Samsung AQ12?5(6)MB Manual de usuario

SERVICE Manual

CONTENTSAIR CONDITIONER

1. Precautions

2. Product Specifications

3. Operating Instructions and

3. Installation

4. Disassembly and Reassembly

5. Troubleshooting

6. Exploded Views and Parts List

7. Block Diagrams

8. PCB Diagrams

9. Wiring Diagrams

10. Schematic Diagrams

ROOM AIR CONDITIONER

INDOOR UNIT

AQ12✳5(6)MB

AQ12✳5(6)ME

AQ09✳5(6)ME

SH09Z✳5(6)

AQ07✳5(6)ME

SH07Z✳5(6)

AQ09✳7(8)ME

SH09Z✳7(8)

AQ07✳7(8)ME

SH07Z✳7(8)

AQ12✳9(0)ME

SH12Z✳9(0)

AQ12✳A(B)ME

AQ09✳5(6)MED

AQ07✳5(6)MED

SH12Z✳A(B)

SH09Z✳5(6)D

SH07Z✳5(6)D

OUTDOOR UNIT

UQ12✳5(6)MB

UQ12✳5(6)ME

UQ09✳5(6)ME

SH09Z✳5(6)X

UQ07✳5(6)ME

SH07Z✳5(6)X

UQ09✳7(8)ME

SH09Z✳7(8)X

UQ07✳7(8)ME

SH07Z✳7(8)X

UQ12✳9(0)ME

SH12Z✳9(0)X

UQ12✳A(B)ME

UQ09✳5(6)MED

UQ07✳5(6)MED

SH12Z✳A(B)X

SH09Z✳5(6)DX

SH07Z✳5(6)DX

DB81-00181A(4)-cover 3/6/11 3:12 PM Page 3

1-1Samsung Electronics

1. Warning: Prior to repair, disconnect the

power cord from the circuit breaker.

2. Use proper parts: Use only exact replace-

ment parts. (Also, we recommend replacing

parts rather than repairing them.)

3. Use the proper tools: Use the proper tools

and test equipment, and know how to use

them. Using defective tools or test equip-

ment may cause problems later-intermittent

contact, for example.

4. Power Cord: Prior to repair, check the

power cord and replace it if necessary.

5. Avoid using an extension cord, and avoid

tapping into a power cord. This practice

may result in malfunction or fire.

6. After completing repairs and reassembly,

check the insulation resistance.

Procedure: Prior to applying power, mea-

sure the resistance between the power cord

and the ground terminal. The resistance

must be greater than 30 megaohms.

7. Make sure that the grounds are adequate.

8. Make sure that the installation conditions

are satisfactory.

Relocate the unit if necessary.

9. Keep children away from the unit while it is

being repaired.

10. Be sure to clean the unit and its surround-

ing area.

1. Precautions

Fig. 1-1 Avoid Dangerous Contact

Fig. 1-2 No Tapping and No Extension Cords

Fig. 1-3 No Kids Nearby!

O.K

Fig. 1-4 Clean the Unit

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-1

Samsung Electronics2-1

2. Product Specifications

2-1 Table

Model

Item

Type

Cooling BTU/h(KW)

Heating BTU/h(KW)

Dehumiditying I/h

Air volume Cooling m3/min

Heating

Noise Cooling dB

Heating

Energy efficiency ratio Cooling BTU/h•W

Heating (W/W)

Power V-Hz

Power Consumption Cooling W

Heating

Operating Current Cooling A

Heating

Power factor Cooling %

Heating

Starting current A

Power cord Length m

Number of core wire

Fuse capacity A

Outer Width x Height mm

Dimension x Depth inch

Weight

Refrigerant pipe Liquid mm x L(MT)

GAS mm x L(MT)

Drain hose D x L(mm)

Compressor Type

Motor Type

Rated output

Blower Type

Motor Type

Rated output W

Heat exchanger

Refrigerant control unit

Freezer oil capacity

Refrigerant to change(R-22)

Protection device

Cooling test Condition

Maximum operation Condition

AQ12

✳

5(6)MB

Indoor unit Outdoor unit

Wall-mounting

12000

13000

1.9

7.4 19

8.1 19

41 53

9.375

10.0

1-220 -60

1280

1300

6.0

6.2

95.3

250V-10 / 16A

790 x 245 x 165 762 x 532 x 280

31.1 x 9.6 x 6.5 30 x 20.9 x 11

7.7 35

ø6.35 x 5

ø12.7 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 20STEP

CAPILLARY TUBE

410

800

MRA 12002-9200/MRA 12002-12008

AQ12

✳

5(6)ME

Indoor unit Outdoor unit

Wall-mounting

12000 (3.4)

13000 (3.7)

1.9

7.4 19

8.1 19

41 53

10.0

10.6

1-220 / 240-50

1200

1230

5.4

5.5

96.6

97.2

250V-10 / 16A

790 x 245 x 165 762 x 532 x 280

31.1 x 9.6 x 6.5 30 x 20.9 x 11

7.7 35

ø6.35 x 5

ø12.7 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 20STEP

CAPILLARY TUBE

410

820

MRA 12030-12008/RAC12030-9622

AQ09

✳

5(6)ME/SH09Z

✳

5(6)

Indoor unit Outdoor unit

Wall-mounting

9000 (2.72)

10000 (2.95)

1.4

6.0 18

6.7 18

38 51

9.375

10.752

1-220 / 240-50

960

930

4.4

4.2

94.9

96.3

250V-10 / 16A

790 x 245 x 165 660 x 497 x 235

31.1 x 9.6 x 6.5 26 x 19.6 x 9.3

7.7 29

ø6.35 x 5

ø9.52 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 18STEP

CAPILLARY TUBE

360

670

RAC 12054-9622

Power

Size

Perfor-

mance

INDOOR UNIT : DB27°C WB19°C

INDOOR UNIT : DB32°C WB23°C

OUTDOOR UNIT : DB35°C WB24°C

OUTDOOR UNIT : DB43°C WB26°C

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-2

2-2Samsung Electronics

AQ07

✳

5(6)ME/SH07Z

✳

5(6)

Indoor unit Outdoor unit

Wall-mounting

7500 (2.3)

8000 (2.38)

0.9

5.6 18

5.5 18

35 50

10.0

10.959

1-220 / 240-50

750

730

3.3

98.8

96.7

250V-10 / 16A

790 x 245 x 165 660 x 497 x 235

31.1 x 9.6 x 6.5 26 x 19.6 x 9.3

7.7 29

ø6.35 x 5

ø9.52 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 18STEP

CAPILLARY TUBE

360

630

RAC 12086-9622

AQ09

✳

7(8)ME/SH09Z

✳

7(8)

Indoor unit Outdoor unit

Wall-mounting

9000 (2.64)

10000 (2.93)

1.4

6.0 20.5

6.7 20.5

38 51

9.47

10.75

1-220 / 240-50

950

930

4.2

3.9

98.3

10.37

250V-10 / 16A

790 x 245 x 165 660 x 470 x 242

31.1 x 9.6 x 6.5 26 x 18.5 x 9.5

7.7 2.5

ø6.35 x 5

ø9.52 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 18STEP

CAPILLARY TUBE

360

600

MRA 12110-12008/RAC12054-9622

AQ07

✳

7(8)ME/SH07Z

✳

7(8)

Indoor unit Outdoor unit

Wall-mounting

7500 (2.2)

8000 (2.34)

0.9

5.6 20.5

5.5 20.5

35 50

10.0

10.96

1-220 / 240-50

750

730

3.3

3.2

98.8

99.2

250V-10 / 16A

790 x 245 x 165 660 x 470 x 242

31.1 x 9.6 x 6.5 26 x 18.5 x 9.5

7.7 25

ø6.35 x 5

ø9.52 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 18STEP

CAPILLARY TUBE

360

620

MRA 12086-12008/RAC12086-9622

AQ12

✳

9(0)ME/SH12Z

✳

9(0)

Indoor unit Outdoor unit

Wall-mounting

12000 (3.5)

13000 (3.8)

1.9

7.4 19

8.1 19

41 53

10.3

10.2

1-220 / 240-50

1170

1270

5.0

5.4

101.7

102.3

250V-10 / 16A

790 x 245 x 165 720 x 532 x 245

31.1 x 9.6 x 6.5 28.3 x 20.9 x 9.6

7.7 39

ø6.35 x 5

ø12.7 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 2ROW 20STEP

CAPILLARY TUBE

410

970

MRA 12030-12008/RAC12030-9622

INDOOR UNIT : DB27°C WB19°C

INDOOR UNIT : DB32°C WB23°C

OUTDOOR UNIT : DB35°C WB24°C

OUTDOOR UNIT : DB43°C WB26°C

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-3

Samsung Electronics2-3

Table (Cont.)

Model

Item

Type

Cooling BTU/h(KW)

Heating BTU/h(KW)

Dehumiditying

Air volume Cooling m3/min

Heating

Noise Cooling dB

Heating

Energy efficiency ratio Cooling BTU/h•W

Heating (W/W)

Power V-Hz

Power Consumption Cooling W

Heating

Operating Current Cooling A

Heating

Power factor Cooling %

Heating

Starting current A

Power cord Length m

Number of core wire

Fuse capacity A

Outer Width x Height mm

Dimension x Depth inch

Weight

Refrigerant pipe Liquid mm x L(MT)

GAS mm x L(MT)

Drain hose D x L(mm)

Compressor Type

Motor Type

Rated output

Blower Type

Motor Type

Rated output W

Heat exchanger

Refrigerant control unit

Freezer oil capacity

Refrigerant to change(R-22)

Protection device

Cooling test Condition

Maximum operation Condition

AQ12

✳

A(B)ME / SH12Z

✳

A(B)

Indoor unit Outdoor unit

Wall-mounting

12000 (3.5)

13000 (3.8)

1.9

7.4 23.0

7.9 23.0

41 53

(2.99)

1-220 / 240-50

1170

1270

5.4

5.5

96.0

250V-10 / 16A

790 x 245 x 165 740 x 530 x 230

31.1 x 9.6 x 6.5 29.1 x 20.6 x 9.1

7.7 35.0

ø6.35 x 5

ø12.7 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 24STEP

CAPILLARY TUBE

410

1000

RAC12030-9622

AQ09

✳

5(6)MED/SH09Z

✳

5(6)D

Indoor unit Outdoor unit

Wall-mounting

9000 (2.64)

10000 (2.85)

1.4

6.0 18

6.7 18

38 51

8.91

10.87

1-220 / 240-50

1010

920

4.4

4.0

99.8

250V-10 / 16A

790 x 245 x 165 660 x 497 x 235

31.1 x 9.6 x 6.5 26 x 19.6 x 9.3

7.7 29

ø6.35 x 5

ø9.52 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 22STEP

CAPILLARY TUBE

360

610

RAC 12054-9622

AQ07

✳

5(6)MED / SH07Z

✳

5(6)D

Indoor unit Outdoor unit

Wall-mounting

7500 (2.20)

8000 (2.34)

0.9

5.6 18

5.5 18

35 50

9.74

10.959

1-220 / 240-50

770

730

3.4

3.2

94.4

95.0

250V-10 / 16A

790 x 245 x 165 660 x 497 x 235

31.1 x 9.6 x 6.5 26 x 19.6 x 9.3

7.7 29

ø6.35 x 5

ø9.52 x 5

ø18 x 2000

Rotary

Cross-flow Propeller

Resin steel

15 25

2ROW 12STEP 1ROW 22STEP

CAPILLARY TUBE

360

520

RAC 12086-9622

Power

Size

Perfor-

mance

INDOOR UNIT : DB27°C WB19°C

INDOOR UNIT : DB32°C WB23°C

OUTDOOR UNIT : DB35°C WB24°C

OUTDOOR UNIT : DB43°C WB26°C

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-4

2-4Samsung Electronics

2-2 Dimensions

2-2-1 Indoor Unit

790 165

245

Air in

(Front view)

(Remote Control)

(Rear view)

Air out

Installation plate

2245

115

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-5

Samsung Electronics2-5

2-2-2 Outdoor Unit

249

497

492

660

235

UQ09✳5(6)M✳

UQ07✳5(6)M✳

SH09Z✳5(6)X

SH07Z✳5(6)X

UQ09✳5(6)M✳D

UQ07✳5(6)M✳D

SH09Z✳5(6)DX

SH07Z✳5(6)DX

457 254

242

660

457

SH07Z✳7(8)X

SH09Z✳7(8)X

UQ07✳7(8)M✳

UQ09✳7(8)M✳

UQ12✳5(6)M✳

280

555

762

532 295

(Front view) (Rear view)

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-6

Product Specifications

2-6Samsung Electronics

230

506

740 57

UQ12✳A(B)ME

SH12Z✳A(B)X

UQ12✳9(0)M✳

SH12Z✳9(0)X

532 267

245

496

720 55

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-7

Samsung Electronics2-7

2-3 Pressure Graph

20 25 30 35 40 45

32.4/24.0

30.6/22.5

28.8/21.0

27.0/19.0

24.0/17.0

21.5/15.0

6.5

5.5

4.5

3.5

12K BTU

20 25 30 35 40 45

32.4/24.0

30.6/22.5

28.8/21.0

27.0/19.0

24.0/17.0

21.5/15.0

6.5

5.5

4.5

3.5

9K BTU

20 25 30 35 40 45

32.4/24.0

30.6/22.5

28.8/21.0

27.0/19.0

24.0/17.0

21.5/15.0

7K BTU

DB81-00181A(4)-1 3/6/11 3:23 PM Page 1-8

3-1Samsung Electronics

3. Operating Instructions and Installation

3-1 Operating Instructions

To select the 5 way function with the remote control, press the 5 way

button one or more times until the desired mode is selected.

Each time you press the 5 way button.

Each 5 way indicator on the indoor unit comes on in order.

Each time you press this button,

FAN SPEED is changed in the following order.

Press until the appearance. the sleep timer can be used when

you are cooling or heating your room to switch the air conditioner off

automatically after a perriod of six hours.

Temp. down button. To decrease the temperature by the pressing

the temperature button.

FUNCTION OF KEY

3-1-1 Name & Function of Key in remote controller

(DOWN)

Power On/Off button to start and stop airconditioner or timer set up.

Press until the appearance. the air condition cools or heats

the room as quickly as possible. after 30minutes, the air,

the airconditioner is reset automatically to the previous mode.

NAMED OF KEY

(UP)

Adjust air flow vertically.

Each time you press this button

Mode is changed in the following order : Auto Mode : Fan Only

: Cool Mode : Heat Mode

: Dry Mode

Temp. up button. To increase the temperature by the pressing

the temperature button.

The ON Timer enables you to switch on the air conditioner automatically

after a given period of time that is from 30 minutes to 24 hours.

To cancel, press the (Set/Cancel) button.

The Off Timer enables you to switch off the air conditioner automatically

after a given period of time that is from 30 minutes to 24 hours.

To cancel, press the (Set/Cancel) button.

DB81-00181A(4)-1 3/6/11 3:23 PM Page 3-1

Este manual sirve para los siguientes modelos

106

Tabla de contenidos

Otros manuales de Acondicionador de aire de Samsung

Samsung

Samsung Air ConditioningUnits Manual de usuario

Samsung

Samsung AM***FNFDEH series Manual de usuario

Samsung

Samsung AW08P1 Series Manual de usuario

Samsung

Samsung ECO HP Manual de usuario

Samsung

Samsung AWT18QBHDA Manual de usuario

Samsung

Samsung SC18AW6 Manual de usuario

Samsung

Samsung AWT18S1WDCG Manual de usuario

Samsung

Samsung MXD-14K Series Manual de usuario

Samsung

Samsung AC052MN4DKH Manual de usuario

Samsung

Samsung AW1291L Manual de usuario

Samsung

Samsung AVXC1H022EA Manual de usuario

Samsung

Samsung AC026KNADEH Manual de usuario

Samsung

Samsung APH450PG Manual de usuario

Samsung

Samsung EHS AE050RXYDEG/EU Manual de usuario

Samsung

Samsung AVMGH052EA4 Manual de usuario

Samsung

Samsung AVMCH070EA4 Manual de usuario

Samsung

Samsung AG042KSVANH Manual de usuario

Samsung

Samsung AWT18P1HBB Manual de usuario

Samsung

Samsung AS09W8WE/XAP Manual de usuario

Samsung

Samsung AVXDSH022EE Manual de usuario

Samsung

Samsung AR10FVSED Series Guía

Samsung

Samsung ADC4400TB Manual de usuario

Samsung

Samsung AC035FCADEH/EU Manual de usuario

Samsung

Samsung AC100JNCDEH/EU Manual de usuario

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Daikin

Daikin FCFV50A Manual de usuario

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Daikin

Daikin FXLQ20MAVE Manual de usuario

Hitachi

Hitachi RAS-E24CAK Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario

Webasto

Webasto Frigo Top 25 DS Manual de usuario

Frigidaire

Frigidaire FAZ12ES2A Manual de usuario