St. Croix Ashby Manual de usuario

Ashby Insert

Ashby

Multi-Fuel Insert

Installation & Operations Manual

Save these Instructions

"Please read this entire manual before installation and use of this pellet fuel-

burning room heater. Failure to follow these instructions could result in

property damage, bodily injury or even death."

"Contact local building or fire officials about restrictions and installation

inspection requirements in

our area.

Ashby Insert

General Information ...................................................................................................... 4

Installation Check List .................................................................................................. 5

Ashby Layout Diagram............................................................................................... 6-7

Ashby Dimensions, Location & Clearances .............................................................. 8-9

Approved Installations..................................................................................................10

Installing as a Zero-Clearance Unit ..............................................................................11

Surround Instructions....................................................................................................12

Exhaust Venting............................................................................................................14

Venting - Approved Materials ....................................................................... 14

Venting-Typical PL Vent Components...........................................................15

Venting - Determining Materials .................................................................. 16

Venting - Termination Requirements.........................................................17-18

Venting: Termination Clearance Requirements ............................................ 19

Venting – Into an existing Chimney...........................................................20-22

Combustion Air ........................................................................................................... 23

Mobile Home Installation ........................................................................................... 24

Thermostat Hook-Up .................................................................................................. 25

Ashby Operation...........................................................................................................26

Installation Check ..........................................................................................26

Preventing Chimney Fires..............................................................................26

Approved Fuels........................................................................................................27-28

Corn, Pellets, Wheat, Rye, Cherry Pits & Distiller’s Grain......................27-28

Control Board Features.................................................................................................31

TABLE OF CONTENTS

Ashby Insert

Pre-Lighting & Lighting instructions.......................................................................33-35

Shutting Off the Insert ..................................................................................................36

Diagnostic & Safety Features ..................................................................................36-37

Combustion Air Damper – Location and Adjustments............................................38-41

Thermostat Control & Pilot Settings.............................................................................41

Ashby Maintenance ....................................................................................................42

St. Croix Clinker Theory................................................................................43

Clinker/Ash Removal (Multi-Fuel pot) .........................................................43

Daily Maintenance (Multi-Fuel Pot)........................................................................44-46

Versa Grate System.......................................................................................................47

Daily Maintenance (Versa Grate System) ...............................................................48-49

Periodic Maintenance...............................................................................................50-53

Yearly Maintenance......................................................................................................53

Safe Operation ..............................................................................................................54

Wiring Schematic..........................................................................................................55

Troubleshooting & Frequently Asked Questions ...............................................56-59

Parts Breakdown (Specific to Versa Grate System )....................................................60

Parts Breakdown (Multi-Fuel Pot & Common parts)..............................................61-62

Warranty .......................................................................................................................63

Ashby Info & Notes......................................................................................................64

Ashby Insert

GENERAL INFORMATION

SAFETY PRECAUTIONS

SAFETY NOTICE: The Ashby must be properly installed in order to prevent the possibility of

a house fire! These installation instructions must be strictly observed! The Maintenance

schedule must be followed as described in this manual. Failure to follow instructions may

result in property damage, bodily injury or even death.

The Ashby’s exhaust system works with negative combustion chamber pressure and a slightly

positive chimney pressure. Therefore, it is imperative that the air intake and exhaust system be

airtight and installed correctly. Do not install a flue damper in the exhaust vent of this unit.

Do not connect this unit to a chimney flue serving another appliance.

BUILDING PERMIT

CONTACT THE LOCAL BUILDING OFFICIALS TO OBTAIN A PERMIT AND

INFORMATION ON ANY LOCAL INSTALLATION RESTRICTIONS AND

INSPECTION REQUIREMENTS.

DEFINITION OF “MULTI-FUEL INSERT”

The word “Multi-Fuel Insert” as used in this manual is interpreted to mean a corn, wheat, rye or

wood pellet burning Multi-Fuel Insert. This model is not intended as the sole source of heat.

SAFETY TESTING

The Ashby has been independently tested and listed by Warnock Hersey Laboratories in

accordance with the proposed ASTM E 1509-2004 Standards and the applicable portions of UL

1482 and ULC S627/B366.2, and Oregon Administrative Rules 814-23-901 through 814-23-

909, stating requirements for installation the Ashby and for mobile home installations. The

safety-listing label is located on the top of the hopper. Please refer to label for pertinent

information.

DISCLAIMER OF WARRANTY

Since Even Temp Company has no control over the installation of the Ashby, Even Temp

Company grants no warranty, implied or stated, for the installation of the Ashby and assumes no

responsibility for any special, incidental or consequential damages.

MANUFACTURED BY:

Even Temp Inc

Hwy 34

Waco, NE, 68467

Save This Installation & O

erations Manual

Ashby Insert

BEFORE INSTALLATION THOROUGHLY

READ AND UNDERSTAND THIS MANUAL

SAFETY NOTICE

PLEASE READ THE ENTIRE MANUAL BEFORE INSTALLING AND USING YOUR NEW MULTI-FUEL INSERT.

FAILURE TO FOLLOW INSTRUCTIONS MAY RESULT IN POPERTY DAMAGE, BODILY INJURY, OR EVEN

DEATH.

INSTALLATION CHECK LIST

FOR USE IN THE U.S. AND CANADA

MOBILE HOME APPROVED

CHECK WITH LOCAL AUTHORITIES AND OBTAIN NEEDED PERMITS

WE RECOMMEND INSTALLATION BY A QUALIFIED PROFESSIONAL.

BEFORE STARTING THE MULTI-FUEL INSERT FOR THE FIRST TIME

1. Under certain conditions outside combustion air is recommended. Use only approved parts. When using

out side air for combustion, check that the outside air inlet is connected to draw fresh air from outside the

building.

2. All joints of PL vent and single wall stainless steel pipe should be fastened by at least 3 screws and

correctly installed. (Follow vent manufacturer’s instructions). Seal all joints with high temperature silicone

to create an airtight seal.

3. WARNING: The high temperature paint on this Multi-Fuel Insert may take several hours of burning at a

high fuel setting to cure fully. During this time, an odor that is not harmful may be evident. When odors are

present, the area around the Multi-Fuel Insert should be well ventilated.

4. Caution: The high temperature paint can be easily scratched prior to burning the Multi-Fuel Insert.

CAUTION

FAILURE TO FOLLOW THE INSTRUCTIONS IN THE INSTALLATIONS MANUAL MAY RESULT

IN A HOUSE FIRE. PLEASE FOLLOW INSTALLATION AND MAINTENANCE INSTRUCTIONS.

TABLE OF CONTENTS

Ashby Insert

Ashby

Stove Layout

Figure 1

There are two burn systems used in the Ashby. These systems are interchangeable in the stove

body. The first is the St. Croix Patent Pending “Clinker Removal System”. This burn pot

allows the clinker to be removed without loosing the fire in the pot. This eliminates the need of

having to constantly re-light the Ashby after removing the clinker. This burn system does not

have Self-Ignition. It is approved for Pellets Corn, Wheat, Rye, Cherry Pits & Distillers Grain

Pellets. See Figure 2 on the next page.

The second burn system uses the “Versa Grate System”. This system does have Self-Ignition.

This system is approved for Pellets & Cherry Pits. See Figure 3 on the next page.

Ashby Insert

Figure 2

Multi-Fuel Burn System

Pellets, Corn, Wheat, Rye, Cherry Pits & Distillers Grain Pellets

Figure 3

Versa Grate System

Pellets & Cherry Pits

Ashby Insert

INSERT DIMENSIONS

Figure 4

Ashby Insert

Clearance to Combustibles

Figure 5

A - Top of Insert to Combustible Mantle.........................................................12”

B - Side of Insert to Combustible Wall ............................................................ 10”

Figure 6

The Hearth must extend a minimum of 6” (152 mm) in Front of Unit and beyond each side

of the Fuel Loading and Ash Removal Opening(s). If the hearth is too short a non-combustible

Hearth Extension must be installed.

Ashby Insert

Approved installations

1. In a Masonry Fireplace – The Masonry Fireplace must be built according to the

requirements of the Standards of Chimneys, Fireplaces, Vents and Solid Fuel

Burning appliances, N.F.P.A. 211 and any National, State or Local codes that apply.

2. In a Zero Clearance Fireplace – The Factory built Zero-Clearance Fireplace and its

Chimney must be listed per UL 127 or ULC S610 standards.

3. As a Zero Clearance Fireplace. When building the unit in as a Zero-Clearance

Fireplace, St. Croix factory Built Cabinet, part # 80P53963, must be used. Follow

instructions on page 10.

Figure 7

Minimum Fireplace Opening

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Chimenea de interior de St. Croix

St. Croix

St. Croix Ashby-MF Insert Manual de usuario

St. Croix

St. Croix PEPIN Manual de usuario

St. Croix

St. Croix Ashby-P Insert Manual de usuario

St. Croix

St. Croix YORK Manual de usuario

St. Croix

St. Croix Lincoln SCR Instrucciones de instalación y funcionamiento

St. Croix

St. Croix Element-P Manual de usuario

St. Croix

St. Croix Ashby-P Insert Manual de usuario

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación