Square Scrub EBG-20 Manual de usuario



EBG‐20SurfacePreparationMachine

OwnersManual



CONTENTS

IntroductiontotheEBG‐20..………………………………………………………………

OperatorInstructions……..…………………………………………………..…………….

MachinespecificationsandSet‐Up…………………………………………………….

OperationInstructions……………………………………………………………………….

TroubleshootingGuide………………………………………………………………………

PartsBreakdown………………………………………………………………………………

WarrantyInformation……………………………………………………………………...



IntroductiontotheEBG20

YouarenowtheproudownerofanEBG20.ThismachineisaproductofSquareScrubInc.Itismade

offinematerialsandwillgiveyoumanyyearsofsatisfactoryserviceifmaintainedandusedaccording

totheguidelinesinthisowner’smanual.

SAFETY

DANGER:Indicatesanimminentlyhazardoussituationwhich,ifnotavoided,mayresultindeathor

seriousinjury.

WARNING:Indicatesapotentiallyhazardoussituation,which,ifnotavoided,mayresultindeathor

seriousinjury.

CAUTION:Indicatesthatmachineorpropertydamagecouldresultifinstructionsarenotfollowed.

NOTE:Provideshelpfulinformation.

OPERATORINSTUCTIONS

DANGERS:

Severebodilyinjuryordeathcanoccurtoyouorotherpersonnelifwarningsfoundonthismachineor

inthisowner’smanualareignored.Readandobserveallstatementandinstructionsfoundonthe

machineandintheowner’smanual.

Neverleavethemachineunattendedwhilepowercordisconnected.

Alwayswearsafetygogglesanddustmaskandwhenoperatingthismachine.

Neverinhaledustcreatedbytheuseofthismachine.

Anymodificationstothismachinemayresultindamagetothemachineorinjurytotheoperatoror

othersnearby.Alterationstothemachinewillalsovoidanyandallwarrantyandliabilities.

Donotoperatethismachinearoundfuels,solvents,flammablefloorfinishes,thinners,wooddustor

anyflammablematerials.Cigarettelighters,pilotlights,electricalsparksandallothersourcesofigni‐

tionshouldbeextinguishedoravoided.Workareasshouldbewellventilated.

Keepthepowercordclearofthepad.Alwaysliftthecordoverthemachine.Donotpullonthepower

cordinanattempttomovethemachine.Thiscouldresultinelectrocution.

Donotusemachineifithasbeensprayedwithwaterorleftoutintherain.Thiscouldresultina

shockinjury.

Keepfeet,hands,andlooseclothingawayfromanymovingpartsonthemachinetoavoidinjury.Dis‐

connectpowercordbeforechangingthepadorwhenservicing.



Caution:

Damagecanoccurtothemachineortootherpropertyifinstructionsintheowner’smanualarenot

followed.

WARNINGS:

Donotoperatethismachinewhileundertheinfluenceofalcoholorotherdrugs.

Neverallowchildrenunderagae18tooperatethismachine.

Unplugmachinefrompowersourcebeforeadjustingheightofhandleorchangingpad.

Neverattempttomovethemachinebypullingthepowercord.



TRANSPORTOFMACHINE

Totransportthismachine,thefollowingprocedureisadvised:

Unplugmachinefrompowersource

Alwaysleaveapadonthemachinetoprotectthegripfacefromdamageintransportandstorage.

Wrapcordusingcordwrapandhandleaspictureillustrates.



Raisehandleandlockinuprightposition.

Tiltmachineontowheelsandtransportslowly.

Whenliftingmachine,itisadvisablefortwouserstoparticipate.Withoneuseroneachsideof

themachine,gripliftingbarsatthebaseofmachinewithonehand.Gripthehandlewiththe

otherhandandlift.

Securemachinewhentransportinginavehicletopreventmovement.



Caution:Thismachineweighs117pounds.Getassistancewhenlifting.Donotattempttoliftalone.



OPERATINGINSTRUCTIONS

1)Movemachinetoworklocation.Nevertransportorstorethemachinewithoutapadtoprotect

thegripface.

2)Checkthepad.Ifithasbecomereducedtoathicknessoflessthan1/2”replacethepad.

3)Toinstallorreplacepad,followtheseinstructions:

Makecertainpowersourceisdisconnected.

Lockhandleinuprightposition

Tiltmachinebackuntilthehandlerestsonthefloor.

Removeexistingpadandreplacewithnewpad.Centerpadwhenplacingongripface.

Presspadfirmlyintogripface.

Returnmachinetouprightposition.

**WhenusingaSPPabrasivepad,placethepadonthefloorandslowlylowermachineontopad,

makingcertaintheSPPpadiscenteredonthemachineandredpad.

4)Connectcordtopowersource.

5)Releaseandlowerhandletoacomfortableposition.Lockhandleintoposition.Thebestoperating

positionisatarmslengthtohelpwithcontrolofmachineandtoimproveoperatorcomfort.Main‐

tainthemachineflatonthefloorforeaseofoperation.Raisingorloweringthehandlecancausethe

machinetopulltotherightorleft.Aneutralhandlepositionwillprovideaneutraloperation.

6)Squeezethepowerbarwithbothhandstostartmachine.Releasepowerbartostopmachine.

Note:Releasingpowerbarwillimmediatelystopthemachine.

TROUBLESHOOTINGGUIDE

ProblemCauseAction

MachinewillnotstartNotconnectedtopowersourceCheckpowersourceconnection 

DefectiveswitchContactSquareScrubdealer





runserratically  LowvoltagefromexcessivelengthUse12gaugeextensioncord

orundersizedextensioncord notmorethan25’long

Defectivestartswitch  ContactSquareScrubdealer

Defectivemotorlowvoltage ContactSquareScrubdealer

Fuse/CircuitBreakertripsLowvoltageAllowthemotortocool.The

circuitbreakerisaredbutton

onthesideofthemotorthat

willresetwhenpressed.

 Eliminateextensioncord.



Locatepowercordclosertoworksite.Havevoltagecheckedbyelectrician.



MachinepullshardtoonesideRubberisolatorswornout Replaceisolators.

NOTE:TherubberisolatorsontheEBG‐20FloorPreparationMachineareconsideredwearitems.Itis

recommendedtoreplacetheentiresetofallfourisolatorsatleastevery100hoursofmachineopera‐

tiontopreventfailureanddamagetothemachine.

Machineisnoticeablylouderthanitwaswhennew  Replaceisolators.



SquareScrub,Inc.

www.squarescrub.com

Tollfree800‐577‐6822



NOTES:

___________________________________________________________________



___________________________________________________________________



___________________________________________________________________



___________________________________________________________________



___________________________________________________________________



___________________________________________________________________



MachineSerialNumber:________________

DatePurchased:_______________________



SquareScrubLimitedWarranty

ThisSquareScrubproductiswarrantedtobefreefromdefectsinmaterialsandworkmanshipunder

normaluseandserviceforaperiodoftwoyearsfromthedateofpurchase,whenoperatedandmain‐

tainedinaccordancewithSquareScrubMaintenanceandOperationsInstructions.Damagedueto

misuseorimpropercarewillnotberepairedunderwarranty.

Thiswarrantyisextendedonlytotheoriginalpurchaserforuseoftheproduct.Itdoesnotcovernor‐

malwearandtearpartssuchaselectricalcable,rubberparts,paddriver,andmotorbrushes.Note:

Therubberisolatorsareconsideredwearableparts.Itisrecommendedthattheentiresetoffouriso‐

latorsbereplacedevery20hoursofmachineoperation.

Ifadifficultydevelopswiththeproduct,contactyourlocalSquareScrubdealerorcallSquareScrubat

800‐557‐6822or870‐932‐0748.OnlySquareScrubcanauthorizerepairsunderwarranty.Transporta‐

tionchargestoandfromtherepairlocationmustbeprepaidbythepurchaser.SquareScrubwillre‐

pairtheproductand/orreplaceanydefectivepartswithoutchargewithinareasonabletimeafterre‐

ceiptoftheproduct.

SquareScrub’sliabilityunderthiswarrantyislimitedtorepairoftheproductand/orreplacementof

partsandisgiventopurchaserislieuofallotherremedies,includingINCIDENTALANDCONSEQUEN‐

TIALDAMAGES.

THEREARENOEXPRESSWARRANTIESOTHERTHANTHOSESPECIFIEDHEREIN.THEREARENOWAR‐

RANTIESWHICHEXTENDBEYONDTHEDESCRIPTIONOFTHEFACEHEREOF.NOWARRANTIES,INCLUD‐

INGBUTNOTLIMITEDTOWARRANTYOFMERCHANTABILITY,SHALLBEIMPLIED.Pleaseregisteryour

machineonourwebsitewithinthirtydaysofpurchasetoassistSquareScrubinprovidingtheper‐

formanceyouexpectfromyournewfloormachine.







800-557-6822

www.squarescrub.com

Otros manuales de Depurador de Square Scrub

Square Scrub

Square Scrub Versality 2 EBG Series Manual de usuario

Square Scrub

Square Scrub EBG Series Manual de usuario

Square Scrub

Square Scrub EBG-28 Manual de usuario

Manuales populares de Depurador de otras marcas

Olympus

Olympus M200H Manual de usuario

Clarke

Clarke BEXT 100H Manual de instalación y funcionamiento

JOHNY VAC

JOHNY VAC JVC70BCT Manual de usuario

RCm

RCm Elan Series Manual

Kärcher

Kärcher B 120 W Manual de usuario

Truvox

Truvox Orbis MotorScrubber 20 Manual de usuario

Numatic

Numatic TTB 4045/100 Manual de usuario

U.S. Products

U.S. Products PEX 500-C-TICK Instrucciones de funcionamiento

Mclennan

Mclennan C510 Manual de usuario

Tennant

Tennant T20 LPG Manual de usuario

Columbus

Columbus ARA 66 BM 100 Manual de usuario

Numatic

Numatic TTV 678G / 300T Manual de usuario

American-Lincoln

American-Lincoln 505-945 Manual de usuario

FIORENTINI

FIORENTINI ET 65-75 Manual de usuario

Floorpul

Floorpul ruby 48 blt Guía del usuario

Onyx

Onyx RX-34 Manual de usuario

Dustbane

Dustbane Hurricane 400 Manual de usuario

Sana

Sana EUJ-702 Manual de usuario