Prosilica GB660 Manual de usuario

Prosilica Inc. www.prosilica.com tel: 604.875.8855 fax: 604.875.8856

prosilica

USER MANUAL

December 14, 2009

GB660

GB660C

GB660-V

GB660C-V

GB660 User Manual 70-0045A-A

Prosilica Inc.

Table of Contents

Table of Contents............................................................................................................................ ii

Introduction.................................................................................................................................1

Precautions ..................................................................................................................................1

Warranty......................................................................................................................................1

Specifications ..............................................................................................................................2

Supported Features......................................................................................................................3

Mechanical ..................................................................................................................................4

Connections.................................................................................................................................7

Cleaning the Sensor...................................................................................................................11

Adjusting the C-mount..............................................................................................................12

Camera Installation....................................................................................................................13

System Optimization.................................................................................................................18

Trouble Shooting.......................................................................................................................20

Addendum......................................................................................................................................21

GB IO Schematic.......................................................................................................................22

Isolated Trigger Schematic........................................................................................................23

Non-isolated Trigger Schematic................................................................................................24

Video Iris Schematic.................................................................................................................25

Trigger Timing Diagram ...........................................................................................................26

Notes on Triggering...................................................................................................................27

GB660 User Manual 70-0045A-A

Prosilica Inc.

Introduction

The GB660 series of cameras are single board, 120 frames per second, VGA, Gigabit Ethernet

cameras based on the Sony ICX618ALA and ICX618AQA, EXview HAD CCD sensors.

Precautions

READ INSTALLATION GUIDE CAREFULLY.

This document contains specific information which is necessary for the correct operation and

treatment of this product.

USE ESD PRECAUTIONS WHEN HANDLING PRODUCT.

This camera contains sensitive components which can be damaged if handled incorrectly.

KEEP SHIPPING MATERIAL.

Poor packaging of this product can cause damage during shipping.

VERIFY ALL EXTERNAL CONNECTIONS.

Verify all external connections in terms of voltage levels, power requirements, voltage polarity,

and signal integrity prior to powering this device.

CLEANING.

This product can be damaged by some volatile cleaning agents. Avoid cleaning the image sensor

unless absolutely necessary. Please see instructions on sensor cleaning in this document.

DO NOT EXCEED ENVIRONMENTAL SPECIFICATIONS.

See environmental specifications limits in the Specifications section of this document.

Warranty

Please contact Prosilica.

GB660 User Manual 70-0045A-A

Prosilica Inc.

Specifications

Sensor Type

Sony ICX618ALA CCD (ICX618AQA for color)

Sensor Shutter Type

Progressive Interline

Image Resolution

659 x 494 pixels

Pixel Size

5.6μm x 5.6μm

Optical Format

1/4 inch

Lens Mount

C-mount with adjustable back focus (CS-mount available)

Color Sensor Filter Pattern†

Bayer

Full Resolution Frame Rate

119 fps

Frame Rate (320 x 240 ROI)

199 fps

I/O

1 isolated input/output, 1 non-isolated input/output,

1 RS-232 input/output

Power Requirements

Less than 3.0W†† (5V to 16V)†††

Digitization

12 Bits

Trigger latency*

2us for non-isolated I/O, 10us for isolated I/O

Trigger Jitter*

±20ns for non-isolated I/O, ±0.5us for isolated I/O

Tpd*

10ns for non-isolated I/O, 1.3us for isolated I/O

Operating Temperature

0 to 70 Celsius***

Operating Humidity

20 to 80% non-condensing

Weight

53g

Hardware Interface Standard

IEEE 802.3 1000BASE-T, 100BASE-TX

Software Interface Standard

GigE Vision Standard 1.0

Regulatory

RoHS

†Applies to GB660C only.

†† Power consumption will increase with reduced ROI imaging and color interpolation.

††† Nominal operating voltage is 12V. Cameras have been tested at 12V.

* See Notes on Triggering in the Addendum.

***DUE TO THE SMALL PACKAGING AND HIGH SPEED OF THE GB CAMERAS, SPECIAL

CARE IS REQUIRED TO MAINTAIN A REASONABLE OPERATING TEMPERATURE. IF THE

CAMERA IS TO BE OPERATED IN A WARM ENVIRONMENT, IT IS SUGGESTED THAT THE

CAMERA BE MOUNTED ON A HEAT SINK SUCH AS A METAL BRACKET AND THAT

THERE IS SUFFICIENT AIR FLOW.

GB660 User Manual 70-0045A-A

Prosilica Inc.

Supported Features

Imaging Modes

free-running, external trigger, fixed rate, software trigger

Fixed Rate Control

0.001 fps to maximum frame rate

External Trigger Delay

0 to 60 seconds in 1 microsecond increments

External Trigger Event

rising edge, falling edge, any edge, level high, level low

Exposure Time

10 microseconds to 60 seconds in 1 microsecond increments

Gain

0 to 34dB

Region of Interest (ROI)

independent x and y control with 1 pixel resolution

Horizontal Binning

1 to 8 pixels

Vertical Binning

1 to 16 rows

Pixel Formats

Mono8, Mono16*, Bayer8, Bayer 16, RGB24,

YUV411, YUV422, YUV444,

BGR24, RGBA24, BGRA24

Sync Out Modes

trigger ready, trigger input, exposing, readout, imaging, strobe, GPO

*On monochrome versions only.

GB660 User Manual 70-0045A-A

Prosilica Inc.

Mechanical

1.66 42.2

19.10.7569.92.75

16.50.65

0.65 16.5

1.78 45.2

INCHES[MILLIMETERS]

OPTIONS: LANDSCAPE/RIGHT ANGLE CONNECTORS

MODEL: GB660/GB660C

ITEM 2: HALO HFJ11-1G16E-L12RL

ITEM 1: 3M 10214-55G3PC

ITEM 3: SONY ICX618

0.62 15.70.37 9.4

0.93 23.6

1.16 29.5

0.19 4.8

0.37 9.4

2 PLCS TYP

M2.5x0.45

0.63 15.9

0.54 13.6

5.40.21

0.062 1.6

0.10 2.50.17 4.3

0.13 3.2

6 PLCS TYP

0.10 2.6

2 PLCS TYP

0.75 19.1

1 2

2.00 50.8

1.80 45.7

1.23 31.2

GB660 User Manual 70-0045A-A

Prosilica Inc.

1.78 45.2

2.55 64.7

0.65 16.5

69.92.75

16.50.6542.21.66

0.75 19.1

INCHES[MILLIMETERS]

ITEM 1: 3M 10214-6212PC

ITEM 2: HALO HFJV1-E1G16-L12RL

ITEM 3: SONY ICX618

OPTIONS: LANDSCAPE/VERTICAL CONNECTORS

MODEL: GB660-V/GB660C-V

45.71.80

9.1

1.23 31.2

0.93 23.6

1.16 29.5

0.63 16

2 PLCS TYP

M2.5x0.45

0.36

2.00 50.8

0.13 3.2

6 PLCS TYP

0.10 2.6

2 PLCS TYP

0.75 19.1

0.062 1.6

0.85 21.6

0.65 16.5

0.53 13.5

0.21 5.4

0.62 15.70.37 9.4

0.65 16.5

0.23 5.8

GB660 User Manual 70-0045A-A

Prosilica Inc.

INCHES[MILLIMETERS]*Nominal value. This dimension will vary

depending on CCD type.

ADJUSTABLE

C-MOUNT

0.29 7.4

0.45 11.4

0.65 16.5

0.84 *21.3

1.50 38.1

1.28 32.5

GB660 User Manual 70-0045A-A

Prosilica Inc.

Connections

Figure 1. GB SERIES connection diagram.

GB660 User Manual 70-0045A-A

Prosilica Inc.

Item 1: GIGABIT ETHERNET PORT

This port conforms to the IEEE 802.3 1000BASE-T standard for Gigabit Ethernet over copper.

It is recommended that CAT5E or CAT6 compatible cabling and connectors be used for best

performance. Cable lengths up to 100m are supported.

Item 2: General Purpose I/O PORT

PIN 1PIN 7

PIN 8

PIN 14

FUNCTION

12V POWER

GND POWER

Sync Input 1 - isolated

Isolated Ground

Sync Output 1 - isolated

Video Iris

DNC

12V POWER

GND POWER

RS-232 TXD

RS-232 RXD

Sync Input 2 –non-isolated

Sync Output 2 –non-isolated

Figure 2. General Purpose I/O Pin out. Camera

rear view.

GND SIGNAL

The General Purpose I/O port uses a 3M 10214-55G3PC (or 3M 10214-6212PC) connector on

the camera side. The mating cable connector is 3M 10114-3000PE with shielded housing 3M

10314-3210-00X (X indicates color preference). This connector can be purchased from Prosilica

or from http://www.digikey.com.

See Addendum for more detail.

DO NOT EXCEED 5.5V ON SIGNAL INPUTS UNLESS OTHERWISE

INDICATED. SYNC INPUT 1 CAN BE DRIVEN FROM A HIGHER VOLTAGE IF

A CURRENT LIMITING RESISTOR IS USED TO LIMIT THE CURRENT TO

LESS THAN 10 MILLIAMPS.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Manuales populares de Cámara IP de otras marcas

FLIR

FLIR Exx series Manual de usuario

Avigilon

Avigilon H4A-BO1-IR Manual de usuario

Digital Watchdog

Digital Watchdog DWCA-C128-64 Manual de usuario

ShareTech

ShareTech AV1 Manual de usuario

Ezviz

Ezviz C6C Manual de usuario

Melchioni

Melchioni UCAM 2015 Manual de usuario

Geutebruck

Geutebruck G-Cam/ESD-4630 Manual de usuario

Arecont Vision

Arecont Vision MegaBall AV3146DN-3310-D-LG Manual de usuario

Mitel

Mitel 6800i Series Manual de servicio

Vitek

Vitek VTC-IR403-212NP Manual de usuario

THOMSON

THOMSON DSC - 323W Manual de usuario

AVer

AVer FB2027 Manual de usuario

ENFORCER

ENFORCER EV-T5105-N2SQ Manual de usuario

Wansview

Wansview NC543 Manual de usuario

Eneo

Eneo MCB-64A0003M0A Manual de usuario

deView electronics

deView electronics CBDNI36F Manual de usuario

Swann

Swann SwannEye Manual de usuario

LevelOne

LevelOne IP CamSecure Manual de usuario