Rollplay W488 Manual de usuario

Mercedes Benz GL (W488)

Customer Service Guide

2

Customer Service Guide

Contents

I) Check Battery …………………………............................................. 3

II) Check Wiring Condition ……………………………..………………………. 5

III) Check Foot Pedal ………………………………………………………….….... 12

IV) Gearbox Replacement …………………………………………..…………… 14

V) Door Replacement .…………………………………..…….……..….………. 17

VI)Motor Control Board Replacement .….………..…….……..….………. 19

VII) Headlight Replacement .….……………………...…….……..….………. 21

VIII) Schematic diagram ……………..…………….…..….………..……………. 22

IX) Exploded View …………..………………..…....….……….……..…….…… 23

CAUTION :

Disconnect the battery before proceeding.

3

Customer Service Guide

I) Check Battery

Operation: Using a Flat head screwdriver, unlock and remove the seat. Locate the battery

harness, unplug the connector, and use a volt-meter to check battery condition

at battery side.

Step (1)

Turn and unlock this plastic knob according to the icon

Step (2)

Unplug the battery connector (red) by holding down

the small clip and pulling apart.

4

Customer Service Guide

I) Check Battery

Step

(3)

Voltage Reading: 6.0 V ~ 6.5 V –Good condition

5.6 V ~ 5.9 V –Proceed to Recharge

5.5 V –Battery to be recharged if after the stipulated

recharging time, voltage has not increased,

the Battery needs replacement

Below 5.5 V –Battery needs replacement

5

Customer Service Guide

II) Check Wiring Connection

Operation: Disconnect and reconnect all plugs and connections leading to the drive board

shown below.

A. Motor/Gearbox : Follow above (Point I) to remove the seat, locate the Gearbox

harness underneath.

Customer Service Guide

VI)Motor Control Board Replacement

Operation: Follow above (Point I) to remove the seat first and replace the Motor Control

Board (MCB) by below steps.

Customer Service Guide

Re-Coding Remote Control

Follow the below steps if;

1: Replacing the receiver/drive board module in the vehicle or

2: Remote control function is not operating as it should.

Note: The remote coding button should be held down for 5 seconds & then hold down

the receiver/module reset coding button for 5 seconds.

7

Customer Service Guide

II) Check Wiring Connection

C. Dashboard : Remove the Steering Wheel and Dashboard to check the connection.

Step (1)

Unscrew then pull up & out to remove steering wheel

Step (2)

Next, unscrew these two screws to remove the dashboard

8

Customer Service Guide

II) Check Wiring Connection

Step (3)

Pull up & out to remove the dashboard and windshield

together as one unit.

Step (4)

Check the 4-Pin plug

9

Customer Service Guide

II) Check Wiring Connection

D. Shifter : Follow steps above to remove the Dashboard, then check the connection

of Shifter and Main Power Switch as well.

Step (1)

Unplug this connector

Step (2)

Unscrew these four screws to remove the Windshield

Tabla de contenidos

Otros manuales de Coche de juguete motorizado de Rollplay

Rollplay

Rollplay Beach Cruiser Instrucciones de montaje

Rollplay

Rollplay W491-B-WH Instrucciones de montaje

Rollplay

Rollplay W442 Instrucciones de montaje

Rollplay

Rollplay W348AC-P-F Instrucciones de montaje

Rollplay

Rollplay 12V STORM UTV Manual de usuario

Rollplay

Rollplay W488AC Instrucciones de montaje

Rollplay

Rollplay FLEX KART XL PEDAL Instrucciones de montaje

Rollplay

Rollplay 6V Chevy W460 Manual de usuario

Rollplay

Rollplay Audi R8 Spyder Instrucciones de montaje

Rollplay

Rollplay 6V BMW X5 Manual de usuario

Rollplay

Rollplay W466AC-R Instrucciones de montaje

Rollplay

Rollplay 6V Chevy Tahoe Police SUV Instrucciones de montaje

Rollplay

Rollplay MINI COUNTRYMAN 6V Instrucciones de montaje

Rollplay

Rollplay W503 Instrucciones de montaje

Rollplay

Rollplay BMW Motorrad R 1200 GS Manual de usuario

Rollplay

Rollplay W488AD Manual de usuario

Rollplay

Rollplay Turnado W401E Manual de usuario

Rollplay

Rollplay W462 Manual de usuario

Rollplay

Rollplay BMW i8 Concept Spyder Manual de usuario

Rollplay

Rollplay W461-RT Instrucciones de montaje

Rollplay

Rollplay 6V GMC Sierra W460-G Instrucciones de montaje

Rollplay

Rollplay W441 Instrucciones de montaje

Rollplay

Rollplay STORM Instrucciones de montaje

Rollplay

Rollplay BMW R1200 GS Motorcycle Manual de usuario

Manuales populares de Coche de juguete motorizado de otras marcas

Eduard

Eduard Humber Scout Car Mk.I exterior Manual de usuario

Traxxas

Traxxas 4995X Manual de usuario

Jamara

Jamara VW T1 Bus Manual de usuario

REVELL

REVELL 68 CHEVY CHEVELLE SS 396 Manual de usuario

Schumacher

Schumacher Pro Cat Manual de usuario

Tamiya

Tamiya TT-01 TYPE E Manual de usuario

Eduard

Eduard Krupp Protze 6x4 1/48 Manual de usuario

New Bright

New Bright 61072UEP Manual de usuario

Team Durango

Team Durango DEX410v5 Manual de usuario

Jamara

Jamara Mercedes Actros Muldenkipper 2,4 GHz Manual de usuario

PLAYMOBIL

PLAYMOBIL 9536 Manual de usuario

Atomic

Atomic BZ3 Manual de usuario

Aiyaplay

Aiyaplay 370-290V00 Manual de usuario

Power Wheels

Power Wheels GRJ53 Manual de usuario

ZEROTRIBE

ZEROTRIBE Zetricks ZT1144 Manual de usuario

INJUSA

INJUSA 412 Manual de usuario

Maverick

Maverick MSC-30BR-WP Manual de usuario

Land of B.

Land of B. Rollin' Riders Manual de usuario