Optoma EX556 Manual de instrucciones
SERVICE MANUAL
TSE: Mina Check: Alick Approved: Alick
Date Revise Version Description
2012.05.20 V1.0 Initial Issue
EX556/ES556/EW556/ES555/EX555
Condential
EX556/ES556/EW556/ES555/EX555 I
Preface
This manual is applied to EX556/ES556/EW556/ES555/EX555 projection system. The
manual gives you a brief description of basic technical information to help in service
and maintain the product.
Your customers will appreciate the quick response time when you immediately
identify problems that occur with our products. We expect your customers will
appreciate the service that you offer them.
This manual is for technicians and people who have an electronic background.
Please send the product back to the distributor for repairing and do not attempt to
do anything that is complex or is not mentioned in the troubleshooting.
Notice: The information found in this manual is subject to change without prior notice.
Any subsequent changes made to the data herein will be incorporated in
future edition.
EX556/ES556/EW556/ES555/EX555 Service Manual
Copyright May. 2012
All Rights Reserved
Manual Version 1.0
Condential
EX556/ES556/EW556/ES555/EX555
EX556/ES556/EW556/ES555/EX555 Comparison List
II
ES555 ES556 EX556 EX555 EW556
Main Board 80.8PJ01G012 80.8PJ01G002 80.8PL01G002 80.8PL01G012 80.8PM01G002
DMD Chip 48.8EH01G001 48.8CQ01G003 48.8EJ01G001
IO Cover 70.8PJ21GR01 70.8PJ18GR01 70.8PL09GR01 70.8PM10GR01
Engine Module 70.8PJ17GR01 70.8PM09GR01
Condential
EX556/ES556/EW556/ES555/EX555 III
Table of Content
Chapter 1 Introduction
Highlight 1-1
Compatible Mode 1-2
Chapter 2 Disassembly Process
Equipment Needed & Product Overview 2-1
Disassemble Lamp Module 2-2
Disassemble Focus Ring 2-3
Disassemble Lamp Cover 2-4
Disassemble Main Board 2-5
ROD Adjustment 2-8
Re-write Lamp Hours 2-9
Chapter 3 Troubleshooting
LED Lighting Message 3-1
Main Procedure 3-2
Chapter 4 Function Test & Alignment Procedure
Test Equipment Needed 4-1
Test Condition 4-1
S-Video and Audion Port Test(not for ES555) 4-7
Video port Test 4-7
Component port Test 4-7
HDMI Port Test 4-8
HDMI Port Test(3D Test ) 4-8
3D Test 4-8
Run In Test 4-9
Condential
EX556/ES556/EW556/ES555/EX555 IV
Test Inspection procedure 4-9
Factory Fan RPM 4-10
Chapter 5 Firmware Upgrade
Section 1: System Firmware Upgrade 5-1
Section 2: 8051 Firmware Upgrade Procedure 5-3
Appendix A
Exploded Image I
Appendix B
SerialNumberSystemDenition I
PCBACodeDenition II
EX556/ES556/EW556/ES555/EX555 Condential 1-1
Chapter 1
Introduction
1-1 Highlight
No Item Description
1Dimensions (WxDxH) ● 288 x220 x77 mm
2 Power Supply ● Universal AC 100V-240V±10%, 50-60Hz
3Power Consumption ● Normal:TYP 239W MAX 263W @110
● ECO:TYP 200W MAX 220W@110
4 Keystone correction ● +/- 40 degree is the scaler spec
5Throw ratio ● 1.95~2.15(D/W) (For ES555/ES556/EX555/EX556)
● 1.55~1.7(D/W) (For EW556)
6Projection lens
● YM09X/FPL65(For ES555/ES556)
● YM09X/FPL30(For EX555/EX556)
● YM31Z (For EW556)
7 Lamp life
Normal Mode:
● 4500 Hours Standard @190W, 50% Survival Rate
ECO Mode:
● 5000 Hours Typical @162W, 50% Survival Rate
8 Lamp ● 190W Lamp (Philp E20.9)
9DMD Chip&Number
of active dots
For ES555/ES556
● 0.55” SVGA
● Number of active dots: 800 x 600
For EX555/EX556
● 0.55” XGA
● Number of active dots: 1024 x 768
For EW556
● 0.55” WXGA
● Number of active dots: 1280 x 800
10 Color wheel ● 6 segments (R81Y41G84C31W52B71)
11 System controller ● TI DDP 2431
12 Video compatibility
● NTSC: M/J,3.58MHz,4.43MHz
● PAL: B, D, G, H, I, M, N,4.43MHz
● SECAM: B, D, G, K, K1, L,4.25/4.4MHz
● SDTV: 480i/p, 576i/p,
● HDTV: 720p(50/60Hz), 1080i(50/60Hz),1080p(50/60Hz)
Condential 1-2
EX556/ES556/EW556/ES555/EX555
No Item Description
13 Input signal spec
For ES556/EX556/EW556
● VGA-in x 2(support SCART/YPbPr)
● HDMIv1.3(with HDCP support) x 1
● Composite Video x 1
● S-Video (Mini DIN) x 1
● Audio input (phone Jack) x 1
For ES555
● VGA-in x 1(support SCART/YPbPr)
● Composite Video x 1
For EX555
● VGA-in x 2(support SCART/YPbPr)
● Composite Video x 1
● S-Video (Mini DIN) x 1
● Audio input (phone Jack) x 1
14 Altitude&Temperature
● Operating: 0~2,500 ft 5°C~45°C
2,500~5,000 ft 5°C~35°C
5,000~10,000 ft 5°C~30°C
Condential 1-3
EX556/ES556/EW556/ES555/EX555
Compatibility Resolution H-Sync [KHz] V-Sync
[Hz] Analog/Digital
NTSC －15.734 60 －
PAL/SECAM
－15.625 50 －
640 x 350 31.5 70 O
640 x 350 37.9 85 O
720 x 350 31.5 70 O
640 x 400 31.5 70 O
640 x 400 37.9 85.1 O
720 x 400 31.5 70 O
720 x 400 37.9 85 O
720 x 576 50 O
720 x 576 60 O
VGA 640 x 480 31.5 60 O
VGA 640 x 480 67 O
VGA 640 x 480 37.9 72.8 O
VGA 640 x 480 37.5 75 O
VGA 640 x 480 43.3 85 O
SVGA
800 x 600 35.2 56.3 O
800 x 600 37.9 60.3 O
800 x 600 46.9 75 O
800 x 600 48.1 72.2 O
800 x 600 80 O
800 x 600 53.7 85.1 O
832 x 624 72 O
832 x 624 75 O
1024 x 576 50 O
1024 x 576 60 O
1-2 Compatible Mode
Computer Compatibility
ES555/ES556/EX555/EX556
Condential 1-4
EX556/ES556/EW556/ES555/EX555
Compatibility Resolution H-Sync [KHz] V-Sync
[Hz] Analog/Digital
XGA
1024 x 768 48.4 60 O
1024 x 768 56.5 70.1 O
1024 x 768 57.7 72 O
1024 x 768 60 75 O
1024 x 768 68.7 85 O
1152 x 864 60 O
1152 x 864 70 O
1152 x 864 75 O
1152 x 864 85 O
1152 x 870 75 O
HD720 1280 x 720 50 O
HD720 1280 x 720 60 O
HD720 1280 x 720 75 O
HD720 1280 x 720 85 O
WXGA 1280 x 768 47.4 60 O
WXGA 1280 x 768 70 O
WXGA 1280 x 768 75 O
WXGA 1280 x 768 85 O
WXGA-800 1280 x 800 60 O
SXGA 1280 x 1024 64 60 O
SXGA 1280 x 1024 80 75 O
SXGA 1280 x 1024 91.1 85 O
SXGA+ 1400 x 1050 60 O
UXGA 1600 x1200 75 60 O
Condential 1-5
EX556/ES556/EW556/ES555/EX555
Compatibility Resolution H-Sync [KHz] V-Sync
[Hz] Analog/Digital
HDTV
1920 x 1080 33.8 30 O
1920 x 1080 28.1 25 O
1920 x 1080i 50 O
1920 x 1080i 60 O
1920 x 1080p 24 O
1920 x 1080p 25 O
1920 x 1080p 30 O
1920 x 1080p 50 O
1920 x 1080p 60 O
1280 x 720 45 60 O
1280 x 720p 50 O
1280 x 720p 60 O
SDTV
720 x 576 31.3 50 O
720 x 576i 50 O
720 x 576p 50 O
720 x 480 31.5 60 O
720 x 480i 60 O
720 x 480p 60 O
Otros manuales para EX556
1
Este manual sirve para los siguientes modelos
4
Tabla de contenidos
Otros manuales de Proyector de Optoma
Optoma
Optoma TS725 Manual de usuario
Optoma
Optoma TX800 Manual de usuario
Optoma
Optoma DX319p Manual de usuario
Optoma
Optoma EX765 Manual de usuario
Optoma
Optoma Optoma TX615 Guía del administrador
Optoma
Optoma H78DC3 Manual de usuario
Optoma
Optoma TWR1693 Manual de usuario
Optoma
Optoma UHD51A Manual de usuario
Optoma
Optoma TW610ST Manual de usuario
Optoma
Optoma 1080p DLP Manual de usuario
Optoma
Optoma TX1080 Manual de usuario
Optoma
Optoma HD8000-LV Manual de usuario
Optoma
Optoma Optoma EP721 Manual de usuario
Optoma
Optoma L1 Manual de usuario
Optoma
Optoma TWR1693 Manual de usuario
Optoma
Optoma EP910 SXGA+ Manual de instalación
Optoma
Optoma Optoma EP721 Manual técnico
Optoma
Optoma Data Projector Manual de usuario
Optoma
Optoma EP739 Manual de usuario
Optoma
Optoma TW330 Manual de usuario
