Raytec RAYMAX WARRIOR Manual de usuario

illuminators installation guide

LUX WARRIORMAX and

This installation guide provides instructions for installing the RAYMAX Infra-Red and

RAYLUX White-Light WARRIOR series of explosion protected illuminators.

1. Safety Instructions

2. Installation

3. Maintenance

4. Technical Speciﬁcation

5. Trouble Shooting

Version 4.0

Important information

• TheWARRIORseriesofexplosionprotectedilluminatorsarespecialistdevices,

certiﬁed for use in speciﬁc operating environments.

• Theunitsmustbeinstalledinaccordwiththeseinstructions,mustbecorrectly

certiedforthespecicoperatingenvironmentandmustbeinstalledbysuitably

qualiﬁed personnel.

• Ifyouhaveanyqueriesabouttheinstallationorthecerticationoftheunit–please

contactRaytecforimmediateassistanceandadvice.

Overview

1.Safetyinstructions

1. ReadthisleaetcarefullybeforecommencingtoinstalltheWARRIORunitandretainit

forfutureuse.Installationcanonlybecarriedoutbysuitablyqualiedpersonnel.

2. Checkthecerticationtoensurethatthemainssupplyandtheambienttemperature

presentissuitablefortheunitbeinginstalled.

3. IftheWARRIORunitistobeinstalledinareasofhighvibration,pleaseconsultRaytec.

4. The WARRIOR unit housing is constructed from marine grade aluminium and

polycarbonate. The end user must ensure that these materials are suitable for the

atmospheretheWARRIORunitwillbeinstalledin;Zone1andZone2Hazardousareas.

5. The incoming mains cable should not exceed a temperature rise of 61˚C above

theambientconditions;selectsuitablecableandcablegland.You must use ATEX

approvedcableandglandse.g.M25,foradviceonsuitableglandsandcablesplease

contactRaytec

Specicationssubjecttochangewithoutnotice.

Installationtobecarriedoutbysuitabletrainedandqualiedpersonnel.

Isolatemainsbefore

removing cover

Installinawell

ventilated area

Donotcontinually

stare at lamp

1.5m

2. Installation

Mount WARRIOR Unit

1. TomeettherequirementsofcerticationaMINIMUMof2xingpointsmustbeused,

thexing/xingpointsmustbesuitablefortheconditionsofuse.

2. Theunitmayhavebeensuppliedwithanintegratedphotocell.Careshouldbetaken

whenpositioningtheunittoensurethesensorisnotshielded,isnotpointingdirectly

atanotherlightsourceandismonitoringthegeneral,prevailinglightconditions.

3. TheWARRIORilluminatorandthe mounting bracket is suppliedtogetheras a unit.

Theboltsinthesideofthehousingshallberemovedandusedtosecurethebracketto

theWARRIORhousing.Itisveryimportantthattheredbrewashersarettedbetween

theWARRIORhousingandthemountingbracket.Theunitmustbealignedrstbefore

securingthebracket.Theunitcanbemountedhorizontallyorverticallyallowingthe

unittopointup/downorleft/right.

267

R30

120

R15

5 x

HOLES 9

100

281

250

245

202

2 x M20 ENTRIES

COMPLETE WITH

IEC Ex APPROVED

STOPPER PLUGS

EXTERNAL

EARTH/GROUND

POINT

135

Power Connections

1 2 3 4 5 6 7 8 9 10 11 12

Terminal Loop

(colour may vary)

MAINS

INPUT

MAINS

LOOPING

OUTPUT

(OPTIONAL)

LAMPS (LED)

OUTPUTS

(OPTIONAL)

PHOTOCELL

INPUT

(OPTIONAL)

Terminal Pins

Wiring Label

Terminal

Cable Crimp

(colour may vary)

Terminal

Block

Weidmüller

WHITEWHITE

BLACKBLACK

BLACK

RED

BLUE

BROWN

GREEN/YELLOW

Photocell Black

(-ve)

Red

(+ve) N L E

WiretheMainscableintotheterminalblock.Provisionhasbeenmadeforthisandidentied

astheE(Earth/Ground),L(Live)andN(Neutral)terminals.Therearetwopairsofcontacts

foreachofthesetofacilitateamainscablethatcanbeloopedinandoutoftheunit.

4. Installershouldearth/groundtheunitseparately.

5. Connectwirestomainssupply;

Blue=Neutral

 Brown=Live

 Green/Yellow=Earth/Ground

6. Iftheunitisopenedforanyreason,disconnectmains.

For 24V version only – Must not be used on a Centre Tapped Earth Transformer

power supply

Additional important information

Note: Torque = Newton Metre (Nm)

7. All WARRIOR units have terminal blocks suitable for 4mm2 live, neutral and earth/

ground.

8. Wheninstallingtheunitthespecialconditionsforsafeuseshouldbeadheredto–

i. Exceptforinternalwiring,notmorethanonesingleormultiplestrandleadshallbe

connected into either side of any terminal, unless multiple conductors have been

joinedinasuitablemanner,e.g.twoconductorsintoasingleinsulatedcrimpedboot

lace ferrule.

ii. Leadsconnectedtotheterminalsshallbeinsulatedfortheappropriatevoltageand

thisinsulationshallextendtowithin1mmofthemetaloftheterminalthroat.

iii. Allterminalscrews,usedandunused,ontheWARRIORterminalblock(typeBkIECEx

SIR05.0035Uterminalblock)shallbetighteneddowntobetween0.5Nmand0.7Nm.

iv. The WARRIOR terminal hey shall only be installed and wired with cable within a

temperature range of -10°C to 80°C.

v. Whencross-connectingcombsareusedontheterminalstherelevantconditionsof

certicationIECExSIR05.0035UandIECExSIR05.0037Ushallbeapplied.

vi. Cableentryholesshallbettedwitheitheranappropriatelycertiedcableglandor

appropriatelycertiedblankingelement.Theseshallprovideandmaintainaminimum

enclosureingressprotectionofIP66orIP67asappropriate.

vii. IntheunlikelyeventofthefailureofanLED,theassemblymustbereplaced;contact

Raytecforassistance.

4. Technical Speciﬁcation

Input Voltage 100-254VAC

 24VAC/DCversionavailable

Consumption 60Wmax

Power Factor >0.95

Mains Frequency 50/60Hz

IP Rating 66/67

Weight 6kg

Dimensions 250x165x145mm

ATEX and IECEx Zone1&Zone2:

Rating II2GDExembII

Protection / Certiﬁcation

IECEx Cert.

ExembIICT4Gb

ExtIIICT103°C

DbIP66/67

Tamb-20°Cto+50°C

ATEX Cert.

II2GD

ExembIICT4Gb

ExtIIICT103°C

DbIP66/67

Ta=-20°Cto+50°C

WARRIOR Speciﬁcation

3. Maintenance

1. IsolatetheWARRIORunitfromthemainssupplyandallowtocoolbeforecarryingout

anymaintenancework.

2. IntheunlikelyeventofthefailureofanLED,theassemblymustbereplaced;contact

Raytecforassistance.

3. ItisessentialthatallWARRIORunitsaremaintainedinaccordancewiththerequirements

of the EN60079-17standard: (Electrical apparatus for explosive gas atmospheres –

otherthanmines).

4. IMPORTANT. No modications are permitted to the unit, all spare parts must be

purchased from the manufacturer, unauthorized modications or spare parts will

invalidate certiﬁcation.

5. ELECTROSTATIC CHARGING HAZARD-Plasticcomponentsmaybecleanedwith

watercontainingasmallamountofdetergent,followedbyacleanwaterwash.Surplus

watercanbewipedoffplasticcomponents,buttheyshouldnotbewipedorpolished

withadryclothtoavoidabuild-upofstaticelectricity.

6. Disposalofpackaging,WARRIORunitandoldLEDassembliesshouldbecarriedout

inaccordancewithnationalregulations.

PART CODES & DISTANCES

RLW-200-10 RAYLUXWarrior,10° White-Light 120m(394ft)

RLW-200-30 RAYLUXWarrior,30° White-Light 65m(213ft)

RLW-200-50 RAYLUXWarrior,50° White-Light 45m(184ft)

5.Troubleshooting

1. EnsurethetwoLEDboardsarecorrectlywiredtoterminalblock.

Red to Red : Black to Black

2. EnsureMainsinputiscorrectlyconnected.

Earth/Ground to Yellow/Green : Live to Brown : Neutral to Blue

3. EnsureMainsInputisturnedonatthesource

PART CODES & DISTANCES

RMW2-200-10 RAYMAXWarrior,10° 850nm 150m(492ft)

RMW2-200-30 RAYMAXWarrior,30° 850nm 80m(262ft)

RMW2-200-50 RAYMAXWarrior,50° 850nm 56m(184ft)

RAYMAX WARRIOR: Infra-Red

RAYLUX WARRIOR: White-Light

UK / Europe

T: +44 (0) 1670 520055

F: +44 (0) 1670 819760

sales@rayteccctv.com

Americas (Toll Free)

T: +1 888 505 8335

ussales@rayteccctv.com

www.rayteccctv.com

WII/11/10.1

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Equipo de iluminación de Raytec

Raytec

Raytec SPX SPARTAN Manual de usuario

Raytec

Raytec VARIO2 IP 16 Series Manual de usuario

Raytec

Raytec RAYMAX RM200 Manual de usuario

Raytec

Raytec VARIO2 series Manual de usuario

Raytec

Raytec VARIO2 w8 Manual de usuario

Raytec

Raytec SPARTAN Series Manual de usuario

Raytec

Raytec SPARTAN HP series Manual de usuario

Raytec

Raytec PULSESTAR VTR4 Manual de usuario

Raytec

Raytec PULSESTAR VTR Manual de usuario

Raytec

Raytec PULSESTAR VTR6 Manual de usuario

Raytec

Raytec VAR2 IPPOE i4-1 Manual de usuario

Raytec

Raytec vario2ip HYBRID Instrucciones de montaje

Raytec

Raytec VARIO2 VAR2-i2-2 Manual de usuario

Raytec

Raytec SPI WARRIOR Series Manual de usuario

Raytec

Raytec SPARTAN SPX Series Manual de usuario

Raytec

Raytec RL F 25 Manual de usuario

Raytec

Raytec WARRIOR Manual de usuario

Raytec

Raytec VARIO2 series Manual

Manuales populares de Equipo de iluminación de otras marcas

Brizo

Brizo 8SP-MU-4 Manual de usuario

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 Manual de usuario

IKEA

IKEA BJÖRKSPIREA Manual de usuario

Laserworld

Laserworld Evolution Series ES-400RGB Manual de usuario

Alien

Alien RG STAR Manual de usuario

EuroLite

EuroLite LED B-40 Manual de usuario

Qazqa

Qazqa Suplux SL 3 Black 103062 Manual de usuario

Commercial Electric

Commercial Electric 54568141 Manual de usuario

CREE LIGHTING

CREE LIGHTING 304 Series Manual de usuario

Goobay

Goobay 49867 Manual de usuario

ECOMAN ITALIA

ECOMAN ITALIA LED T8 Manual de usuario

Alkalite

Alkalite Krypton KT-81 Manual de usuario

Clas Ohlson

Clas Ohlson GU10 Manual de usuario

DTS

DTS DELTA 10 F Manual de usuario

ring

ring Solar Steplight Manual de usuario

One Stop Gardens

One Stop Gardens 57696 Instrucciones de montaje

Chauvet DJ

Chauvet DJ COREpar UV120 ILS Manual de usuario

SIREM

SIREM Swimeo A2 Manual de usuario