ORTAL Circle 70 Manual de usuario

YOUR LIFE.

YOUR FIRE.

Ortal Curved & Islands Fireplaces User’s Manual

[USA Fireplace Models

[

THIS ISTALLATION MANUAL INCLUDES ASSEMBLY INSTRUCTIONS

FOR THESE MODELS:

STAND ALONE 7565 CURVED TUNNEL –DOUBLE GLASS

STAND ALONE 7565 CURVED –DOUBLE GLASS

ISLAND 130 –DOUBLE GLASS

YOUR LIFE. YOUR FIRE.

[Europe Fireplace Models

[THIS

ISTALLATION MANUAL INCLUDES ASSEMBLY INSTRUCTIONS FOR THESE MODELS:

CIRCLE 70

CIRCLE 70 [270]

CIRCLE 70 [DG]

CIRCLE 70 [270] [DG]

ISLAND 70

ISLAND 130

ISLAND 130 [DG]

INSTALLER:

Installation must be performed by a

professional who is licensed to install

fireplaces in the state where the

installation will take place. Instructions

provided by the manufacturer, ORTAL,

should be considered installation

recommendations. If there is any

divergence between the manufacturer’s

instructions and the local code, priority

must be given to the local code.

YOUR LIFE. YOUR FIRE.

[Table of Contents

[TABLE OF CONTENTS

Preparation –Curved Fireplaces ...............................................5

Installation –Curved Fireplaces................................................6

Maintenance –Curved & Island Fireplaces ..............................24

Installation –Wall Mounted Curved Fireplaces .........................25

Installation –Island Models ...................................................30

J.C. Bordelet Chimney Assembly Instruction ............................34

Ortal Chimney Assembly Instruction .......................................35

Glass Types..........................................................................36

Log Sets and Stones .............................................................37

Clearances for Circle 70 EU / 7565 Curved Tunnel ...................38

Clearances for Circle 70 EU / 7565 Curved Tunnel DG ..............39

[Preparation

–

Curved Fireplaces

[PRE-INSTALLATION PREPARATIONS

A round fireplace can be installed with a cone or flat top. When a cone is installed, it must be

installed BEFORE installation of the fireplace begins (according to the installation instructions

on page 25 and depending upon the model of the selected cone.

[VENT PIPE AND CONE INSTALLATION

First install the vent pipe cone (see the relevant manual for your type of cone).

Thread the vent pipe inside the cone to the required length.

When the installation is complete, verify that the distance between the bottom of the cone and the floor is approximately 860mm (33 3/4 “).

NOTE: For all round fireplace models, the cone is must be suspended from the ceiling and NOT resting on the fireplace.

[GAS & ELECTRICITY SOURCE

Provide gas and electricity according to local code.

Electrical source –For fireplaces with double glass and blowers, you will need to connect the unit to a 110V/220V outlet.

NOTE: This manual describes the installation of the vent pipe cone and the fireplace assembly. Explanations regarding gas and vent

pipe installation are described in a separate Installation & Operation Manual.

[Installation

–

Curved Fireplaces

[GRILL COVER

•

Unpack the unit.

•

Unscrew the 4 Phillips screws on the top of the unit.

•

Lift the grill cover top up and away from the unit.

[DECORATIVE COVERS

•

Gently hand lift 4 peripheral decorative covers. These

decorative covers are secured in position with magnetic

supports.

NOTE: Use a coated screwdriver only.

[Installation

–

Curved Fireplaces

[BURNER UNIT REMOVAL

•

Carefully lift the burner unit by unscrewing 8 base plate

screws, and manually lift and remove the entire burner

plate upwards.

[PREPARATIONS

•

Gently and securely rotate and position the fireplace

base on its side. It is recommended that you prepare

a soft material to place underneath the fireplace base

for protection.

[GAS VALVE

•

The gas valve is screwed to one of the 4 fireplace legs

in the factory prior to shipping. Prior to attaching the

legs to the fireplace, choose the best location for the

gas valve and attach the leg/gas valve assembly to the

unit, as described below.

[FIREPLACE LEGS

•

With the fireplace on its side, install the adjustable leg

fixtures to each one of the 4 legs underneath.

•

Make sure the leg fixtures are fitted while the adjusting

screws are pointing to the fireplace center (inward

direction). This is important for height adjustment later

during the installation process.

•

When complete, rotate the fireplace base to the upright

position so that it stands solidly on it’s the legs.

[Installation

–

Curved Fireplaces

[FIREPLACE

BASE INSTALLATION:

•

Position the fireplace base centered underneath the vent pipe cone.

•

Make sure there is gas and electrical access

underneath the fireplace base.

[Installation

–

Curved Fireplaces

[

LEG PLACEMENT:

•

With the fireplace base centered under the vent pipe cone,

secure the legs to the floor with anchor screws.

Note: This step is important to avoid any fireplace

movement during use.

•

After securing the leg fixtures to the floor,

release all adjustment screws to level the

fireplace.

•

It is recommended to use a spirit level to determine the

base level in "X" and "Y" directions before tightening the

height adjustment screws.

NOTE: Perform the above installation process through

the burner base-plate hole on top.

[SAFETY GAP:

•

Before tightening the fixture legs, make sure that there is

a safety gap of 6.35mm [1/4"] between the fireplace base

(skirt) to the floor.

Note: THIS IS AN IMPORTANT LPG SAFETY PRECAUTION.

6.35mm

[1/4"]

[Installation

–

Curved Fireplaces

[

GAS AND ELECTRICAL CONNECTIONS:

•

Install and connect the gas access valve to the supply

line, and connect the gas pipe positioned between the

gas valve to the burner.

•

Connect the electrical wiring to the burner controller

according to model specifications.

•

Place the back the burner unit in position, and tighten

the 8 top screws to secure the burner.

•

NOTE: Make sure the burner is properly seated while

the gas pipe and electrical wiring are correctly

positioned and attached underneath.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Chimenea de interior de ORTAL

ORTAL

ORTAL Wilderness 44 RS Manual de usuario

ORTAL

ORTAL Series 40 Manual de usuario

ORTAL

ORTAL 98 Series Manual de usuario

ORTAL

ORTAL Series 40 Manual de usuario

ORTAL

ORTAL 75 Manual de usuario

ORTAL

ORTAL Series 40 Manual de usuario

ORTAL

ORTAL Lyric Front Facing Series Manual de usuario

ORTAL

ORTAL Front Facing Series Manual de usuario

ORTAL

ORTAL Stand Alone Front Series Manual de usuario

ORTAL

ORTAL Clear 40 RS Manual de usuario

ORTAL

ORTAL Wilderness 31 Front Manual de usuario

ORTAL

ORTAL 44 Series Manual de usuario

ORTAL

ORTAL Wilderness 68 Series Manual de usuario

ORTAL

ORTAL Stand Alone 75 Hood Manual de usuario

ORTAL

ORTAL Clear 40 Manual de usuario

ORTAL

ORTAL Stand Alone TS Series Manual de usuario

ORTAL

ORTAL Wilderness Stand Alone 25H TS Manual de usuario

ORTAL

ORTAL Wilderness Traditional Insert Series Manual de usuario

ORTAL

ORTAL Series 40 Manual de usuario

ORTAL

ORTAL 44HH Series Manual de usuario

ORTAL

ORTAL 77 Series Manual de usuario

ORTAL

ORTAL 68 RS Manual de usuario

ORTAL

ORTAL Wilderness 60HH Front Facing Manual de usuario

ORTAL

ORTAL Lyric Manual de usuario

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación