for the sake of operational safety and for liability reasons.

If the play equipment has been incompletely installed or partly dismantled when

carrying out maintenance and repair work, this may lead to particular risks of

injury for the user. For this reason, make clearly visible that the equipment shall

not be used in such cases!

Maintenance instructions for wendyhouse „silva villa“

Item No. 51 5530 601

State: 16.10.2020 p. 2

Annual main inspection

(in intervals of not more than 12 months):

1. In addition to the checks of the operative inspection, pay special attention

to the stability of the equipment (which may be a󰀨ected due to corrosion or

vandalism) and its operational safety, especially after repair works or after

mounting new elements or replacing existing elements. For that purpose, it

may be necessary to uncover the foundations.

2. Wooden elements must be checked regarding their stability/sustainability.

A󰀨ected by putrefaction and rotten wood must be renewed.

STAINLESS STEEL

NOTE: Play equipment, which contain components made of stainless steel

should not come with „normal“ steel parts in contact. Those steel parts may rub

o󰀨 and leave small steel particles in combination with moisture brown rust stains.

If such corrosion occur on stainless steel parts, they are ne with an abrasive

(240 grit) to remove.

Please take care when transporting and setting up the fact that the components

are made of stainless steel with no „normal“ steel parts in contact.

MAINTENANCE: In order to preserve a good visual appearance of your stilum

playground equipment over a long period one should take care of maintenance of

the stainless surface even despite of their corrosion resistance.

Especially areas, which can not be reached by rainfall should be frequently clea-

ned from dirt and deposits due to air pollution and dirt caused by the atmosphere.

Light soiling can easily be romoved by using a high pressure cleaner.

For persistent deposits use a clean cloth moistened with a special liquid cleaner

(e.g. on phosphoric acid) and rinse o󰀨 with clear water after a short application

time. During cleaning with mild abrasive components, only wipe over stainless

steel surface in polishing direction.

For heavily soiled surfaces, polishes can be used (e.g. for cleaning chrome on

cars) or for greasy and oily dirt alcoholic cleaning agents and solvents (e.g. ethyl

alcohol, isopropyl alcohol or acetone).

However, it should be noted that the dissolved soiling is not spread over the

surface again.

Do not use any chlorid or hydrochloric containing cleaning products nor scouring

powder, bleaching - or silver polish cleaner. Cleaning intervals depend on type

and degree of soiling as well as on demands made on optical characteristics.

Therefore cleaning is advisable at intervals of six to twelve months – whereby in

the case of strong soiling it is appropriate to clean the playground equipment at

intervals of three to six months.

Maintenance instructions for wendyhouse „silva villa“

Item No. 51 5530 601

State: 16.10.2020 p. 3

WOOD

NOTE: For all play equipment with wooden elements, it cannot be ruled out that

dry cracks may develop. These natural changes of wood are dependent on climate

conditions as well as on the age and usage of the play equipment. Longer dry peri-

ods may lead to more dry cracks.

This development, however, does not represent a quality defect. Static properties of

the equipment are not impaired.

See EN 1176 Bbl 1:2019-01 4.2.7.6: Dry cracks in wood elements as a conse-

quence of weather conditions are not to be considered as dangerous openings in

terms of the standard due to the fact that the shape of the cracks (tapering towards

the inside) makes it almost impossible for ngers to get trapped in them.

MAINTENANCE: To ensure a long life of stilum playground equipment, wooden

surfaces should be regularly re-glazed. This provides the wooden surfaces with the

necessary protection and preserves the look. Areas which are not exposed to rain

should be regularly freed from deposits.

The cleaning intervals depend on the degree and type of soiling as well as on the

exigencies on cleanliness. It is recommended to clean and / or glaze at every 6

to 12 months, or to shorten the cleaning interval to 3 to 6 months if the wheather

conditions are bad.

LASUR: Use a soft and at brush or / and a glaze application roll to paint.

The wood should be cleaned a few hours before glazing. That can be done with

mild javel water, which should in any case be rubbed o󰀨 afterwards. For resistant

dirt use a wood cleaner. Eventually a light abrasion is necessary. If water-based

detergents are used for cleaning, please ensure that the wood elements are tho-

roughly dried before the glazing is done.

Always brush in one direction, so that the glaze can spread evenly. Apply very

thinly!

Remove glaze with a soft cotton cloth.

Then let the freshly glazed wood dry for at least one day and prohibit the use of

the equipment for this duration.

Este manual sirve para los siguientes modelos

Otros manuales de Juegos y equipos de juegos infantiles de stilum

stilum

stilum altus 2 saddle Manual de usuario

stilum

stilum Tamino 1 Guía del usuario

stilum

stilum Gravis 2A Especificaciones técnicas

stilum

stilum flecto Manual de usuario

stilum

stilum altus 1 saddle Manual de usuario

stilum

stilum supra 1 Manual de usuario

stilum

stilum tigna Manual de usuario

stilum

stilum pinna2 Manual de usuario

stilum

stilum alva swing Especificaciones técnicas

stilum

stilum Cora Manual de usuario

stilum

stilum sura 4b Manual de usuario

stilum

stilum pila1 Especificaciones técnicas

stilum

stilum play campana Manual de usuario

stilum

stilum Jump XL Manual de usuario

stilum

stilum angulus 5 Instrucciones de funcionamiento y mantenimiento

stilum

stilum supra 2 Robinia Manual de usuario

stilum

stilum vigo 1 Especificaciones técnicas

stilum

stilum gravis 1C Manual de usuario

stilum

stilum multiplay gravis 4A Manual de usuario

stilum

stilum frondis1 Manual de usuario

stilum

stilum gravis 3 Manual de usuario

stilum

stilum retis 1 Guía del usuario

stilum

stilum Klemens Guía del usuario

stilum

stilum supra 4 Manual de usuario

Manuales populares de Juegos y equipos de juegos infantiles de otras marcas

Ledon

Ledon 302040 Manual de usuario

FUNormous

FUNormous Disney Junior MICKEY MOUSE Manual de usuario

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Manual de usuario

PoolMaster

PoolMaster 72775 Manual de usuario

Palmako

Palmako 4743142009857 Manual del instalador

BOERPLAY

BOERPLAY PSTE000.019 Manual de usuario

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Guía del usuario

Costway

Costway NP10816 Manual de usuario

Trigano

Trigano VABI Manual de usuario

Outward

Outward OUT116 Manual de usuario

GALOPIN

GALOPIN ARC02 Manual de usuario

Ledon

Ledon BASIC Bai LB012 Manual de usuario

BOERPLAY

BOERPLAY PSTE115.002 Manual de usuario

Europlay

Europlay S306 Manual de programación

SportsPlay Equipment

SportsPlay Equipment 361-509H Manual de usuario

Ledon

Ledon 302250 Manual de usuario

Costway

Costway NP10441 Manual de usuario

HAGS

HAGS Lillie Expansion module w Dolly Manual de usuario

stilum Silva villa Especificaciones técnicas

Manuales populares de Juegos y equipos de juegos infantiles de otras marcas