Spear & Jackson DRUMBBQ Manual de usuario
ASSEMBLY AND USER INSTRUCTIONS
STEEL DURM BBQ
Model DRUMBBQ
Images are only an indication of the general appearance and design. Specific aspects may change from time to
time. Steel Drum BBQs are manufactured with outdoor use in mind , so tolerances are quite large. Expect some
gaps between components.
WARNING - Observe these
instructions to avoid personal
injury and damage to property
NEVER leave a burning fire
unattended
HOT Burn risk
This product carries a 12 months
from the date of the original pur-
chase. If any defect arises due to
faulty materials or workmanship,
It is not a guarantee against rust-
ing. BBQ and charcoal grills are
not included in the guarantee.
ASSEMBLY
Keep plastic bags out of the reach of children and dispose of safely.
Please read the safety recommendations before use.
Keep these instructions in safe place for future reference.
Before starting read these instructions carefully. We suggest you carry out assembly on a soft surface so as to avoid scratching
the paint.
DO NOT FULLY TIGHTEN THE BOLTS BEFORE ASSEMBLING ALL THE PARTS
Assembly is easier with two people, one to hold the parts and a second person to insert the fixings.
Tools required: screwdriver and socket wrench - spanner and forked poker supplied
Please separate the bolts and nuts by size before starting the assembly.
1. Assemble the two Right Leg Pieces (11) to the two horizontal Lower Joining Bars (16) with two M6 X 35 Screws (C) and Nut
(E),then assemble the two Left Leg Pieces (17) to the horizontal Lower Joining Bars (16) with two M6 X 35 Screws (C) and
Nut (E).
(Note: Make sure the legs with the hole at the end for fixing the Wheel Axle both at the right side not separate).
2. Assemble the two Leg Joiner (12) cross front and back in-between the two assembled leg stands with four M6 X 35 Screws
(C) and Nut (E).
3. Attached the two Wheels (13) to the right end of the legs by inserting the Wheel Axle (14) through the hole on legs and
attached the two Wheels (13) on the two Ends of the Wheel Axle (14) and fix with two Nuts (F).
4. Assemble the two Upper Joining Bars (15) with the legs and Bottom Bowl (8) together by inserting the leg top ends into
the Upper Joining Bars (15) first and then insert four M6 X 35 Screws (C) through the Upper Joining Bars (15) and legs to
the Bottom Bowl (8) and fix with four Washers (D) and Nuts (E) from inside of the Bottom Bowl (8).
(Note: Make sure when assemble the Bottom bowl ,the bottom bowl be assembled with the two holes at the side for fixing
the Side handle is opposite to the wheels).
5. Assemble the two Brackets (10) on outside of the Bottom bowl (8) with four M6 X 10 Screws (A) and Nut (E).
6. Attach the Bottom Bowl Side Handle (9) to the left side of the Bottom Bowl (8) by inserting the two M6 x 20 Screws (B) from
inside of the Bottom Bowl (8) with two Washers (D) next to the handle then into the screw thread hole on Bottom Bowl Side
Handle (9).
7. Attach the Lid Handle (1) to the Lid (Drum Top) (2) by inserting the two M6 x 20 Screws (B) from inside of the Bottom Bowl
(8) in the middle with two Washers (D) next to the handle then into the screw thread hole on Lid Handle (1).
8. Attach the two Air Valves (3) outside to the two sides of the Lid (Drum Top) (2) with two M4 x 30 Screws (G) from outside of
the Lid (Drum Top) (2) and fix with four Nuts (H) which is two for each Air Valves (3).
(Note: The extra Nut is fixing at the end of the Screw that leave a space for hanging the Warming Rack (5) on the screw
in-between the two Nuts , so the extra nut is for stopping the Warming Rack (5) falling off ).
9. Attach the two Connection Plates (4) inside at the corner on two sides of the Lid (Drum Top) (2) with six M6 X 10 Screws (A)
and Nut (E). Then assemble the Lid (Drum Top) (2) to the Bottom Bowl (8) by fixing the other end of the Connection Plates
(4) to the outside of Bottom Bowl (8) with inserting two M6 X 10 Screws (A ) through the Connection Plates (4) and fix with
Nut (E) from inside of Bottom Bowl (8).
10. Insert the Charcoal Grill (7) into the Bottom Bowl (8), then put the BBQ Grill (6) onto the stage of Bottom Bowl (8).
Attach the Warming Rack (5) to the Screw and in-between the two nuts that for fixing the Air Valves (3) which inside the Lid
(Drum Top) (2) .
Now check and tighten all fixings, assembly is complete.
DO NOT OVER TIGHTEN THE FIXINGS
USER INSTRUCTIONS OUTDOORS
Please read the following instructions and recommendations and use CAUTION at all times for the safe enjoyment of a real pa-
tio fire. Please keep these instructions in a safe place so you can read them again from time to time.
• ALWAYS FOLLOW THE USER INSTRUCTIONS. Failure to do so may result in personal accidents or fires spreading to
property. Please remember, you are dealing with a real fire.
• PLACE your real patio fire on a FLAT surface; you should NOT place on a sloping surface where the fire might tip over.
• This should be a NON-FLAMMABLE surface such as stone, gravel or bricks. Do not place on grass which may turn brown.
Do not place on wood which may turn brown or catch fire. DO NOT PLACE ON DECKING which may turn brown or catch
fire.
Protect wooden decking with a FLOOR PROTECTION or use bricks or concrete slabs.
• DO NOT place your fire near bushes or plants or under trees; the heat will damage the leaves and is a fire risk.
• DO NOT place your real fire under an awning; it will burn or melt.
• DO NOT place your real fire near garden furniture, especially made of fabric or woven plastic, which may melt or catch
fire. We recommend at least one metre distance.
• DO NOT make a real fire inside a conservatory or summer house or shed; real fires are designed to be outside, and fumes
emanating from the fire made with wood, coal or charcoal are toxic and dangerous to health. You can use your patio fire
indoors ONLY WHEN USING WITH THE CHIM BURNER AND BIO-ETHANOL FUEL.
• DO NOT touch the real fire when burning; the surface is hot and you will burn your fingers; protect your hands with a
FIRE GLOVE. We recommend that gloves are used at all times.
• DO NOT allow children, especially small children, near the fire. Do not allow pets near the fire.
• DO NOT allow children to play or run around the fire. It is not a game. Use a CHIMENEA GUARD to prevent small children
coming close to the fire.
• DO NOT over fuel the fire. If flames are coming out of the top of the DRUMBBQ, then the fire is too large.
• DO NOT PANIC if fuel falls out of the fire or for any reason flames spread out from the patio fire, simply extinguish
spreading flames with earth or sand or with water immediately.
DO NOT throw water on a real fire other than in an emergency.
• DO NOT use petrol, paraffin or similar substances as fire lighters or as a fuel. The best method is balled newspaper and
kindling, such as OCOTE sticks. The best fuel is wood or charcoal.
• NEVER LEAVE A BURNING REAL PATIO FIRE UNATTENDED. Failure to do so may result in the fire spreading out of control
and result in damage or destruction of property. Please ensure the fire is
completely out before leaving the real patio fire unattended.
• DO NOT attempt to move a real patio fire while the fire is burning.
• We advise against using a real patio fire when it is windy or in the case of droughts. Strong wind may tip the DRUMBBQ
over which is a fire risk. Wind may also disperse burning material, which is a fire risk, particularly if the environment is dry
as in the case of a drought.
• Please be a good neighbour and be reasonable in the use of your patio fire, keep smoke and noise to a minimum.
MAINTENANCE INSTRUCTIONS FOR YOUR DRUM BBQ
• Although your Drum BBQ or patio fire is coated with heat-resistant paint, the PAINT WILL BURN OFF - this may happen after
one use only. The bigger the fire, the faster the paint will burn off.
• A Drum BBQ or patio fire can be re-painted with high temperature resistant paint available from local DIY store.
• Cast iron and steel corrode quickly in wet conditions and WILL RUST. Rusting is a natural phenomenon that cannot be
prevented. It is not a product defect therefore we offer no guarantees against rusting.
Corrosion may occur after one use only.
• A rusty Drum BBQ is still fit for purpose and can continue to be used. No refunds or replacements will be given for rusty
Drum BBQs.
• Rust runs may mark flooring, slabs, and patios, so if you are worried abut marking, protect your flooring.
• To reduce the likelihood of rusting, wipe the whole surface of the product with oil after each use. Use a rag or brush to
that effect.
• Bring inside or protect with a weatherproof Drum BBQ cover. If the cover traps dampness underneath it, the Drum BBQ may
still go rusty. Ideally, bring inside for the winter. Careful, never
put a cover on a Drum BBQ while still warm: it will melt.
• To maintain the finish, clean the surface with a soft cloth. Do not use a wire brush. Slight wear and tear scratches may
appear with normal use.
SPECIFIC INSTRUCTIONS FOR YOUR DRUM BBQ
• Use your Drum BBQ or real patio fire for warmth and cooking, Drum BBQs are beautiful to look at and can be used as garden decorations.
• You may use dry wood logs, charcoal, coal or briquettes for fuel. Drum BBQs and other patio fires can be used to burn garden refuse such
as leaves or branches. DO NOT throw fuel into a Drum BBQ. Wet logs will create a lot of smoke.
• The environmental friendly fuel is wood or charcoal which is carbon neutral.
• When cooking use locally made charcoal from renewable forests with minimal transport cost. Wyre
Forest Charcoal is made in the Wyre Forest in the UK West Midlands following to ancient rural methods.
• CHIM LOGS, which are made from environmentally friendly recycled sawdust and burn slowly with little smoke.
• To start a fire use domestic fire lighters or balled newspaper and kindling.
• The best and most natural way to start the fire is Ocote fire lighters. Ocote is a high resin content pinewood from Central
America, one or two sticks are enough to light a fire.
• For a fire without firelighters or kindling, use the smokeless FIRE LOG, a wax impregnated sawdust briquette, wrapped in
a paper. Just light both ends of the paper and the log will burn for about 2½ hours. You cannot use Fire Logs for cooking.
• Protect hands with FIRE GLOVES when adding fuel. The more fuel is added, the more intense the heat, the larger the flames. Do not
over-fuel the fire.
• Use a Gardeco POKER to reposition logs inside the patio fire.
• If the fire is slow to start, more air will help, use a BELLOWS to blow air into a slow fire.
• No one wants smoke to spoil their party, a EXTENSION CHIMNEY raises smoke above the heads of standing people and increases the
draw enabling the fire to burn more efficiently.
• Safety is our main concern, so please use a CHIMENEA GUARD to keep small fingers well away from the fire.
• Drum BBQs are very heavy. At least two people must carry one Drum BBQ. Failure to do so may result in back injury or accidents.
When moving the Drum BBQ, make sure each person is holding it by the side handle and the leg- do not hold it in just one place.
COOKING ON A DRUMBBQ OR FIRE BOWL OR BBQ
Special care and attention is necessary when cooking on a DRUMBBQ or fire bowl to avoid contamination by smoke or soot. All
cooking accessories MUST BE THOROUGHLY CLEANED BEFORE USE.
• BBQ grills and accessories are coated with vegetable oil during manufacture but may have gathered dirt
and dust therefore must be thoroughly washed in hot water and detergent, check all dirt is removed.
• After cleaning and drying, cooking accessories are best lightly coated with vegetable cooking oil before use. After use, they
must washed clean with hot water and detergent and coated with vegetable cooking oil before storing. NEVER USE
MINERAL OIL.
• If you do not oil cooking accessories they will rust, this could happen after first use. If you wash cooking accessories with
water and don’t coat with cooking oil rust can occur in a matter of hours.
• After use the surfaces of the cooking accessories in direct contact with the fire will be covered in black carbon soot.
Soot can be washed off with hot water and household detergent or washing up liquid. Be careful because black soot
residues will mark surfaces, tea towels or washing up cloths. All soot must be removed before oiling and storage.
FUEL
Do not cook on flames, if you do this there will be a soot residue on the food, which is unhealthy. Be aware wood is often treat-
ed with preservatives which are toxic and can contaminate the food.
.• When cooking use dry wood or charcoal, and allow the wood gas to burn off as flames to leave hot glowing embers, cook
on the embers.
• If meat releases fat onto the hot embers which makes a flame, move the meat away from the flame.
• Keep a spray bottle of water handy to squirt on any flames.
• Used a cast iron pan to grill meat rather than placing directly on a grill.
• Alternatively wrap food in aluminium foil to prevent contamination.
FOOD HYGIENE AND SAFETY
When cooking outdoors take care food is kept in hygienic conditions.
• DO NOT leave meats in the sun or outside in hot weather, keep cool and covered with a clean cloth.
• DO NOT leave butter in the sun or uncovered.
• Keep meat and vegetables in separate dishes to avoid cross contamination with fluids.
• Only bring food out into the garden before cooking and it should be consumed after cooking as soon as possible. Food
should be eaten while hot, immediately after coming out of the fire. Dispose of any cooked food not eaten.
• MAKE SURE meat is thoroughly cooked.
• When cooking accessories are taken out of the fire, they are hot and need to be put onto a hard non-flam mable surface, so
the contents of the cooking accessory can be removed.
• DO NOT place the cooking accessory on the patio, grass, earth or directly on the ground.
• DO NOT put hot cooking accessories directly onto wood, furniture, plates, crockery or plastic surface.
• Parts of the cooking accessories in direct contact with the fire may become covered with carbon soot. Make sure you do
not contaminate your food with soot.
• CAREFUL HOT! DO NOT TOUCH, steel and cast iron cooking accessories are very hot when taken out of the fire, do not
touch with your fingers, protect hands with FIRE GLOVES.
• Cast iron cooking accessories can remain hot after use, so ALWAYS be very careful and cautious when handling cast iron
cooking accessories.
• DO NOT allow children to handle any of the cooking accessories.
• NEVER leave a cooking accessory in the fire unattended. If you leave food in the fire, it will be burnt and inedible.
1. This product is guaranteed for 12 months from the date of the original purchase. If any
defect arises due to faulty materials or workmanship, the faulty product must be
returned to the place of purchase.
2. Refund or replacement is at the discretion of the retailer.
3. The following conditions apply:
• The product must be returned to the retailer with the original proof of purchase.
• The product must be installed and used in accordance with the instructions contained
in this instruction guide and any other instructions for use which are supplied.
• It must be used for domestic purposes only and for its intended use.
• This warranty does not cover wear and tear, damage, misuse or consumable parts.
• This does not affect your statutory rights
4. To check the availability of spare parts, simply contact our friendly Customer Services
team on 0345 0719018 or email General-enquiries@jdwilliams.co.uk
Opening times: 7am to 10pm Monday to Friday
8am to 6pm Saturday and Sunday.
GUARANTEE AND CUSTOMER SERVICES
Tabla de contenidos
Otros manuales de Parrilla de Spear & Jackson
