Speed Queen SLW570RAW Manual

Speed Queen RDomestic WasherTechnical Information

August 2000 RT3100015 Rev. 01

120 V, 60 Hz Models

SLW570RAW PSLW570RAW

•Due to possibility of personal injury or property damage, always contact an authorized technician for servicing or

repair of this unit.

•Refer to Service Manual RS3100007 for detailed installation, operating, testing, troubleshooting, and disassembly

instructions.

•Refer to Parts Manual RP3100017 for part number information.

CAUTION

All safety information must be followed as provided in this Technical Sheet and in Service Manual RS3100007.

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to unit and discharge capacitor

before servicing, unless testing requires it.

Models SLW570RAW Models SLW570RAW

Power Source Wash cyles 12

Voltage AC 120 VAC Water temperatures 4

Amperage (Single Unit) 10 A Water level Variable

Frequency 60 Hz Features

Motor horsepower 1/2 Steady SpinBalance System X

Receptacle 6-20R Self-cleaning lint filter X

Plug 6-20P Self-adjusting rear leveling legs X

Dimensions 210 Agitation stroke X

Cabinet Tri−Actionwash system X

Height−overall 43” Fabric softener dispenser X

Height of cabinet 36” Extra rinse X

Width 27” Motor speed 2 speed

Depth 28” Spin speed (revolutions per minute) 640 / 427 rpm

Clearance−washer lid 17 1/2” Agitation speed (strokes per minute)

Weight High 69 spm

Crated 193 lbs. Medium 46 spm

Component Testing Information

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20002

Illustration Component Test Procedure Results

40046601

L1 L2

Temperature switch Disconnect wires from component to

properly measure the resistance of the

component.

Place switch in the following positions

and measure across the terminals

below:

Hot / Cold L1-2

Warm / Warm L1-1, L1-2, L2-2

L2-1, L2-L1, 1-2

Warm / Cold L1-1, L1-2, 1-2

Cold / Cold L1-1

>1 Ω

40097701 Mixing valve Measure resistance of terminals on

each valve.

Resistance across each valve. Approximately 1000 Ω±10%

40073901 Timer Verify input and output voltage is

present.

Verify wiring is correctly connected to

the timer.

See timing sequence chart for functional

description of the component.

40055101

Pressure switch Do not disconnect the pressure hose

from pressure switch to perform

measurements.

Measure resistance across the

following terminals on the pressure

switch:

Terminal 1 to 2

Terminal 1 to 3

Refer to wiring diagram/schematic for

correct contacts.

Air pressure that actuates switch is

determined by the water level of the

tub.

Continuity (no pressure)

Continuity (pressure)

40035001 Lid switch−SPST Disconnect wire terminals from switch.

Test terminals with switch closed.

Test terminals with switch open. Continuity >1 Ω

Infinite 1 MΩ

Component Testing Information

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

August 2000 3 RT3100015 Rev. 0

Illustration Component Test Procedure Results

038424W Rocker switch

(Extra Rinse) Measure resistance of switch

positions:

Closed (ON position)

Open (OFF position)

Continuity >1 Ω

Infinite 1 MΩ

R0000014 Brake pad kit If washtub does not stop spinning

within seven seconds after opening

loading door.

If brake pads make noises.

Replace all three brake pads.

Apply a thin layer of silicone (26594P) on

pads, see Service Bulletin

“ASQ−213−B”

40095001 Motor Type of motor:

Two speed See following section “Internal Motor

Diagram and Schematic” for correct

wiring contacts.

40040301 Drain pump Verify drain pump is not clogged or

damaged. Remove clog and verify proper operation.

Replace drain pump if damaged.

40065301 Transmission

assembly Type of transmission:

640 rpm Externally identical, must be identified by

part number.

If transmission locks-up, replace.

40053602 Drive belt Type of drive belt:

640 rpm

Refer to “Parts Manual” for proper

pulley size.

Refer to “Parts Manual”, to verify which

drive belt and pulley size is required.

Internal Motor Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20004

Continuity exists between switch

terminal Rand Red wire.

Manually depress actuator.

Continuity broken between

switch terminal Rand Red wire.

Continuity exists between switch

terminal Pand Red wire.

Manually depress actuator.

Continuity broken between

switch terminal Pand Red wire.

Inoperative start switch.

Replace switch.

Inoperative high speed

switch. Replace switch.

Continuity broken between

switch terminal Pand Violet wire.

Manually depress actuator.

Continuity exists between switch

terminal Pand Violet wire.

Inoperative low speed

switch. Replace switch.

Motor switch checks OK.

YES

Start

Terminals

High Speed

Terminals

Low Speed

Terminals

One or Two Speed Motors

4-5 ohms between Brown wire

and Red wire.

1-2 ohms between Blue wire and

Yellow wire.

1-2 ohms between Yellow wire

and Violet wire.

Continuity exists between Yellow

wire and White wire.

All motor windings checks OK.

Inoperative start winding.

Replace motor.

Inoperative high speed winding.

Replace motor.

Inoperative low speed winding.

Replace motor.

Inoperative common lead.

Replace motor.

Start

Winding

High Speed

Winding

Low Speed

Winding

Protector

YES

Internal Motor Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

August 2000 5 RT3100015 Rev. 0

Wire harness

connection

block

WhiteBrown

Blue Yellow

Violet

Red

RUN

START

Red

Blue

Yellow

Brown

White

4P M

6P M

Aux.

Overload

protector

Yellow

Violet

Motor Assembly

(two speed motor)

Wiring Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20006

24 L2

PNK/BLU

4N.O.

PNK/BLU

WHT/BLK

GRY/BLK

BLU/WHT

WHT/RED

BRN

VLT

10 BLUK

A14

16 PNK

EXTRA RINSE

SWITCH

BLK/PNK

GRY

HOUSING

CONNECTION

DIAGRAM

RED/BLK

BLU/BLK

24 PIN

TIMER

H20

21 RED L1 1

4 POSITION

TEMP. SWITCH

ORG

CONTROL HOOD

GROUND TO

PNK/BLU

VLT

COM.

SWITCH

LID

SWITCH

PRESSURE

BLU 7

BLU

WHT

BRN 5

VLT

BRN

WHT

PNK 7PNK

WHT/RED

GRN/YEL

3MOTOR

HOUSING

GROUND TO

GRN/YEL

CABINET

WHT/RED

GRN/YEL

WHT/RED

GRN/YEL

GROUND

TO TOP GRY

ORG

PLUG

RECEPTACLE

GRY

ORG

MIXING VALVE

NATURAL

RED

HOT COLD

GRN

CONNECTOR

GROUND TO

18 GA.

BLK WHT

TOP

RIDGE OR TINNED TERMINAL = NEUTRAL

CORD

POWER

TM WHT/BLK

PNK

Wiring Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

August 2000 7 RT3100015 Rev. 0

BP EXTRA RINSE SWITCH

SPIN

HIGH

AGITATE

START 4

HOT

COLD

SPRAY RINSES = COLD

WARM

4 POSITION WATER

TEMP. SWITCH

COLD

HOT L1-2

L1-1

L1-1-2

WARM

WARM L1-L2-1-2

MOTOR

TIMER

SCHEMATIC

TIMER BUSS

INDICATES INTERNAL

3LOW MOTOR

N.O.

SWITCH

LID

120 VOLTS A.C. 60 HZ

PRESSURE SWITCH

MIXING VALVE

L1 L2

WATER TEMP.

4 POSITION

SWITCH

Timer Cycle Chart

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20008

BLU/

WHT

WHT/

BLU/

RED

BLK

TMHI

AEX

1012 11

24 23

RED 22

PINK

BLK/

21 RED/

BLK

GRY

18 17

BRN

PNK

VLT

15 14

BLU

89 WHT/

BLK

231

SWITCH

FUNCTION

EXTRA

RINSE

PARTNO. 40101801

TIMERCHART

WIRE POSITION

24 PIN HOUSING

DTERM

IDENT

BLU

PNK/

REGULAR WASH

SOAK PRE-

WASH DELICATE

PERMANENT

PRESS EXTRA

RINSE EXTRA

RINSE HAND

WASH

AGITATE

PRESSURE SW, BYP

EX. RINSE ENABLE

FILL

AGITATE

WASH

COLD WATER

LO MOTOR

RINSE

TM-LO

V-W

P-V

V-R

F-L

F-K

G-L

G-K

SPIN

A-EX

A-BP

A-PS

TM-HI

HI-MOTOR

DEGREES

190

170

180

160

140

150

130

110

120

100

300

310

290

270

260

250

240

220

230

280

210

200

350

360

330

340

320

LO MOTOR

HOT WATER P-H

TM-LO

SOAK

WASH:

FILL &

AGITATE

F A

I G

L I

L T

& T

D G

R I

Y T

WASH:

FILL &

AGITATE

PNK WHT/

BLK

LOTM

PNK/

BLU

BLK

GRY/

13121189761054312 30

3027 282625 292422 232120191815 16 1714 4745 4644434241403938373634 35333231 52 53 5451504948

CONTACTS CLOSED

CONTACTS OPEN

THIS MACHINE MANUFACTURED

UNDER ONE OR MORE OF THE

FOLLOWING PATENTS:

UNITED STATES NO: 3,253,874;

3,838,755; 3,8453642

CANADIAN NO: 1,008,265;

994,685

OTHER PATENTS PENDING

Failure to install, maintain, and/or

operate this machine according to

manufacture's instructions may

result in conditions which can

produce bodily injury and/or

property damage.

Tabla de contenidos

Otros manuales de Arandela de Speed Queen

Speed Queen

Speed Queen SCN030GF Instrucciones de instalación

Speed Queen

Speed Queen wx40120 Guía de inicio rápido

Speed Queen

Speed Queen SWNBY2PP112TW01 Manual de usuario

Speed Queen

Speed Queen 25 lb Manual de usuario

Speed Queen

Speed Queen WX50120 Guía de inicio rápido

Speed Queen

Speed Queen LTSA0AWN Manual de usuario

Speed Queen

Speed Queen NetMaster Manual del propietario

Speed Queen

Speed Queen HA 5591 Manual de usuario

Speed Queen

Speed Queen AWNA62SN305AW01 Manual de usuario

Speed Queen

Speed Queen AWN311 Manual de usuario

Speed Queen

Speed Queen FA6300 Manual de usuario

Speed Queen

Speed Queen HA3000 Manual de usuario

Speed Queen

Speed Queen AWM472W2 Manual de usuario

Speed Queen

Speed Queen LWNA11SP111TW01 Manual de usuario

Speed Queen

Speed Queen LWS16 Manual de usuario

Speed Queen

Speed Queen SA4710 Guía de inicio rápido

Speed Queen

Speed Queen frontload washer Manual de usuario

Speed Queen

Speed Queen TR7003WN Manual de usuario

Speed Queen

Speed Queen SCN100GF Instrucciones de instalación

Speed Queen

Speed Queen 202147R2 Manual de usuario

Speed Queen

Speed Queen LWS05 Manual de usuario

Speed Queen

Speed Queen On-Premises SC20 Manual de usuario

Speed Queen

Speed Queen SWTY20WN Manual de usuario

Speed Queen

Speed Queen 802757R4 Manual de usuario

Manuales populares de Arandela de otras marcas

Tricity Bendix

Tricity Bendix AW 1000 W Guía del producto

Panasonic

Panasonic NA-F60L5WRB Manual de usuario

GE WSLP1500 Manual

Electrolux

Electrolux EWF1284EDW Manual de usuario

Bosch

Bosch WAN2829BSN Manual de usuario

LG TV2516DV3B Manual de usuario

LG TH2517DSAV Manual de usuario

VESTEL

VESTEL CMH-XL 7510 TE Manual de usuario

AEG

AEG 74335 Manual de operación

Johnson

Johnson JWF721A Manual de usuario

Beko

Beko WTE7604XLW0 Manual de usuario

Danby

Danby DTT100A1WDB Instrucciones de montaje

Amica

Amica WA 14 Ex Manual de usuario

Daewoo

Daewoo DWD-F1222 Manual de usuario

Bosch

Bosch WAS28461AU Manual de usuario

Miele

Miele PW 6080 Vario Manual de usuario

Finlux

Finlux FLX108CF220 Manual de usuario

Whirlpool

Whirlpool 3LBR5132AN0 Manual de usuario