Philips MCM330 Manual de usuario

Version 1.1

MCM330

3141 785 33951

Micro Hi-Fi System

-/12

Published by LX 0915 Service Audio Subject to modification

system or transmitted, in any form or by any means, electronic, mechanical, photocopying,

or otherwise without the prior permission of Philips.

CONTENTS

�

Technical specification ..................................................................1-2

Version variation............................................................................1-2

Service measurement setup..........................................................1-3

Service aids .................................................................................1-4

Instructions on CD playability ...............................................2-1.. 2-2

Block diagram................................................................................3-1

Wiring diagram ..............................................................................4-1

Disassembly diagram............ ........................................................5-1

Power board

Circuit diagram ..................................................................6-1..6-3

Layout diagram..................................................................6-4..6-5

CD board

Circuit diagram .........................................................................7-1

Layout diagram..................................................................7-2..7-3

Display board

Circuit diagram .........................................................................8-1

Layout diagram..................................................................8-2..8-3

MCU board

Circuit diagram .........................................................................9-1

Layout diagram..................................................................9-2..9-3

Key board

Circuit diagram .......................................................................10-1

Layout diagram.......................................................................10-2

Exploded view diagram ............................................................... 11-1

Mechanical parts list.................................................................... 11-2

Electrical parts list...............................................................12-1..12-2

Disc

Laser type Semiconductor

Disc diameter 12cm/8cm

Support disc CD-DA, CD-R, CD-RW,

MP3-CD, WMA-CD

Audio DAC 24Bits / 44.1kHz

Total harmonic

distortion

<1.5%

Frequency

response

60Hz -16kHz (44.1kHz)

Signal to noise ratio >75dBA

Tuner

Tuning range FM: 87.5 - 108MHz

Tuning grid 50KHz

Number of presets 20 FM

Speakers

Speaker Driver 3.5”woofer+0.8” tweeter

Sensitivity >82dB/m/W

General information

AC power (power

adaptor)

Input: 100-240V~,

50/60Hz, 1.5A Max.;

Output: 18V

2.5A; Brand name:

Philips; Model: OH-

1048B1802500U-VDE

Operation Power

Consumption

20W

Standby Power

Consumption

<2W

Eco Power Standby

Power Consumption

<1W

USB Direct Version 2.0/1.1

Dimensions

- Main Unit

(W x H x D)

571 x143 x 91mm

Weight

- Main Unit 1.91 kg

Amplifier

Total output power 2X10W RMS

(with Living Sound off)

4 x 6W RMS

(with Living Sound on)

Frequency

response

125Hz - 16kHz, ±3dB

Signal to noise ratio >65dB

MP3 link input 0.5 V RMS 20kohm

TECHNICAL SPECIFICATION

1 - 2

Type /Versions:

Features

Board in used:

MCM330

Service policy

DISPLAY BOARD

* TIPS : C -- Component Lever Repair.

M -- Module Lever Repair

√-- Used

/05 /12 /55 89/16/85/

Feature diffrence

RDS & DAB

VOLTAGE SELECTOR

ECO STANDBY - DARK √

Type /Versions:

/05 /12 /55 89/16/85/

VERSION VARIATION

39/

√

CD BOARD

KEY BOARD

POWER BOARD

USB & SD CARD BOARD

MCU BOARD

MCM330

1-3

LF Generator

e.g. PM5110

Recorder

Use Universal Test Cassette CrO2 SBC419 4822 397 30069

LEVEL METER

e.g. Sennheiser UPM550

with FF-filter

S/N and distortion met

e.g. Sound Technology ST170

DUT

or Universal Test Cassette Fe SBC420 4822 397 30071

LEVEL METER

e.g. Sennheiser UPM550

with FF

filter

S/N and distortion meter

e.g. Sound Technology ST1700B

DUT

Use Audio Signal Disc

(replaces test disc 3)

SBC429 4822 397 30184

Bandpass

250Hz-15kHz

e.g. 7122 707 48001

LF Voltmeter

e.g. PM2534

DUT

S/N and distortion meter

e.g. Sound Technology ST1700B

Frame aerial

e.g. 7122 707 89001

Tuner AM (MW,LW)

To avoid atmospheric interference all AM-measurements have to be carried out in a Faraday´s cage.

Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).

RF Generator

e.g. PM5326

Ri=50:

Bandpass

250Hz-15kHz

e.g. 7122 707 48001

LF Voltmeter

e.g. PM2534

DUT

RF Generator

e.g. PM5326

S/N and distortion meter

e.g. Sound Technology ST1700B

Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).

Ri=50:

Tuner FM

MEASUREMENT SETUP

1-4

SERVICE AIDS

GB WARNING

All ICs and many other semi-conductors are

susceptible to electrostatic discharges (ESD).

Careless handling during repair can reduce life

drastically.

When repairing, make sure that you are

connected with the same potential as the mass

of the set via a wrist wrap with resistance.

Keep components and tools also at this

potential.

ESD

CLASS 1

LASER PRODUCT

Safety regulations require that the set be restored to its original

condition and that parts which are identical with those specified,

be used

Safety components are marked by the symbol !.

Lead free

Set remains closed!

Play a CD

for at least 10 minutes

playability

ok ?

playability

ok ?

add Info for customer

"SET OK"

check playability

playability

ok ?

check playability

return set

Customer complaint

"CD related problem"

"fast" lens cleaning

3For flap loaders (= access to CD drive possible)

cleaning method 4is recommended

INSTRUCTIONS ON CD PLAYABILITY

2 - 1

Exchange CDM

1-4For description - see following pages

PLAYABILITY CHECK

For sets which are compatible with CD-RW discs

use CD-RW Printed Audio Disc ....................7104 099 96611

TR 3 (Fingerprint)

TR 8 (600µ Black dot) maximum at 01:00

• playback of these two tracks without audible disturbance

playing time for: Fingerprint 10seconds

Black dot from 00:50 to 01:10

• jump forward/backward (search) within a reasonable time

For all other sets

use CD-DA SBC 444A..................................4822 397 30245

TR 14 (600µ Black dot) maximum at 01:15

TR 19 (Fingerprint)

TR 10 (1000µ wedge)

• playback of all these tracks without audible disturbance

playing time for: 1000µ wedge 10seconds

Fingerprint 10seconds

Black dot from 01:05 to 01:25

• jump forward/backward (search) within a reasonable time

CUSTOMER INFORMATION

It is proposed to add an addendum sheet to the set which

informs the customer that the set has been checked

carefully - but no fault was found.

The problem was obviously caused by a scratched, dirty or

copy-protected CD. In case problems remain, the customer

is requested to contact the workshop directly.

The lens cleaning (method 3) should be mentioned in the

addendum sheet.

The final wording in national language as well as the printing

is under responsibility of the Regional Service Organizations.

LIQUID LENS CLEANING

Because the material of the lens is synthetic and coated

with a special anti-reflectivity layer, cleaning must be done

with a non-aggressive cleaning fluid. It is advised to use

“Cleaning Solvent

The actuator is a very precise mechanical component and

may not be damaged in order to guarantee its full function.

Clean the lens gently (don’t press too hard) with a soft and

clean cotton bud moistened with the special lens cleaner.

The direction of cleaning must be in the way as indicated in

the picture below.

Before touching the lens it is advised to clean the

surface of the lens by blowing clean air over it.

This to avoid that little particles make scratches on

the lens.

INSTRUCTIONS ON CD PLAYABILITY

2 - 2

SET BLOCK DIAGRAM

PICK-UP MECHA

SANYO : DA23Z1

4 CH

MOTOR DRIVER

(BA5826)

ROHM

RF AMP+SSP+DSP

(BU9543)

MCS LOGIC BX8804

MP3/WMA D/E + MCU +USB

SOUND CONTROL

SW+VOL+EQ

(PT2314)

POWER AMP

( TDA8932 )

( 2x10W )

AUX INTPUT

DISPLAY

VFD

SD/USB Device

NOR FLASH

SST39VF400A

SDRAM

16Mbit

TUNER(FM+RDS)

( Si4703 )

VFD DRIVER

PT6324

VFD VOLTAGE

Circuit

KEY Function

LIVING SOUND

( TL072 )

LIVING SOUND

POWER AMP

( TDA8932 )

(2X6W )

AC ADAPTER

CD PCB

KEY PCB

USB PCB

MCU PCB

POWER PCB

DISPLAY(VFD) PCB USB PCB

3-1

POWER BOARD

SPK L

SPK R

MCU BOARD

KEY BOARD

VFD BOARD

CN4

CN8

CN6

CON3

CON4

CON6

CN1 CN2 J204

J205 CN1

CN01

USB/SD CARD BOARD

CD BOARD

CDM CONNECT BOARD

DC JACK BOARD

CM3

CN602

CN807

CN804

CM1

CN5

CN401

CON3

CM2

MOTOR SWITCH BOARD

IR BOARD

CN806

CN402

CN4

CON1

SET WIRING DIAGRAM

4-1

5-1 5-1

DISASSEMBLY DIAGRAM

Dismantling of the Rear Cabinet

Dismantling of the PCB Board and CD part

1)Remove 8 screw rubbers.

2)Remove 8 screws A as indicated.

3)Open the CD door.

4)Remove 2 screws B as indicated to loosen the rear cabinet.

BFRONT CAB.

REAR CAB.

CD PART

1)Remove 3 screws C as indicated to loosen the Key Board and USB/SD jack Board.

2)Remove 5 screws D as indicated to loosen the Power Board.

3)Remove 2 screws E as indicated to loosen the DC jack Board.

4)Remove 4 scre ws F as indicated to loosen th e CD Board.

5)Remove 6 scre ws G as indicated to loosen th e CD mechanism

CIRCUIT DIAGRAM - POWER BOARD

PART1

6-1 6-1

Otros manuales para MCM330

Tabla de contenidos

Otros manuales de Sistema estéreo de Philips

Philips

Philips MCM726/12 Manual de usuario

Philips

Philips BTD5210 Hoja de información del producto

Philips

Philips FWM400D/05 Manual de usuario

Philips

Philips FWD876/98 Manual de funcionamiento

Philips

Philips MCM390/22 Manual de usuario

Philips

Philips DS9800W/93 Manual de usuario

Philips

Philips FWM139 Manual de usuario

Philips

Philips DCM3065 Manual de usuario

Philips

Philips MCM108B/93 Manual de usuario

Philips

Philips MCD759D Manual de usuario

Philips

Philips FWM352 Manual de usuario

Philips

Philips FW-P750/34 Manual de usuario

Philips

Philips BTM2310 Manual de usuario

Philips

Philips FWD182/98 Manual de funcionamiento

Philips

Philips FWD16 series Manual de usuario

Philips

Philips FX20/55 Manual de usuario

Philips

Philips MCM330/12 Manual de usuario

Philips

Philips MC-500 Manual de usuario

Philips

Philips BTM2180 Hoja de información del producto

Philips

Philips MCM2050 Manual de usuario

Philips

Philips MCM108B Manual de usuario

Philips

Philips FWP3200D/12 Manual de usuario

Philips

Philips FW-C280 Manual de usuario

Philips

Philips Magnavox FW 340C Instrucciones de montaje

Manuales populares de Sistema estéreo de otras marcas

LG CM3330B Manual de usuario

Sony

Sony SS-CEP50 Manual de usuario

Cetacea Sound

Cetacea Sound CVS-II Manual de usuario

Aiwa

Aiwa XR-H66MD Manual de usuario

Denon

Denon UCD-250 Manual de usuario

Sanyo

Sanyo DC-MX41i Manual de usuario

Sharp

Sharp CD-ES600V Manual de usuario

Exibel

Exibel BDX600-UK Manual de usuario

Sanyo

Sanyo DC-F320 Manual de usuario

Sharp

Sharp CD-C462 Manual de usuario

Onkyo

Onkyo CBX 300 - CD / MP3 Clock Radio Manual de usuario

Aiwa

Aiwa XR-EM70 Manual de usuario

Cyrus

Cyrus Lyric Manual de usuario

Philips/Magnavox

Philips/Magnavox Magnavox FW 62C Manual de usuario

RCA

RCA RS3965SB Manual de usuario

Sharp

Sharp XL-UH240 Manual de usuario

LG FB165DAB Manual de usuario

Sanyo

Sanyo DC-UB1475M/XE/UK Manual de usuario