Siemens S65 Guía de configuración
Company Confidential s Com
Copyright 2004© Siemens AG
Page 1of 15
Service Repair Documentation
Level 2.5 light - S65
Service Repair Documentation
Level 2.5 light - S65
Release Date Department Notes to change
1.0 04.08.2004 ICM MP CCQ GRM T New document
1.1 25.11.2004 ICM MP CCQ GRM T MMC Melting Problem
1.2 12.01.2005 COM MD CC GRM T SIM Card Reader Add On
Company Confidential s Com
Copyright 2004© Siemens AG
Page 2of 15
Service Repair Documentation
Level 2.5 light - S65
Introduction
This Service Repair Documentation is intended to carry out repairs on Siemens repair level
2.5 light. The described failures shall be repaired in Siemens authorized local workshops
only,
The level 2.5 (former Level 2.5e) partners are obliged to repair level 2 classified boards, up
to their repair level, under consideration of the information given by level 2.5 (former level
2.5e) repair instruction.
All repairs have to be carried out in an ESD protected environment and with ESD protected
equipment/tools. For all activities the international ESD regulations have to be considered.
Assembling/disassembling has to be done according to the latest S65 Level 2 repair
documentation. It has to be ensured that every repaired mobile Phone is checked according
to the latest released General Test Instruction document (both documents are available in
the Technical Support section of the C-market).
Check at least weekly C-market for updates and consider all S65 related Customer Care
Information
CX65 Partnumber on IMEI label: S30880-S7400-#xxx
, while # may be any letter (A-Z) and xxx may be any number from 100, 101, 102....
Scrap Handling: All Scrap information given in this manual are related to the
SCRAP-Rules and instructions.
If you have any questions regarding the repair procedures or technical questions spare not
hesitate to contact our technical support team in Kamp-Lintfort, Germany:
Tel.: +49 2842 95 4666
Fax: +49 2842 95 4302
Company Confidential s Com
Copyright 2004© Siemens AG
Page 3of 15
Service Repair Documentation
Level 2.5 light - S65
Table of Content
1S65 board layout ...........................................................................................................................4
2Connector SIM Card Reader.........................................................................................................5
3Connector IO Jack.........................................................................................................................6
4Connector Board to Board.............................................................................................................8
5Connector Battery .........................................................................................................................9
6Connector MMC ..........................................................................................................................10
7Connector RF..............................................................................................................................11
8Connector Camera......................................................................................................................12
9Connector Display.......................................................................................................................13
10 IRDA.........................................................................................................................................14
11 JOYSTICK................................................................................................................................15
Company Confidential s Com
Copyright 2004© Siemens AG
Page 4of 15
Service Repair Documentation
Level 2.5 light - S65
1 S65 board layout
Jigs, Tools and Working materials for all described repairs:
-hot air blower
-soldering gun
-tweezers
-flux
-solder
Company Confidential s Com
Copyright 2004© Siemens AG
Page 5of 15
Service Repair Documentation
Level 2.5 light - S65
2 Connector SIM Card Reader
Fault Symptoms
Customer: GRT:
Handset does not accept SIM card SIM Card Problems
Connector SIM Card Reader
Use soldering iron to remove defective component. Avoid excessive heat! Watch surrounding components!
Resolder new component afterwards.
E-commerce order number: L36334-Z97-C337
Soldering temperature: 240 - 255°C
IRIS Diagnose Code: 43300 Interface/SIM Cardreader/Mechanical Damage
Surrounded Components
R1614 Resistor Res_Type8 L36842-C472-J
C1605 Capacitor Cap_Type3 L36853-C6224-M6
Z1601 Filter L50620-U6056-D670
Company Confidential s Com
Copyright 2004© Siemens AG
Page 6of 15
Service Repair Documentation
Level 2.5 light - S65
Connector IO Jack
Fault Symptoms
Customer: GRT:
Charging Problems No connection to GRT
Problems with external loudspeaker or microphone when using a car kit Tbd.
Problems with accessories connected at the IO connector
Connector IO Jack
Use soldering iron to remove defective component. Avoid excessive heat! Watch surrounding components!
Resolder new component afterwards.
E-commerce order number: L36334-Z93-C303
Soldering temperature: 240 - 255°C
IRIS Diagnose Code: 46100 Interface/Charging Connector/Mechanical Damage
47300 Interface/Data Interface/Mechanical Damage
4B100 Interface/Headset Connector/Mechanical Damage
Company Confidential s Com
Copyright 2004© Siemens AG
Page 7of 15
Service Repair Documentation
Level 2.5 light - S65
Important additional soldering hints
The MMC Reader is located on the opposite of the SLIM-Lumberg connector.
Therefore the risk to damage the plastic material of this MMC-Reader is
potentially high if excessive heat is used while removal or soldering of the
SLIM-Lumberg connector.
Please follow this instructions:
a) Remove the SLIM-Lumberg connector with a soldering iron and Desolder
Wick
b) Clean the Pads afterwards
c) Solder the new connecter by using soldering iron under consideration of
the max. allowed temperature range.
Samples of critical area:
Lock mechanism damaged Lock mechanism OK
Company Confidential s Com
Copyright 2004© Siemens AG
Page 8of 15
Service Repair Documentation
Level 2.5 light - S65
3 Connector Board to Board
Fault Symptoms
Customer: GRT:
Keyboard malfunction Keyboard malfunction
Keypad illumination does not work Tbd.
Connector Board to Board
Use hot air blower to remove defective component. Avoid excessive heat! Watch surrounding components!
Resolder new component afterwards.
E-commerce order number: L36334-Z97-C346
Soldering temperature: 240 - 255°C
IRIS Diagnose Code: 32100 Keys / Main / No Function
32200 Keys / Main / Reduced Functionality
36000 Keys / Illumination
Company Confidential s Com
Copyright 2004© Siemens AG
Page 9of 15
Service Repair Documentation
Level 2.5 light - S65
4 Connector Battery
Fault Symptoms
Customer: GRT:
Mobile does not switch on No connection to GRT
Connector BATTERY
Use hot air blower to remove defective component. Avoid excessive heat! Watch surrounding components!
Resolder new component afterwards.
E-commerce order number: L36334-Z97-C213
Soldering temperature: 240 - 255°C
IRIS Diagnose Code: 13000 Battery/Mechanical Damage
Company Confidential s Com
Copyright 2004© Siemens AG
Page 10 of 15
Service Repair Documentation
Level 2.5 light - S65
5 Connector MMC
Fault Symptoms
Customer: GRT:
MMC malfunction Tbd.
Connector MMC
Use soldering iron to remove defective component. Avoid excessive heat! Watch surrounding components!
Resolder new component afterwards.
E-commerce order number: L36334-Z97-C342
Soldering temperature: 240 - 255°C
IRIS Diagnose Code: B1120 Accessories / Memory / MMC / Defect
Attention: Avoid excessive heat in order not to damage the plastic material of the
connector (see problem SLIM-Lumberg connector)
Otros manuales para S65
4
Tabla de contenidos
Otros manuales de Teléfono móvil de Siemens
Siemens
Siemens S75 Manual de usuario
Siemens
Siemens Gigaset SL400 Manual de usuario
Siemens
Siemens CF62 Manual de usuario
Siemens
Siemens Xelibri Manual de usuario
Siemens
Siemens S65 Manual de usuario
Siemens
Siemens CL75 Guía de configuración
Siemens
Siemens S65 Manual de usuario
Siemens
Siemens SIMATIC NET CP 243-1 Manual de usuario
Siemens
Siemens CF62 Manual de usuario
Siemens
Siemens A56 Manual de usuario
Siemens
Siemens HiPath 3000 V3.0 or later Gigaset M1... Manual de usuario
Siemens
Siemens A65 Manual de usuario
Siemens
Siemens M75 Manual de usuario
Siemens
Siemens CX75 Manual de usuario
Siemens
Siemens CF75 Manual de usuario
Siemens
Siemens M65 Manual de usuario
Siemens
Siemens 1168 Manual de usuario
Siemens
Siemens M50 Manual de usuario
Siemens
Siemens Gigaset S45 Manual de usuario
Siemens
Siemens Gigaset M56 Manual de usuario
