Sea-doo XP5662 Manual

www.SeaDooManuals.net

SEA-DOO XP (5662) OPERATOR’S GUIDE

SUPPLEMENT ___________________________________

NOTE: This supplement must be used in conjunction with the

1997 Sea-Doo

Operator’s Guide

PAGE 20

LOCATION OF THE IMPORTANT LABELS

F08L03L

610

smo9703a.fm5 Page 1 Thursday, November 13, 1997 1:59 PM

www.SeaDooManuals.net

F02L2DY

"THIS BOAT IS NOT REQUIRED TO COMPLY WITH THE

FOLLOWING U.S. COAST GUARD SAFETY STANDARDS

IN EFFECT ON THE DATE OF CERTIFICATION:

Fuel System

Display of Capacity

Information

Safe Loading

Flotation

Powered Ventilation

AS AUTHORIZED BY U.S. COAST GUARD GRANT OF

EXEMPTION (CGB 88-001)."

Bombardier Corp. 7575 Bombardier Court, Wausau, WI 54401

Made in Canada/Fabriqué au Canada Bombardier Inc. Rd./Enr.,1988

• WARNING

DO NOT BOOST BATTERY

WHILE INSTALLED.

F00L05Y

TO AVOID POSSIBLE ENGINE FLOODING WHEN ROLLED OVER :

MAKE SURE ENGINE IS OFF

GRAB INLET GRATE AND STEP

ON BUMPER RAIL

ROLL BOAT CLOCKWISE

CAUTION

F02L2EY

USE BOMBARDIER-ROTAX INJECTION OIL OR

HIGHER QUALITY LOW ASH API TC INJECTION

OIL FOR 2 CYCLES ENGINES.

• CAUTION

NEVER USE NMMA TC-W, TC-WII or TC-W3 outboard motor oils.

F00L06Y

F08L04L

WARNING

Read

allw

arning

labels

,Operato

rGui

de&s

afety

docu

mentsbefo

reope

rating.Se

vere injury

ord

eath can re

sult fr

omignor

ing such

infor

mati

onor

impro

peruseo

fthewater

craft.

•Direc

tional c

ontrol

is los

t when

throttle

isrele

asedore

ngin

etu

rnedof

•Check

throttle

& ste

eringbeforest

artinge

ngine.

•Donot

splash

other

orjumpwaves

orwak

es.

•Proper

ly atta

ch safe

tytethertoyo

urPFD.

•Keepa

safe d

istanc

efromotherw

ateruse

rs.Ob

serveboatingre

gulation

•This w

atercra

ft is no

tdesignforni

ghttime

opera

tion.

KEEP WATE

RCR

AFTL

EVELWHI

LEFUE

LIN

NOTOV

ERFILL.

CHE

CKOIL L

EVE

PERIODIC

ALLY,CHEC

KFUEL

SYST

EM.

CLOSE ENGI

NEC

OVER

BEFORE

FUELI

NG.

smo9703a.fm5 Page 2 Thursday, November 13, 1997 1:59 PM

www.SeaDooManuals.net

PAGE 33

2) Throttle Lever

ADDITION: Do not activate or jerk throttle lever unnecessarily, carburetors are

fed with a fuel acceleration pump. The acceleration pump delivers fuel to the

engine each time throttle lever is applied.

PAGE 46

Recommended Oil

CHANGE: Use BOMBARDIER ROTAX INJECTION OIL which is available from

authorized dealers. It is a blend of specially selected base oils and additives which

provides outstanding lubrication, engine cleanliness and minimum spark plug

fouling.

NOTE: High quality low ash API TC injection oil for 2-cycle engines can be used

if BOMBARDIER ROTAX INJECTION OIL is not available.

PAGE 51

Steering and Throttle Systems

CHANGE: Check throttle lever ONCE for free and smooth operation. It must re-

turn to its initial position immediately after it is released.

PAGE 73

Throttle and Choke Cable Inspection

Throttle Cable

CHANGE: Depress and release the throttle lever ONCE. It must operate smooth-

ly and return to its initial position without any hesitation. Refer to an authorized

dealer if necessary.

-CAUTION

Engine can be flooded if throttle lever is applied several times. If engine

is flooded, it will not start.

-CAUTION

Never use 4-cycle motor oil and never mix these with outboard motor oil.

Do not use NMMA TC-W, TC-W2 or TC-W3 outboard motor oils or other

ashless type 2-cycle oil. Avoid mixing different brands of API TC oil as

resulting chemical reaction may cause severe engine damage.

smo9703a.fm5 Page 3 Thursday, November 13, 1997 1:59 PM

www.SeaDooManuals.net

SPECIFICATIONS________________________________

ENGINE XP (5662)

Engine type Bombardier-Rotax 787, 2-stroke

Induction type Rotary valve

Exhaust system Water cooled/water injected with regulator

Exhaust valve Rotax Adjustable Variable Exhaust (R.A.V.E.)

Lubrication Type Oil injection

Oil type BOMBARDIER ROTAX

INJECTION OIL

Number of cylinders 2

Displacement 781.6 cm3(47.7 in3)

Rev limiter setting 7200 (± 50) RPM

COOLING

Type Water cooled, total loss type.

Direct flow from propulsion unit.

ELECTRICAL

Magneto generator output 180 W @ 6000 RPM

Ignition system type Digital DC-CDI

Spark plug Make and type NGK, BR8ES

Gap 0.5 - 0.6 mm

(.020 - .024 in)

Starting system Electric starter

Battery 12 V, 19 A

Fuse Starting

system 5 A

Charging

system 2 x 15 A

VTS system 7.5 A

CARBURETION

Fuel type Regular unleaded gasoline

Carburetor BN 40I

Diaphragm type with acceleration pump

Quantity: 2

smo9703a.fm5 Page 4 Thursday, November 13, 1997 1:59 PM

www.SeaDooManuals.net

➀Refer to load limit.

N.A.: Not Applicable.

BOMBARDIER INC. reserves the right to make changes in design and specifica-

tions and/or to make additions to, or improvements in its products without im-

posing any obligation upon itself to install them on its products previously manu-

factured.

PROPULSION XP (5662)

Propulsion system Bombardier Formula pump

Jet pump type Axial flow, single stage

Transmission Direct drive/split FR and RR

Impeller shaft reservoir oil type SEA-DOO jet pump synthetic

polyolester oil 75W90 GL5

Pivoting angle of direction (nozzle) ~ 26°

Pivoting angle of variable trim system ± 8°

Minimum required water

level for jet pump 90 cm (3 ft)

PERFORMANCE

Cruising time at full

throttle Fuel tank without

reserve N.A.

Fuel tank

reserve N.A.

DIMENSIONS

Number of passengers ➀2

Overall length 272 cm (107 in)

Overall width 111 cm (43.7 in)

Overall height 103 cm (40.6 in)

Weight 238 kg (525 lb)

Load limit

(passengers + luggage) 159 kg (351 lb)

CAPACITIES

Fuel tank 43.5 L (11.5 U.S. gal)

Impeller shaft

reservoir Capacity 70 mL (2.4 U.S. oz)

Oil level Up to plug

Oil injection reservoir 4 L (1.1 U.S. gal)

smo9703a.fm5 Page 5 Thursday, November 13, 1997 1:59 PM

www.SeaDooManuals.net

Tabla de contenidos

Otros manuales de Bote de Sea-doo

Sea-doo

Sea-doo GTI Series Manual

Sea-doo

Sea-doo RXP-X 260 Manual

Sea-doo

Sea-doo 2006 GTI Manual

Sea-doo

Sea-doo SPORTSTER 4-TEC Guía de instalación

Sea-doo

Sea-doo Speedster 200 Manual

Sea-doo

Sea-doo GS 5626 Manual

Sea-doo

Sea-doo GTX RFI 5666 Manual

Sea-doo

Sea-doo LRV 5688 Manual

Sea-doo

Sea-doo Challenger*180 Manual

Sea-doo

Sea-doo Speedster 5894 Guía de instalación

Sea-doo

Sea-doo Aqua Master ZS40 Manual de usuario

Sea-doo

Sea-doo GTX+ Manual de usuario

Sea-doo

Sea-doo 2006 3D RFI Manual

Sea-doo

Sea-doo Speedster Manual

Sea-doo

Sea-doo XP DI 2003 Manual

Sea-doo

Sea-doo 2006 GTI Guía de instalación

Sea-doo

Sea-doo GTI LE RF 2003I Manual

Sea-doo

Sea-doo 2004 3D RFI Guía de instalación

Sea-doo

Sea-doo 2001 UTOPIA 185 Guía de instalación

Sea-doo

Sea-doo 2004 3D RFI Manual de usuario

Sea-doo

Sea-doo SPARK Series Manual

Sea-doo

Sea-doo 2000 Islandia Manual

Sea-doo

Sea-doo 2001 GS Guía de instalación

Sea-doo

Sea-doo 2012 Sea Doo GTX series Manual

Manuales populares de Bote de otras marcas

Raymarine

Raymarine ST70 Instrument Manual de usuario

Pro-Line Boats

Pro-Line Boats Pro Line 19 Sport Manual de usuario

Jeanneau

Jeanneau CAP CAMARAT 8.5 CC Manual de usuario

Tiara Yachts

Tiara Yachts C49 2024 Manual de usuario

Monterey Boats

Monterey Boats Sport Yacht 330 Manual de usuario

J 105 Manual de usuario

PURSUIT

PURSUIT OS 335 Manual de usuario

Boston Whaler

Boston Whaler CONQUEST 345 Manual de usuario

Jeanneau

Jeanneau SUN ODYSSEY 41 DS Manual de usuario

Meridian

Meridian 490 Pilothouse Manual de usuario

Advanced Elements

Advanced Elements AdvancedFrame Expedition AE1009 Manual de usuario

Robo Marine Indonesia

Robo Marine Indonesia GEOMAR Manual de usuario

Swallow Boats

Swallow Boats BayRaider Manual de usuario

Intex

Intex Excursion 5 Set Manual de usuario

X SHORE

X SHORE EELEX 8000 Manual de usuario

ISLAND PACKET

ISLAND PACKET 370 Manual de usuario

Sea Ray

Sea Ray 175 Sport Manual de usuario

Regal

Regal 2300 Manual de usuario