Sphere ST-PS5 Manual de usuario

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

PORTABLE TRAFFIC SIGNALS

Model: ST-PS5

Technical Specifications, Operation Manual and

Warrany Card

Document date: 2020/29/06 © Copyright SPHERE j.d.o.o.

Document produced by SPHERE® (www.sphere.hr).

Table of Contents

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

Table of Contents

Table of Contents.................................................................................................................................... 2

1. Introduction ........................................................................................................................................ 4

1.1. Objectives .................................................................................................. 4

1.2. Scope ......................................................................................................... 4

1.3. Introduction ............................................................................................... 4

2. Design and Features ........................................................................................................................... 5

2.1. Design & Construction .................................................................................. 5

2.2. LED Technology ........................................................................................... 7

2.3. Operator Interface ....................................................................................... 8

2.3.1. PHASE ............................................................................................................................................................................. 9

2.3.2. MODE ........................................................................................................................................................................... 10

2.3.3. TIME ADJUSTMENT – Clearance Time/All-Red ............................................................................................................ 11

2.3.4. TIME ADJUSTMENT – Add Seconds 1-9 ....................................................................................................................... 13

2.3.5. TIME ADJUSTMENT – Green ........................................................................................................................................ 14

2.3.6. TIME ADJUSTMENT – Channel Selection ..................................................................................................................... 15

2.3.7. WARNING ..................................................................................................................................................................... 16

2.3.7.1 Emergency Mode Synchronize Error .................................................................................................................... 16

2.3.7.2 System Fault ......................................................................................................................................................... 16

2.3.7.3 Battery Status ....................................................................................................................................................... 16

2.3.7.4 Reversed Battery Polarity ..................................................................................................................................... 16

2.3.7.5 System Status Indicator ........................................................................................................................................ 17

2.3.7.6 Radio Error or Wrong Channel Selected .............................................................................................................. 17

2.4. Microprocessor Technology ......................................................................... 17

2.5. Low Power Consumption ............................................................................. 17

2.6. Auto-Brightness Technology......................................................................... 17

3. Setup of Portable Traffic Signals ........................................................................................................ 18

3.1. Installing the Signal Head with Pole to the Battery Box .................................... 18

3.2. Connecting the Signal Head Cable with the Battery Box Socket .......................... 18

3.3. Battery Installation .................................................................................... 18

4. Operational Modes ........................................................................................................................... 20

4.1. Radio Operational Mode (The Default Operational Mode) ................................. 20

4.1.1 FIXED TIME .................................................................................................................................................................... 21

4.1.2. MANUAL GREEN .......................................................................................................................................................... 22

4.1.3. MANUAL RED ............................................................................................................................................................... 22

4.1.4. MANUAL ALL-RED ........................................................................................................................................................ 23

4.1.5. FLASHING AMBER ........................................................................................................................................................ 23

4.1.6. LAMPS OFF ................................................................................................................................................................... 24

4.2. Radar Mode .............................................................................................. 25

4.2.1. 2-WAY .......................................................................................................................................................................... 25

4.2.2. DAISY CHAIN ................................................................................................................................................................ 26

4.2.2.1 Setting up the MASTER Unit (Daisy Chain) ........................................................................................................... 27

4.2.2.2 Setting up the SLAVE Units (Daisy Chain) ............................................................................................................. 28

4.2.2.3. Setting Up the Desired Signal Phases for the Daisy Chain Operational Mode .................................................... 29

4.3. Emergency Mode (Non-Radio Mode) .............................................................. 30

Table of Contents

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

5. Troubleshooting ................................................................................................................................ 32

5.1. Radio Communication Failure ...................................................................... 32

5.1.1 Temporary Loss of Radio Communication Between MASTER and SLAVE .................................................................... 32

5.1.2 Permanent Loss of Radio Communication Between MASTER and SLAVE .................................................................... 32

5.1.3 Permanent Loss of Communication Between MASTER and SLAVES in a Daisy Chain Operational Mode .................... 33

5.2. Radar Failure ............................................................................................ 34

5.3. Low Battery Error ...................................................................................... 34

5.4. Lights OFF/2 Lights ON Hazard Condition ....................................................... 34

6. Warranty Card .................................................................................................................................. 35

6.1. Warranty Card ........................................................................................... 35

7. Terms and Conditions........................................................................................................................ 36

7.1. Application ............................................................................................... 36

7.2. Copyright ................................................................................................. 36

7.3. Trademarks ............................................................................................... 36

7.4. Safety ...................................................................................................... 36

7.5. Limited Warranty ....................................................................................... 36

7.6. Liability Limit and Indemnity ....................................................................... 36

1. Introduction

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

1. Introduction

1.1. Objectives

The objective of this document is to give technical information about PORTABLE TRAFFIC SIGNALS ST-PS5 and describe steps

to setup and operate the device.

1.2. Scope

This document will describe the design, features, dimensions, technical specifications, setup and operational modes of the ST-

PS5 Portable Traffic Signals. Further information can be acquired on the web site or directly with manufacturers.

1.3. Introduction

The Sphere ST-PS5 Portable Traffic Signals is a modular mobile traffic signal system intended to be applied primarily to shuttle

the control of vehicular traffic at road works or bridge works.

Road works where Portable Traffic Signals are applied have a a section of the carriage-way closed, so the single lane must be

used alternatively by traffic from the opposite directions.

Other than vehicle-actuated alternating one-way traffic, the ST-PS5 can also be used for controlling the T-junction situations,

crossroads traffic and roundabouts, with up to 7 signals operating simultaneuosly in a Daisy Chain operational mode.

The ST-PS5 Portable Traffic Signals are equipped with a directional radar for vehicle-actuated operation, radio communication

with a range of up to 1000 m under ideal conditions and emergency mode for quartz control when the radio communication

is faulty.

2. Design and Features

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

2. Design and Features

2.1. Design & Construction

When dismounted, Portable Traffic Signals ST-PS5 consists of two separate parts:

1. Signal head made from powder-coating steel consisting of 3 integrated LED signal aspects, 1 vehicle detector, 1 RF

antenna and a built-in steel pole (PICTURE 1)

2. Battery box which consists of built-in watertight electronics and a watertight Operator Interface consisting of

operational interface, space for rechargeable battery, two battery clamps to connect the rechargeable battery to the

system, rear transport handle and two never-flat rubber wheels (PICTURE 1).

PICTURE 1: ST-PS5 Signal Head, Buil t-In S teel Pole and Battery C ase

2. Design and Features

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

SPECIFICATION

Model ST-PS5

O p e r a t i o n a l V o l t a g e 12 V D C r e ch ar ge a b l e b a t t er y

L E D P o w e r C o n s u m p t i o n I m a x 0 .7 1 A d a y ti m e mo d e . I m a x 0. 0 8 A ni g ht - t i me m od e

R u n t i m e o n a S i n g l e

C h a r g e ( D a y s ) Up t o 25 d ay s ( 0- 2 4 h 1 8 0 A h )

L E D T y p e W i d e v ie w i n g a n g l e S M D L ED s

L i g h t S o u r c e s 10 5 L EDs p e r g r e e n a nd re d s e gm e nt . 1 9 0 L ED s o n a mb er s e g me n t

S i g n a l A s p e c t D i a m e t e r 21 0 m m

L u m i n o s i t y 84 0 C d p e r s e gm e n t

B r i g h t n e s s Gr a d u a l L ED b ri gh t n e s s ad jus t m e n t

H o u s i n g P o w d e r c oati ng s t e e l

F e a t u r i n g D e tac h ab le s i gn a l h e a d /o os t , m o d u la r co m p o n e nts

T r a n s p o r t H e i g h t 22 0 0 m m

T r a n s p o r t W i d t h 68 5 m m

T r a n s p o r t W e i g h t 61 kg

S y s t e m F o o l p r o o f s y s te m, b at t e r y s t a tu s , st at u s mo ni t o ri n g , s y ste m m o ni to r i ng ,

o v e r - d is c ha rge p r o te c t i o n , e a s y us e lo ck in g sy s t e m, re v e rse d b a t t e ry

p o l ar i ty pr ote c t i o n

D e f a u l t

O p e r a t i o n a l

F r e q u e n c y 43 3 M H z ( A d jus ta b l e )

R F C h a n n e l s 16 C h a n n e ls

R F R a n g e Up t o 1 0 00 m u n d e r id e a l c o n d itio ns

R a d i o O p e r a t i o n a l M o d e s

wa y r a d a r m o de , d a i s y c hai n r a d a r m od e, f

i x ed t i me ,

m a n ua l

al l

r e d ,

m a nu al r ed , m an u a l gr e en, f l a s hi n g a m b e r , l am ps o ff

N o n

R a d i o

O p e r a t i o n a l

M o d e s Em e r ge n c y m o d e

R a n g e o f A p p l i c a t i o n s

Si n g l e la n e ,

ju nc ti on , c r os s ro ad , ro u n d a bo u t s. U p t o 7 u n i ts s u pp o r t e d i n

d a i s y c ha i n o pe r a t i on al m od e .

E U D e c l a r a t i o n o f

C o n f o r m i t y

ET S I E N 30 1 48 9

1 v 2 . 2. 0 ( 2 017) , ET S I E N 30 1 4 89

3 v 2.1 . 1 ( 2 0 1 7 ) , EN

50 2 9 3 : 2 0 1 2

A d d i t i o n a l U p g r a d e s Co u n td o wn t i m e r , a d ju s t a b l e p o le

TABLE 1. ST-PS Technical Specification

DIMENSIONS & WEIGHT

Model ST-PS5

T o t a l H e i g h t 210 cm

B a t t e r y B o x W i d t h 76 c m

B a t t e r y B o x L e n g t h 68 c m

B a t t e r y B o x H e i g h t 41 . 5 c m

B a s i c W e i g h t 61 kg

T r a n s p o r t W e i g h t s 61 kg

TABLE 2. ST-PS Dimensions & Weight

2. Design and Features

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

2.2. LED Technology

Portable Traffic Signals ST-PS5 signal aspects are made in high quality integrated LED (

light-emitting diode

) technology which

has up to five times lower power consumption than the standard halogen bulbs, as well as significantly longer lifespan.

PICTURE 2: Portable Traffic Si gnals ST -PS5 – LED Signal Aspects

2. Design and Features

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

2.3. Operator Interface

The operator interface of ST-PS5 was designed and developed in a large way by listening to recomendations and advices of the

road construction workers, who demanded simple, intuitive, precise and fast entering of the desired operational settings.

PICTURE 3: Ope rator Interface – MASTER

PICTURE 4: Operator Inte rface – S LAVE

The operator interface of ST-PS5 is divided into 4 FUNCTIONAL SECTIONS for easier navigation:

1. PHASE section (RED, AMBER or GREEN phase indicators)

2. MODE section for choosing the desired operational mode

3. TIME ADJUSTMENT section for choosing the duration of ALL-RED/CLEARANCE TIME (secs) and the duration of GREEN

(secs)

4. WARNING section

2. Design and Features

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

The Operator Interface of ST-PS5 consists of three multifunctional rotary knobs:

1. On the TIME ADJUSTMENT section, the CLEARANCE TIME/ALL-RED knob is used to set the duration of CLEARANCE

TIME/ALL-RED phase in seconds

2. On the TIME ADJUSTMENT section, the GREEN knob is used to set the duration of GREEN phase in seconds

3. On the MODE section, the MODE knob is used to set the desired operational mode

2.3.1. PHASE

On both Master and Slave controllers, the PHASE section provides indication of which aspect is on.

The PHASE section mimics the following signal head aspects:

1. RED

2. AMBER

3. GREEN

On both Master and Slave, coloured ultra bright LEDs (which represent the signal head) provide indication of which aspect is

ON.

Phase se ction on t he Operator interface – RED signal aspect i s ON

2. Design and Features

SPHERE Portable Traffic Signals

Model: ST-PS5 / Technical Specifications, Instruction Manual and Warranty Card

2.3.2. MODE

There must be only one Master controller in the system.

To select the operational mode, move the MODE knob to the corresponding mode position (e.g. to use the portable traffic

signals in a 2-WAY RADAR mode, move the MODE knob on both MASTER and SLAVE units to the position 2-WAY RADAR

MODE)

MASTER SLAVE

Selecting the 2-Way Radar Mode on MASTER and SL AVE units

You can choose between one of the following operational modes:

PICTURE 7. Operational Modes for Master Unit and Slave Unit(s)

The upper diagram shows all available operational modes and how to pair them (e.g. to use the MANUAL GREEN operational

mode, move the MODE knob on the MASTER unit to the position MANUAL GREEN and move the MODE knob on the SLAVE unit

to the position FIXED TIME).

The SLAVE TOTAL/SLAVE ID positions are for DAISY CHAIN programming, while STANDBY position is for EMERGENCY MODE

only.

For a detailed instruction for each operational MODE, skip to the paragraph 4. Operational Modes.

Tabla de contenidos

Manuales populares de Equipo de iluminación de otras marcas

Brizo

Brizo 8SP-MU-4 Manual de usuario

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 Manual de usuario

IKEA

IKEA BJÖRKSPIREA Manual de usuario

Laserworld

Laserworld Evolution Series ES-400RGB Manual de usuario

Alien

Alien RG STAR Manual de usuario

EuroLite

EuroLite LED B-40 Manual de usuario

Qazqa

Qazqa Suplux SL 3 Black 103062 Manual de usuario

Commercial Electric

Commercial Electric 54568141 Manual de usuario

CREE LIGHTING

CREE LIGHTING 304 Series Manual de usuario

Goobay

Goobay 49867 Manual de usuario

ECOMAN ITALIA

ECOMAN ITALIA LED T8 Manual de usuario

Alkalite

Alkalite Krypton KT-81 Manual de usuario

Clas Ohlson

Clas Ohlson GU10 Manual de usuario

DTS

DTS DELTA 10 F Manual de usuario

ring

ring Solar Steplight Manual de usuario

One Stop Gardens

One Stop Gardens 57696 Instrucciones de montaje

Chauvet DJ

Chauvet DJ COREpar UV120 ILS Manual de usuario

SIREM

SIREM Swimeo A2 Manual de usuario