Philips DVDR520H/00 Manual de usuario
Service Manual
Service
Service
Service
Service
Service
DVDR520H/00/02/04/05/37/69/75/93/97
©Copyright 2004 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise
without the prior permission of Philips.
Published by LO-MF AV System Printed in The Netherlands Subject to modification
GB
3139 785 30853
HDD / DVD Recorder Combi
Version 1.3
CONTENTS
1. Specifications ..............................................................................................1-1
2. Product Validation Strategies and Process
2.1 System Block Diagram ........................................................................2-1
2.3 Front Panel ..........................................................................................2-2
2.4 Rear Panel...........................................................................................2-2
3. Fault Finding Tree & Trouble shooting ........................................................3-1
4 Disassembly Instructions
5.1 Disassemble the Top Cover .................................................................3-1
5.1 Disassemble the Drive .........................................................................3-1
5.1 Disassemble the HDD .........................................................................3-1
5.1 Disassemble the M/B ...........................................................................3-1
5.1 Disassemble the Power Module ..........................................................3-1
5.1 Disassemble the Tuner ........................................................................ 3-1
5.1 Jumper Setting.....................................................................................3-1
5. Firmware Update ........................................................................................5-1
6. Exploded View & Spare parts list
Exploded view for /37/97 .............................................................................6-1
Exploded view for /00/02/04/05/69/75 ......................................................... 6-2
DVD Test disc & Service parts list ...............................................................6-3
7. Revision List................................................................................................ 7-1
1-1
1. Specifications
2-1
2. Product Validation Strategies and Process
2.1. System Block Diagram
FAN
HDD
Power
Module
DVD
M/BTuner
2-2
2.2.Front Panel
2.3. Rear Panel
3-1
3.Fault Finding Tree
Front panel display?
Y
N
Power cord
plug?
N
Plug the power
cord
Display
Normal?
N
Replace front
display board
Y
Press “EJECT”buttom
to verify if the player
boot up and also tray
come out ?
N
Replace
drive
Y
Open top cover and
use “multimeter” to
verify if the power
module output both
5V&12V
Y
Replace front
display board
Y
Put a movie disc
and press the “play”
to verify if AV output
corret?
Replace M/B
N
Y
N Replace power
module
Y
N
Replace HDD NPF
Use the “Erase”
function of the “disc
tool “ to verify if the
HDD work normal?
Start condition:
1. Plug the power cord
2. Power on
3-2
Recording
Press Record
button to start
di
Select Target to
HDD/DVD OK
Y
N
Select Source view
and display OK
N
Show “Protected
Content”
N
Show “Wrong
Signal Type”
AV Sources video is
black&white or
if
Check if TV system
of input device is
different
Source DVD is not
allowed to
Y
Recording disc was
formatted when
iff
Y
N
Show “Write Fail” Bad write quality
on this disc
Y
N
Select DV but no
video
Gray screen-check
Connection
N
Select AV sources
but no
i i
Check
connection
Y
Y
Y
Start condition:
1. Plug the power cord
2. Power on
3-3
DVD Playback
Auto-play DVD
VCD SVCD and
Media Disc
Load supported
disc DVD+-R/RW,
CD-R
Y
Select Target DVD,
eject
Not supported
format
Show “Preparing”
then start
pre-format for
Blank disc
Invalid disc or
Data disc
N
N
Y
Y
Y
Start condition:
1. Plug the power cord
2. Power on
3-4
Tuner :
Select the source into TV mode first
TV signal
on screen ?
N
N
Check if Audio
/Video output
properly when
DVD playback ?
AV output
issue
Y
N
Replace Tuner
Board
Y
N
Display normally ?
Can scan
All channel?
Can Fine tune
Channel?
No problem found
Replace Tuner
Board
Replace Tuner
Board
N N
Y
Y
Y
Y
Check if the
Audio output
properly ?
3-5
Reference of defect symptoms for repair
• After power cord plug in ,LED no display , but AV output normal after power
on -> replace display board
• After power on , the color of the screen isn’t correct -> replace M/B
• After power on , the fan doesn’t work -> replace power module / Fan
• Can’t eject or show “No Disc” -> replace drive
• Can’t auto format any brand new disc -> replace drive
• Recording will auto stop or hang -> replace M/B & drive
• Playback will have mosaic -> replace M/B
• Can’t format HDD -> replace HDD
• Can’t record with HDD -> replace HDD
• No Audio or audio output abnormal -> replace M/B
• Optical / Coaxial no output when the setting is set as DTS output -> replace
M/B
• Can’t update F/W through drive -> replace drive
• Can’t detect DV when plug in/out with a DV -> replace display board
• AV1 input mode doesn’t output video / audio when connected to a normal
external AV source -> replace display board
• AV2 ( Scart) / S-Video input mode doesn’t output video / audio when
connected to a normal external AV source -> replace M/B
Este manual sirve para los siguientes modelos
8
Tabla de contenidos
Otros manuales de Grabadora de DVD de Philips
Philips
Philips DVDR80/051 Manual de usuario
Philips
Philips DVDR3350H Manual de usuario
Philips
Philips DVDR1000 MkII Manual de usuario
Philips
Philips DVDR3575H/ Manual de usuario
Philips
Philips DVDR5590H/75 Manual de usuario
Philips
Philips DVDR7250H/05 Manual de usuario
Philips
Philips DVDR80 Manual de usuario
Philips
Philips DVDR520H Manual de usuario
Philips
Philips DVDR520H Manual de usuario
Philips
Philips DVDR 725H/05 Manual de usuario
Philips
Philips DVDR616 Manual de usuario
Philips
Philips HDRW720/00 Manual de usuario
Philips
Philips VideoPlus DVDR75 Manual de usuario
Philips
Philips ShowView DVDR3450H Manual de usuario
Philips
Philips ARV663 Manual de funcionamiento
Philips
Philips DVDR3355 Manual de usuario
Philips
Philips DVDR5520H Manual de usuario
Philips
Philips DVDR3576H Manual de usuario
Philips
Philips DVDR615/37B Manual de usuario
Philips
Philips DVDR3435H/93 Manual de usuario
