Pentair SHURFLO Manual de usuario

WATER PURFICATION 911-585 REV. E 1

SHURFLO® LO-FLO 105 SERIES RV PUMPS

INSTALLATION MANUAL

SHURFLO Lo-Flo 105 Series RV pumps are rugged, lightweight, compact and provide the ability to self-prime and run dry.

Standard features include a pressure demand switch, built in 3/8” hose barb ports, ﬂexible mounting feet, splash proof motor,

and thermal protector. All with the security that comes with a UL Recognized Component.

INSTALLATION

SHURFLO Lo-Flo 105 Series RV pumps are self-priming and can be located up to 2.5

feet above the water level. Horizontal and vertical prime vary depending on the ﬂuid

viscosity and pump conﬁguration. The pump can be at the same level or below the

tank.

❚ The pump should be located in an area that is dry and properly ventilated to pre-

vent heat build-up.

❚ Use 50-mesh strainer minimum at the inlet side of the pump. Use ﬂexible hose on

inlet.

❚ The pump can be mounted in any position. However, if mounting the pump verti-

cally the pump head should be in the down position so that in the event of a leak,

ﬂuid will not enter the motor.

❚ 12 Volt pump must be provided with a 5-amp fuse.

❚ Recommended wire size is 16 gauge (1.3 mm) or larger wire as determined by volt-

age drop. Negative (-) must be connected to a known ground. Ground wire must be

the same (gauge/mm) as the positive.

TROUBLESHOOTING

PUMP WILL NOT START

√ For correct voltage (+10%) and

electrical connections

√ Fuse or breaker

√ Pressure switch operation and

correct voltage at switch

√ Rectiﬁer or motor for open or

grounded circuit

√ For locked drive assembly

PUMP WILL NOT PRIME

(No Discharge/Motor Runs)

√ Strainer for debris

√ Inlet/Outlet tube severely restricted

(kinked)

√ Inlet /Outlet valves for debris or

swelling

PUMP WILL NOT SHUT-OFF

√ Output line closed and no leaks

√ For air trapped in outlet line or

pump head

√ For correct voltage to pump

√ Debris in pump Inlet/Outlet valves

√ For loose drive assembly or pump

head screws

√ Pressure switch operation/adjust-

ment

LEAKS FROM PUMP HEAD OR SWITCH

√ For loose screws at switch or pump

head

√ Switch diaphragm ruptured or

pinched

√ For punctured diaphragm if ﬂuid is

present at drain holes

To Faucet

City Water

Check Valve

Alternate Plumbing

for City Water Entry

From Pump

“T” Fitting

RED(+)

PUM P

SWITCH

BLACK(-)

FUSE BATTERY

50 Mesh Strainer Required if using SHURFLO P/N 170-06X-00

A 1/2” to 3/8” Barb splicer is required.

Water Tank

Plumbing Systems can vary.

Consult SHURFLO for detailed

information.

WATER PURIFICATION

3545 HARBOR GATEWAY SOUTH, SUITE 103, COSTA MESA, CA 92626, (800) 854-3218 WWW.SHURFLO.COM

All Pentair trademarks and logos are owned by Pentair, Inc. All other brand or product names are trademarks or registered marks of their respective owners.

Because we are continuously improving our products and services, Pentair reserves the right to change speciﬁcations without prior notice.

Pentair is an equal opportunity employer.

PRODUCT SPECIFICATIONS

Model Number: 105 Series

Pump Design: Positive Displacement Pump

Motor: Placement Magnet, 11-262-00

Voltage: 12 VDC

Pressure Switch: Factory Set: 30 PSI Shut-off, Turn-on 25+/- 5 PSI

Liquid Temperature: 100° Max F [43° C]

Prime: Self Priming up to 2.5 ft. vertical

Ports: 3/8" Barb

Net Weight: 1.27 lbs.

Duty Cycle: Intermittnet

Max Amps: 105-003, 2.5 Amps @ 30 PSI

MATERIALS OF CONSTRUCTION

Motor Housing: Nylon

Plastic: Polypropylene

Valves: EPDM

Diaphragm: Santoprene

Fasteners: Zinc Plated /

Stainess Steel

#10 Screw Mounting Hole

3/8” Hose Barb Port

Pressure Switch

18 AWG Red Positive

18 AWG Black Negative

5.01.70”1.55”3.94”

2.45”

1.87”

2.25”

3.20”

6.82”

FLOW: GPM [LPM]

0.30

[1.14]

0.65

[2.46]

1.00

[3.79]

[2.1]

[1.4]

[0.7]

PRESSURE: PSI [BAR]

Tabla de contenidos

Otros manuales de Bomba de agua de Pentair

Pentair

Pentair Hydromatic SP40 Series Suplemento

Pentair

Pentair MYERS WHR5H Series Manual de usuario

Pentair

Pentair HPD200 Manual

Pentair

Pentair Shurflo 358 Manual de usuario

Pentair

Pentair HYPRO 1532C-6ESP-03 Manual de usuario

Pentair

Pentair PCD-1000 Manual de usuario

Pentair

Pentair MYERS B12-3036 Manual

Pentair

Pentair PANTERA ECO Manual de usuario

Pentair

Pentair Myers MSP4 Manual

Pentair

Pentair ME40T20-R Manual de usuario

Pentair

Pentair MYERS MES106 Manual de usuario

Pentair

Pentair HYDROMATIC HYDR-O-RAIL SYSTEM Manual

Pentair

Pentair Sta-Rite SCM 4 PLUS Series Manual de usuario

Pentair

Pentair AURORA 3801 Instrucciones de funcionamiento

Pentair

Pentair NOCCHI BIOX Series Manual de usuario

Pentair

Pentair Myers Aplex MA-155L Manual

Pentair

Pentair FAIRBANKS NIJHUIS 5410 Manual de usuario

Pentair

Pentair Myers MVPH-100 Manual de usuario

Pentair

Pentair IntelliFlo Manual de usuario

Pentair

Pentair Hypro Series Guía del usuario

Pentair

Pentair MYERS C40-20 Manual

Pentair

Pentair Lincoln E Series Manual de usuario

Pentair

Pentair STA-RITE DOMINATOR Manual de usuario

Pentair

Pentair Myers VH30 Manual

Manuales populares de Bomba de agua de otras marcas

Neptun

Neptun NPHW 5500 Manual de usuario

Sensidyne

Sensidyne Gilian BDX-II Instrucciones de instalación y funcionamiento

Draper

Draper 47808 Manual de usuario

Trolla

Trolla 12820 Manual de usuario

Sunfab

Sunfab SVH Series Manual de usuario

WilTec

WilTec 50740 Manual de usuario

Fieldmann

Fieldmann FVC 5015 EK Manual de usuario

Everbilt

Everbilt EFSUB5-122HD Manual de usuario

Graco

Graco Husky 3300e Manual de usuario

esotec

esotec 101018 Manual de usuario

moyno

moyno 2000 CC Manual de usuario

Becker

Becker BASIC VASF 2.80/1-0.AC230 Manual de usuario

Sykes AmeriPumps

Sykes AmeriPumps GP100M Guía de solución de problemas

DUROMAX

DUROMAX XP WX Series Manual de usuario

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Manual de usuario

Franklin Electric

Franklin Electric IPS Manual de usuario

Xylem

Xylem e-1532 Series Manual de usuario

Milton Roy

Milton Roy PRIMEROYAL Manual de usuario