Optoma H79 Manual de usuario

ModelName:H79

SERVICEMANUAL

Date Revise Version Description

2005/3/9 V1.0 Initial Issue

Prepared bySI:

________________________________________

Prepared byTSE :Jack

________________________________________

Checkby:

________________________________________

Approved by:

________________________________________

CopyrightMarch,2005 .All RightsReserved

Document#81E-G04-01A.P/N:36.81E03.001

ThismanualisappliedtoH79ProjectorwithdigitalimagingfunctionalitybasedonDigitalMicro-mirror

Device(DMD)technology. It’sthemodeofsinglePanel,250wattPhilipsUHPlamp. Themanualgives

youabriefdescriptionofbasictechnicalinformationtohelpinserviceandmaintainingtheproduct.

Yourcustomerswillappreciatethequickresponsetimewhenyouimmediatelyidentifyproblemsthatoccur

withourproducts. Weexpectyourcustomerswillappreciatetheservicethatyouofferthem.

Thismanualisfortechniciansandpeoplewhohaveanelectronicbackground. Sendtheproductbackto

thedistributorforrepairinganddonotattempttodoanythingthatiscomplexorisnotmentionedinthe

troubleshooting.

NOTICE:

Theinformationfoundinthismanualissubjecttochangewithoutpriornotice.Anysubsequentchanges

madeinthedatahereinwillbeincorporatedinfurtheredition.

AllRightsReserved

ManualVersion1.0

Document# 81E-G04-01A

Preface

H79I

H79II

TableofContents

Chapter1Introduction 1-1

ProductHighlights1-1

ComputerCompatibility1-4

Chapter2DisassemblyProcedure 2-1

ToolsNeeded 2-1

Removing LampModule 2-2

Removing I/O Panel,Top Coverand Keypad Board 2-3

RemovingThermalBoard,MainBoard,

ConnectorBoardand PowerModule 2-5

RemovingBallastModule,FrontCoverand Engine Module 2-7

Removing FanModule92x25mm,DMDChip,Fan Module

50x15mm,FanModule59x25mm,ThermalSensor2-9

RemovingAirDuctModule 2-13

Chapter3Troubleshooting 3-1

EquipmentNeeded 3-1

MainProcedure 3-2

Chapter4Function Testand AlignmentProcedure 4-1

Product4-1

TestEquipment4-1

TestCondition 4-1

TestDisplayModesand Pattern 4-2

InspectionProcedure 4-6

Chapter5FirmwareUpgradeProcedure 5-1

EquipmentNeeded 5-1

Setup Procedure 5-1

FirmwareUpgrade Procedure 5-2

HotKey5-5

Chapter6DDC Key-inProcedure 6-1

EquipmentNeeded 6-1

HardwareSetup Procedure 6-2

EDIDUpgrade Procedure 6-3

AppendixAExplodedOverview7-1

AppendixBSerialNumberSystemDefinition 7-19

Reader’s Response 7-20

H791-1

+D=FJAH

Introduction

1-1 Product Highlights

- One HD2 2.5G 0.79" DMD projection system with 540 ANS lumens.

- Contrast (FOFO) : 2800 : 1 (Typical), 2400:1 (Minimum)

-250 - Watt Philips UHP Lamp. Lamp life 1500 hours, Eco mode 2000 hours

- High efficiency cooling system with system acoustic noise level 32 +/- 2 dB(A) (Normal-mode) / 28

+/- 2 dB (A) (Eco- mode)

- Lens Up/Down Shift construction

- Adjustable Feet ( +/- 3 degrees)

- Dimensions : 430mm x 305mm x 135mm (External Max size)

- Motorized focus projection and zoom lens 1.35X

- 8 segments GgRBGgRB color wheel spinning at 150Hz

- Computer capability up to UXGA 60Hz for Analog and XGA 75Hz for Digital nputs

- NTSC/PAL/SECAM video capability with S-video / composite / component, and HDTV(480i/p,

576i/p, 720p, 1080i)

- Separately R/G/B/H/V BNC input supported.

- Auto detection of computer signal input(Auto-tracking /frequency /position adjustment).

- Source Lock Feature

- Automatically saves adjustments for future use

- On-screen menu with 10 languages

- On Screen lamp life timer.

- One DV PC-data input ( ncluding Analog and Digital RGB signal )

- Support HDCP function

- R remote controller

- No High Altitude Mode function supports in OSD

H791-2

- Weight : < 17.1 lbs. ( 7.8 Kg )

- Cooling System

a. Advanced Air Flow

Three fans with system acoustic noise level : 32dB(A) (Typical)

Temperature control circuits with adaptive voltage control fan speed

b. Max touch temperature follows UL60950 regulation

- Lamp Door Protection : Lamp power supply shuts off automatically when door opens

- Display Panel Specifications

a. T HD2+ DC3 (Dark Chip 3) 0.79 DMD / 12deg / 1280x720

b. Number of active dots : 1280(H) x 720(V)

- Power Supply :

Universal AC 90264V~50-60 Hz with PFC input

250W for Philips UHP Lamp at normal operation

- Power consumption

330W+/-10% (Operating@110V), 3.08A+/-10% (Operating@110V)

13.5W maximum (Stand-by@90V), 25W maximum (Stand-by@264V)

- /O ports

a. DV x 1 (DV ,Analog RBG, Component, HDTV)

b. BNC RBGHV x 1 ( R x 1, G x 1, B x 1, Hsync x 1, Vsync x1)

c. YCbCr x1 (R x 1, G x 1, B x 1)

d. Video input (RCA jack Type X 1)

e. Mini D N 4-pin X 1 (S-video)

f. R x 2 (Front, Rear)

g. RS232 Serial Control x 1 (D-sub)

h. Power Cord x 1

i. 12V Trigger relay x 2

- nput signal spec.

a. Hsync Frequency 31.5 ~ 91.1 kHz

b. Vsync Frequency 43 ~ 85 Hz

c. Video Signal RGB (PC)

Analog RGB 0.7Vp-p, 75 ohm

Analog RGB 1Vp-p, 75 ohm, Sync. Signal

Separate TTL H,V Sync.

Composite TTL Sync.

d. Video

Composite video 1Vp-p,75 ohm

S-video Luminance 0.714Vp-p,75 ohm

S-video Chrominance 0.286Vp-p,75 ohm

H791-3

- nput signal spec.

a. Hsync Frequency 31.5 ~ 91.1 kHz

b. Vsync Frequency 43 ~ 85 Hz

c. Video Signal RGB (PC)

Analog RGB 0.7Vp-p, 75 ohm

- Video Compatibility

a. Standards :

NTSC - M, 4.43 MHz

PAL - B, D, G, H,

SECAM - B, G, H, K, K1, L

HDTV - 480i, 480p, 576i, 576p, 720p, 1080i

b. TV Lines - 500 lines

- Keystone

a. Vertical : +/- 16 degree (Desk-projecter angle)

b. Horizontal : +/- 7 degree (Screen-projecter angle)

- Projection lens : f = 28.3 ~ 38.2mm, F/3.4, 1.35X Manual Zoom Lens.

- Projection mage Size : 30 to 280 Diagonal (Wide)

- Throw Distance : 3.28 ft to 32.80 ft / 1.0m to 10m(Wide).

- Throw Ratio : 1.6~2.16 (Projection Distance/ mage Width)

- Brightness : 540 ANS lumens

- Temperature

a. Operating : 5°C  35°C

Storage: -10°C  60°C

- Maximum Humidity

a. Operating: 5°C  35°C , 80%RH (Max.), non-condensing

Storage: -10°C  60°C , 80%RH (Max.), non-condensing

- Lamp life :

a. 1500 hours min. , 50% survial rate (Normal mode)

2000 hours min. , 50% survial rate (Eco mode)

( Lamp life = normal lamp life+1/2 Eco lamp life )

- Altitude :

a. Operating : 0~2,500 ft 5°C~35°C

2,500~5,000 ft 5°C~30°C

5,000~10,000 ft 5°C~25°C

Storage : 40,000 ft

- MTBF : Operating more than 12,000 hrs (90% confidence level)

H791-4

1-2 Computer Compatibility

Compatibility Resolution V-Sync [Hz] H-Sync [KHz]

VGA 640x4 0 60 31.5

640x4 0 72 37.9

640x4 0 75 37.5

640x4 0 5 43.3

720x400 70 31.5

720x400 5 37.9

SVGA 00x600 56 35.2

00x600 60 37.9

00x600 72 4 .1

00x600 75 46.9

00x600 5 53.7

XGA 1024x76 43.4 35.5

1024x76 60 4 .4

1024x76 70 56.5

1024x76 75 60.0

1024x76 5 6 .7

SXGA 12 0x1024 60 64

12 0x1024 75 0

12 0x1024 5 91.1

UXGA 1600x1200 60 75



a. Analog

b. Digital

Compatibility Resolution V-Sync [Hz] H-Sync [KHz]

VGA 640x4 0 60 31.5

640x4 0 72 37.9

640x4 0 75 37.5

640x4 0 5 43.3

700x400 70 31.5

700x400 5 37.9

SVGA 00x600 56 35.2

00x600 60 37.9

00x600 72 4 .1

00x600 75 46.9

00x600 5 53.7

XGA 1024x76 60 4 .4

1024x76 70 56.5

1024x76 75 60.0



H792-1

Chapter 2

Disassembly Procedure

Tools Needed

Screw Bit (+) : 107

Screw Bit (+) : 102

Hex Sleeves 5mm

Long Nose Nipper

Angle utting Nipper

Ball-end hex-key 3mm

H792-2

2-1 Removing Lamp Module

1. Unscrew one screw to remove the Lamp over.

Note : Be careful that Lamp over has the tenon inside.



2. Loosen 3 screws to remove Lamp Module.

Lamp over

Lamp Module

Otros manuales para H79

Tabla de contenidos

Otros manuales de Proyector de Optoma

Optoma

Optoma TW610ST Manual de usuario

Optoma

Optoma ML1000 Manual de usuario

Optoma

Optoma PRO250X Manual de usuario

Optoma

Optoma ES520 Manual de instrucciones

Optoma

Optoma ES522 Manual de usuario

Optoma

Optoma EP739 Manual de usuario

Optoma

Optoma DX626 Manual de usuario

Optoma

Optoma X401 Manual de usuario

Optoma

Optoma ES515 Manual de usuario

Optoma

Optoma EW674N Manual de usuario

Optoma

Optoma PRO160S Manual técnico

Optoma

Optoma TS350 Manual de usuario

Optoma

Optoma Optoma EP730 Manual de usuario

Optoma

Optoma EX536 Manual de usuario

Optoma

Optoma GT1080Darbee Manual de usuario

Optoma

Optoma EP761 Manual de usuario

Optoma

Optoma EP720 Family Manual de usuario

Optoma

Optoma TW556-3D Manual de usuario

Optoma

Optoma GT200 Manual de usuario

Optoma

Optoma HD700X Manual de usuario

Optoma

Optoma DS325 Manual de usuario

Optoma

Optoma E1P2A2F6E1Z1 Manual de usuario

Optoma

Optoma Optoma EP727 Manual de usuario

Optoma

Optoma TX542-3D Manual de usuario

Manuales populares de Proyector de otras marcas

iEmmet

iEmmet MP-312 Manual de usuario

Epson

Epson VS400 Manual de usuario

Sony

Sony VPL-HS10 Marketing Specifications & Features Manual de usuario

Sony

Sony VPL-HW65ES Manual de servicio

Toshiba

Toshiba TLP-791U Manual de usuario

Philips

Philips LC1341 Guía de referencia

Panasonic

Panasonic PTL735NTU - LCD PROJECTOR-NETWORK IB Manual de usuario

NEC

NEC NP600S EDU Manual de usuario

BenQ

BenQ SH753P Manual de usuario

Eiki

Eiki EK-623U series Manual de usuario

Epson

Epson PowerLite Pro Cinema 6020UB Manual de usuario

Epson

Epson PowerLite Home Cinema 705HD Manual de usuario

Christie

Christie LHD700 Manual de usuario

Navitar

Navitar FX Manual de usuario

InFocus

InFocus LitePro 560 Manual de usuario

Sony

Sony SRX-R815P Manual de usuario

Vivitar

Vivitar DP1500 X Manual de usuario

Acer

Acer C20 Series Manual de usuario