Projecta HDBC90 Manual de usuario

12/24V 70A MANUAL

P/No. HDBC90

WORKSHOP

BATTERY CHARGER

HDBC90 Instruction Manual.indd 1 4/06/12 3:02 PM

IMPORTANT SAFETY INFORMATION

Please read this manual thoroughly before use and store in a safe place for future reference.

WARNING

• Explosivegases.Preventflamesandsparks.Provideadequateventilationduringcharging.

•Beforecharging,readtheinstructions.

•Forindooruse.Donotexposetorain.

•ForchargingleadacidbatteriesONLY(ofthesize&voltagespecifiedinthe

specifications table).

•Alwayschargethebatteryonthecorrectvoltagesetting.Neversetthecharger

toahighervoltagethanthebattery.

•Disconnectthe240Vmainssupplybeforemakingorbreakingtheconnections

to the battery.

•Thebatterychargermustbepluggedintoanearthedsocket-outlet.

•ConnectiontosupplymainsistobeinaccordancewithNationalwiringrules.

•Donotattempttochargenon-rechargeablebatteries.

•Neverchargeafrozenbattery.

•IftheACcordisdamageddonotattempttouse.Itmustbereplacedorrepaired

byaqualifiedperson.

•Corrosivesubstancesmayescapefromthebatteryduringcharginganddamage

delicate surfaces. Store and charge in a suitable area.

•Ensureallvehicleaccessoriesincludinglights,heaters,appliancesetcareturnedoff

prior to charging.

•Thischargerisnotintendedforusebypersons(includingchildren)withreduced

physical,sensoryormentalcapabilities,orlackofexperienceandknowledge,unless

theyhavebeengivensupervisionorinstructionconcerninguseoftheapplianceby

a person responsible for their safety.

•Youngchildrenshouldbesupervisedtoensurethattheydonotplaywiththeappliance.

HDBC90 Instruction Manual.indd 2 4/06/12 3:02 PM

FEATURES

ENGINE START FUNCTION

 Startsvehicle’swithaflatbatteryafteracontrolled5minutecharge.

CHARGE METER

 ClearlydisplaystherateofchargeinAmpstoensureanaccurateandthoroughcharge.

ADJUSTABLE OUTPUT

 Adjusttherateofchargetobestsuitdifferentbatterysizes.

RAPID CHARGE

 Increaseschargerateforashortpowerfulcharge.

MULTI VOLTAGE OPERATION

 Suitableforcharging12V&24Vbatteries.

0–60MIN TIMER

 Automaticallyturnsthebatterychargeroffafterasettimewhenchargingyourbattery

inRapidChargemode.

POLARITY PROTECTION

 Fuseprotectionpreventsdamagetothechargerintheeventofreversepolarityand

short circuit.

HDBC90 Instruction Manual.indd 3 4/06/12 3:02 PM

SPECIFICATIONS

P/No. HDBC90

 TYPE Manual

 INPUT 240V,50Hz,2000W

 OUTPUT 9.0Aat12V(setting1) 11.0Aat24V(setting1)

 23.0Aat12V(setting2) 27.0Aat24V(setting2)

  60.0Aat12V(setting3) 60.0Aat24V(setting3)

 70.0Aat12V(rapidcharge) 70.0Aat24V(rapidcharge)

 ENGINESTART 3secon,2minoff

12V 24V

 360Aat6V 360Aat12V

 MINIMUMSTART 0.0V

VOLTAGE

 BACKDRAIN 12V 24V

 5.5mA 11.6mA

 APPROVALS ElectricalSafety,EMC

HDBC90 Instruction Manual.indd 4 4/06/12 3:02 PM

BATTERY CHARGER ASSEMBLY

 YourHDBC90isshippedwiththefollowingpartswhichrequireassemblytothemain

body of the battery charger unit:

•1xBatteryChargerHandle

•4x50mmScrews

•1xBottomStabiliserStop

•2x50mmSelfTappingScrews

•2xTrolleyWheels

•WheelAxle

•2xBlackVoltageTerminalCaps

•2x35mmWashers

•2xWheelLockingRings.

1.Placethemainbodyofthebatterychargerinanuprightposition,installthetophandle

ofthebatterychargerusingthe4x50mmscrewsasperthebelowillustration.Usea

Phillipsheadscrewdrivertotightenall4screws.

2.Laythemainbodyofthebatterychargerdownflatandfitthestabiliserstoptothe

bottomofthebatterychargerusingthe2x50mmselftappingscrewsprovided.Use

aPhillipsheadscrewdrivertotightenscrews.

3.Placethewheelaxleprovidedthroughthebottomofthebatterychargerasperthe

belowillustration.

4.Placethe2x35mmwashersoneither

endoftheaxle.

5.Fitthe2trolleywheelstoeitherendof

theaxleandsecurewiththe2xwheel

lockingring’sprovided.

6.Screwthe2xblackvoltageterminal

capsprovidedtoboththe12V&

24Voutletsonthetoppanelofthe

battery charger.

HDBC90 Instruction Manual.indd 5 4/06/12 3:02 PM

ASSEMBLING CHARGING LEADS TO BATTERY CLAMPS

 TheHDBC90batterychargerisshippedwiththebatteryclampsdisconnectedfromthe

positive&negativechargingleads.

IMPORTANT:

•Thenegative(Black)batteryclampmustbeconnectedtothecharginglead

connectedtotheunit.

•Thepositive(Red)batteryclampmustbeconnectedtothebarecopperend

ofthesecondchargingleadsupplied.Connecttheoppositeendofthecharging

leadtoeitherthe12Vor24Voutletonthetoppanelofthebatterycharger

viathecablelugontheendofthecharginglead.

 Toconnectboththepositiveandnegativeleadstothebatteryclampsreferto

instructionsbelow:

1.Slidetherubbercoveroffthebatteryclamphandle.

2.Loosentheboltlocatedontheoutsideofthebatteryclamphandleusinga10mmsocket.

3.Feedthebearcopperendofthebatteryclampleadthroughthebatteryclamphandle

andpositionunderneaththerectangularnutaspertheillustrationbelow.

4.Refit&tightenbolttocreatefirmconnection.

5.Slidetheplasticcoverbackoverthebatteryclamphandle.

HDBC90 Instruction Manual.indd 6 4/06/12 3:02 PM

CHARGING INSTRUCTIONS

STEP 1 – CHECK THE ELECTROLYTE LEVEL

 Priortochargingthebattery,removetheventcapsandchecktheelectrolytelevel.(Not

requiredonsealed&maintenancefreebatteries).Theelectrolyteshouldbe6mm(1/4”)

abovethebattery’splates.

 Iflow,topuptheelectrolytewithdistilledwatertothecorrectlevelandrefitthevent

caps.

STEP 2A – CONNECTION OUT OF VEHICLE

 ConnecttheREDlead(batteryclip)fromthechargertothePositive(+)batterypost.

 ConnecttheBLACKlead(batteryclip)fromthechargertotheNegative(-)batterypost.

 CONNECTIONOUTOFVEHICLE

STEP 2B – CONNECTION IN VEHICLE

 DetermineifthevehicleisPositively(+)orNegatively(-)earthed.Negativelyearthed

vehicleshaveacable(usuallyblack)fromtheNegativebatteryterminaltothevehicle’s

chassis.

NEGATIVELY EARTHED (MOST VEHICLES)

 ConnecttheREDlead(batteryclip)fromthechargertothePositive(+)batteryterminal.

 ConnecttheBLACKlead(batteryclip)fromthechargertothevehicle’schassisaway

fromthefuellineormovingparts.

 CONNECTIONINVEHICLE(NEGATIVELYEARTHED)

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

HDBC90 Instruction Manual.indd 7 4/06/12 3:02 PM

POSITIVELY EARTHED

 ConnecttheBLACKlead(batteryclip)fromthechargertotheNegative(-)batteryterminal.

 ConnecttheREDlead(batteryclip)fromthechargertothevehicle’schassisawayfromthe

fuellineormovingparts.

 CONNECTIONINVEHICLE(POSITIVELYEARTHED)

STEP 3 – CONNECT TO 240V MAINS POWER

 Ensure‘CHARGERATE’dialisturnedtoOFF&connectthebatterychargerto240V

mainspower.

STEP 4 – SET BATTERY VOLTAGE

 Setthevoltageofthebatterychargerbyremovingtheblackterminalcapfromeitherthe

12Vor24Vterminalonthetoppanelofthejumpstarter.Connectthepositivebattery

cableviatheringterminaltotheappropriate12Vor24Voutlet.Ensurethebatterycharger

voltageissettothesamevoltageasthebatterybeingcharged.

STEP 5 – SET THE CHARGE MODE

NORMAL CHARGE RATE ADJUSTMENT

 Thenormalchargeratecanbeadjustedbyturningthe‘CHARGERATE’dialonthetop

paneloftheunittosetting1,2or3.Thechargerateshouldbesetaccordingtothesize

of the battery.

 Seetherecommendedchargeratesforvariousbatterysizesinthetablebelow:

 CHARGERATE  BATTERYSIZE

  DeepCycle(Ah) Automotive(CCA) Marine(MCA) Time(Hours)

 Setting1(12V) 60–180 380–1080 520–1500 7–24

 Setting1(24V) 75–220 460–1300 640–1830 7–24

 Setting2(12V) 160–460 670–2800 1340–3800 7–24

 Setting2(24V) 190–540 1130–3240 1600–4500 7–24

 Setting3(12/24V) 420–1200 2500–7200 3500–1000 7–24

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

12/24 VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

12/24VOLT 70 AMP BATTERY CHARGER WITH ENGINE START

WORKSHOP 7000

FUSE2x 100A

POWERON

12V

24V

HDBC90 Instruction Manual.indd 8 4/06/12 3:02 PM

RAPID CHARGE

 Turnthe‘CHARGERATE’dialonthetoppaneloftheunitto‘RAPIDCHARGE’&setthe

timerbetween0-60min.TheRapidChargefunctionwillprovidea70Achargetoyour

batteryidealforwhenashortpowerfulchargeisrequired.

STEP 6 – CHARGING

 Duringcharging,theChargeMeter’sneedlewilldecrease

towardstheleft.Afullychargedbatteryisindicatedbyavery

lowreadingaccordingtothebattery’scapacityandcondition.

 Oncethispointhasbeenreached,proceedtodisconnectthe

battery(ReferSTEP7“DISCONNECTION”).

 Important:

 ChargingwillcontinueuntiltheOn/OffswitchisturnedtoOFF.

 Thebatteryandchargermustbemonitoredtoensurethebatteryisnotovercharged.

 Oncecharged,theliquidinsidethebatterymaystarttoboil.Itisrecommendedtostop

chargingwhenthisoccurstopreventdamagetothebattery.

STEP 7 – DISCONNECTION

 Turnthe‘CHARGERATE’dialtothe‘OFF’positionanddisconnectchargerfrom

the240Vsupply.

 Batteryoutofvehicle

 RemovetheBLACKlead(batteryclip)fromthebattery.RemovetheREDlead(battery

clip) from the battery.

 Batteryinvehicle

 Removethechassisconnection.Removethebatteryterminalconnection.

ChargeMeter

HDBC90 Instruction Manual.indd 9 4/06/12 3:02 PM

ENGINE START FUNCTION

STEP 1 TO 4 – FollowSTEPS1to4ofthecharginginstructionsofthisbooklet.

STEP 5 – Turnthe‘CHARGERATE’dialtothe‘RAPIDCHARGE’function,andsetthe

‘TIMER’dialto5minutesandallowchargertochargethevehiclesbattery.

STEP 6 – Oncethe5minuteRapidChargeiscomplete,turnthe‘CHARGERATE’

dialto‘ENGINESTART’.

STEP 7 – Turnthevehicle’signitionkeytostarttheengine.

STEP 8 – Ifenginefailstostartafter3secondsrepeatinstructionSTEP5&6before

attempting to start the engine again.

NOTE:Donotrepeatthisoperationmorethan5times.

NOTE:WheninenginestartmodetheHDBC90usesincreasedpowerforashortperiod

oftime.Ensureotherappliancesconnectedtothatpowercircuitareturnedofftoavoid

fuseorcircuitbreakeroverloadinthebuildingsswitchboard.

HDBC90 Instruction Manual.indd 10 4/06/12 3:02 PM

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Cargador de baterías de Projecta

Projecta

Projecta IC100L Manual de usuario

Projecta

Projecta PMDCS30 Manual de usuario

Projecta

Projecta INTELLI JAY PM100-BTJ Manual de usuario

Projecta

Projecta IM120 Manual de usuario

Projecta

Projecta AC040 Manual de usuario

Projecta

Projecta IC700 Manual de usuario

Projecta

Projecta IC2500L Manual de usuario

Projecta

Projecta IDC25 Manual de usuario

Projecta

Projecta INVCHR2 Manual de usuario

Projecta

Projecta HDBC20 Manual de usuario

Projecta

Projecta INTELLI-CHARGE IC7 Manual de usuario

Projecta

Projecta IC2500 Manual de usuario

Projecta

Projecta DC20 Manual de usuario

Projecta

Projecta INTELLI-RV PM300 Manual de usuario

Projecta

Projecta INTELLI-CHARGE IC25 Manual de usuario

Projecta

Projecta Charge N' Maintain Manual de usuario

Projecta

Projecta WORKSHOP HDBC21 Manual de usuario

Projecta

Projecta IDC25X Manual de usuario

Projecta

Projecta INTELLI-RV PM200 Manual de usuario

Projecta

Projecta IDC45 Manual de usuario

Projecta

Projecta INTELLI-CHARGE DC/SOLAR BATTERY CHARGER... Manual de usuario

Projecta

Projecta HDBM4000 Manual de usuario

Projecta

Projecta AC150 Manual de usuario

Projecta

Projecta IC1500L Manual de usuario

Manuales populares de Cargador de baterías de otras marcas

AA Portable Power Corp

AA Portable Power Corp Universal Smart Charger Manual de usuario

Enelion

Enelion Vertica Manual de usuario

RCA

RCA CHU6 Manual de usuario

ANSMANN

ANSMANN ALCT 6/24-10 Manual de usuario

Hitachi

Hitachi UC 18YRSL Guía de solución de problemas

Olympus

Olympus B-20 LPC Manual de usuario

Exibel

Exibel ZH1708143 Manual de usuario

Lenmar

Lenmar Mach 1 Manual de usuario

CTEK

CTEK MXS 5.0 Manual de usuario

ABB

ABB HT842379 Manual de usuario

Nitecore

Nitecore Superb Charger SC4 Manual de usuario

Renogy

Renogy RBC2125DS-21W Manual de usuario

Braun

Braun BWC02M Manual de usuario

CTEK

CTEK MXS 3.6 Manual de usuario

Black & Decker

Black & Decker BDV090 Manual de usuario

Trinity

Trinity DPD Manual de usuario

Hulkman

Hulkman Sigma 1 Manual de usuario

IKEA

IKEA koppla Manual de usuario