Sony XR-C453RDS Manual de usuario

FM/MW/LW CASSETTE CAR STEREO

East European Model

Model Name Using Similar Mechanism XR-C450RDS

Tape Transport Mechanism Type MG-25B-136

SPECIFICATIONS

SERVICE MANUAL

XR-C453RDS

For RM-X2S (Remote Commander),

please refer to RM-X2S/X3S Service

Manual (9-960-039-S) previously issued.

Cassette player section

Tape track 4-track 2-channel stereo

Wow and flutter 0.08% (WRMS)

Frequency response 30-18,000 Hz

Signal-to-noise ratio 61 dB (TYPE II, IV)

58 dB (TYPE I)

Tuner section

Tuning range FM1, FM2: 87.5-108.0 MHz

FM3: 65.0-74.0 MHz

Antenna terminal External antenna connector

Intermediate frequency 10.7 MHz

Usable sensitivity 8 dBf

Selectivity 75 dB at 400 kHz

Signal-to-noise ratio 63 dB (stereo)

65 dB (mono)

Harmonic distortion at 1 kHz

0.5% (stereo), 0.3% (mono)

Separation 35 dB at 1 kHz

Frequency response 30-15,000 Hz

Capture ratio 2 dB

MW/LW

Tuning range MW: 531-1,602 kHz

LW: 153-281 kHz

Antenna terminal External antenna connector

Intermediate frequency 10.71 MHz/450 kHz

Sensitivity MW: 30 µV

LW: 50 µV

Power amplifier section

Outputs Speaker outputs (sure seal connectors)

Speaker impedance 4-8 ohms

Maximum power output 35 W ×4 (at 4 ohms)

General

Outputs Telephone mute control lead

Power amplifier control lead

Power antenna control lead

Line out (1)

Tone controls Bass ± 8 dB at 100 Hz

Treble ± 8 dB at 10 kHz

Power requirements 12 VDC car battery (negative ground)

Dimensions Approx. 188 ×58 ×181 mm (w/h/d)

Mounting dimensions Approx. 182 ×53 ×164 mm (w/h/d)

Mass Approx. 1.2 kg

Supplied accessories Parts for installation and connections (1 set)

Rotary commander RM-X2S (1)

Front panel case (1)

Design and specifications are subject to change without notice.

9-925-636-12 Sony Corporation

2001F0500-1 e Vehicle Company

C2001.6 ShinagawaTec Service Manual Production Group

Ver 1.1 2001.06

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 2 –

TABLE OF CONTENTS

1. GENERAL

Location of Controls ........................................................ 3

Setting the Clock ............................................................. 3

Using the Rotary Remote ................................................ 4

Adjusting the Sound Characteristics ............................... 4

Muting the Sound ............................................................ 4

Changing the Sound and Beep Tone................................ 4

Installation ....................................................................... 5

Connections ..................................................................... 6

2. DISASSEMBLY.......................................................... 9

3. ASSEMBLY OF MECHANISM DECK ........... 11

4. MECHANICAL ADJUSTMENTS ....................... 14

5. ELECTRICAL ADJUSTMENTS

Test Mode ........................................................................ 14

Tape Deck Section ........................................................... 14

Tuner Section................................................................... 15

6. DIAGRAMS

6-1. Printed Wiring Board – Main Section – ......................... 21

6-2. Schematic Diagram – Main Section (1/2) – .................... 23

6-3. Schematic Diagram – Main Section (2/2) – .................... 27

6-4. Printed Wiring Board – Power Section –........................ 29

6-5. Schematic Diagram – Power Section – .......................... 31

6-6. Printed Wiring Board – Display Section – ..................... 33

6-7. Schematic Diagram – Display Section – ........................ 35

6-8. IC Pin Function Description ............................................ 37

7. EXPLODED VIEWS ................................................ 39

8. ELECTRICAL PARTS LIST................................ 42

SERVICING NOTES

Flexible Circuit Board Repairing

•Keep the temperature of the soldering iron around 270 ˚C during

repairing.

•Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).

•Be careful not to apply force on the conductor when soldering or

unsoldering

Notes on chip component replacement

•Never reuse a disconnected chip component.

•Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 3 –

This section is extracted from

instruction manual.

SECTION 1

GENERAL

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 4 –

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 5 –

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 6 –

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 7 –

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 8 –

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 9 –

Note: Follow the disassembly procedure in the numerical order given.

FRONT PANEL ASS’Y

SECTION 2

DISASSEMBLY

COVER ASS’Y

cover ass’y

Push the button

(release)

Remove the front panel ass’y

to the direction of the arrow

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

– 10 –

SUB PANEL, MECHANISM DECK (MG-25B-136)

MAIN BOARD, HEAT SINK

sub panel

connector

(CN352)

screw

(PTT2.6

mechanism deck

(MG-25B-136)

flexible flat cable

(CN351)

three screws

(PTT2.6

three screws

(PTT2.6

eight screws

(PTT2.6

screw

(PTT2.6

two screw

(PTT2.6

heat sink

main board

two ground point

screws

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

Otros manuales para XR-C453RDS

Tabla de contenidos

Otros manuales de Receptor de coche de Sony

Sony

Sony XAV-9500ES Guía de referencia

Sony

Sony XR-CA400 Manual de usuario

Sony

Sony XR-CA440X Guía del producto

Sony

Sony CDX-C5850R Manual de usuario

Sony

Sony XR-3501MK2 Manual de usuario

Sony

Sony CDX-GT610UI - Cd Receiver With Ipod... Guía del producto

Sony

Sony CDX-757MX - Compact Disc Changer System Manual de usuario

Sony

Sony XR-C9100R Manual de usuario

Sony

Sony XR-CA650X - Fm-am Cassette Car Stereo Guía del producto

Sony

Sony CDX-F7710S Manual de usuario

Sony

Sony CDX-HS70MS - Marine Stereo Guía del producto

Sony

Sony XR-4900 Manual de usuario

Sony

Sony MEXBT5700U - CD Receiver Bluetooth... Manual de usuario

Sony

Sony XR-CA350X Marketing s & diagrams Guía del producto

Sony

Sony XR-CA600X - Fm/mw/sw Cassette Car Stereo Manual de usuario

Sony

Sony MDX-F5800 Manual de usuario

Sony

Sony XAV-W650BT Manual de usuario

Sony

Sony XR-CA800 Guía del producto

Sony

Sony CDX-GT350MP - Fm/am Compact Disc Player Manual de usuario

Sony

Sony XR-C6103SP Manual de usuario

Sony

Sony CDX-GT71W - Fm/am Compact Disc Player Manual de usuario

Sony

Sony HCD-H61 Manual de usuario

Sony

Sony XR-C7220R Manual de usuario

Sony

Sony CDX-F5005X - Fm/am Compact Disc Player Manual de usuario

Manuales populares de Receptor de coche de otras marcas

Motorola

Motorola VWA63 Manual de usuario

Nextar

Nextar D3201 Manual de usuario

Alpine

Alpine CDE-163BT Manual de usuario

Pioneer

Pioneer DEH-P645R Manual de usuario

Axxera

Axxera XDMA7600 Instrucciones de funcionamiento

XM OnyX Manual de usuario

Sound Storm

Sound Storm STM93R Manual de usuario

Soundstream

Soundstream VIR-5000 Manual de usuario

Avson

Avson MKT Platform Manual de usuario

Pioneer

Pioneer DVH-P500UB Manual de usuario

JVC

JVC KD-AHD69 Manual de usuario

Blaupunkt

Blaupunkt SANTIAGO CR 87 Manual de usuario

XFIRE AUDIO

XFIRE AUDIO BMW42S Manual de usuario

VDO

VDO CD 2253 Manual de usuario

Volvo

Volvo 13 84 580 Manual de usuario

ZENEC

ZENEC ZE-160DVD Manual de usuario

Medion

Medion Car Audio Manual de usuario

Philips

Philips CEM5000 Manual de usuario