Newgen 345-E Manual de usuario
ASSEMBLY &
MAINTENANCE
OWNER’S MANUAL
newgenbikes.com
345-E
INDEX
INDEX
-
---------------------------------------------------------------------------------------------------------------------------------------
IMPORTANT SYMBOLS
-
-------------------------------------------------------------------------------------------------
INTRODUCTION
-
---------------------------------------------------------------------------------------------------------------
INTENDED USE
-
------------------------------------------------------------------------------------------------------------------
REGISTER YOUR 345 ------------------------------------------------------------------------------------------------------
LOCAL REGULATIONS ----------------------------------------------------------------------------------------------------
ABOUT YOUR BIKE
-
----------------------------------------------------------------------------------------------------------
UNBOXING & ASSEMBLY
-
-------------------------------------------------------------------------------------------
PREPARATION FOR RIDING -----------------------------------------------------------------------------------------
OPERATING YOUR 345-E
-
--------------------------------------------------------------------------------------------
BATTERY -----------------------------------------------------------------------------------------------------------------------------------
DISPLAY
-
------------------------------------------------------------------------------------------------------------------------------------
GENERAL SAFETY --------------------------------------------------------------------------------------------------------------
PRE-RIDE SAFETY CHECKLIST
-
--------------------------------------------------------------------------------------
MAINTENANCE
-
----------------------------------------------------------------------------------------------------------------
REPAIRS & MAINTENANCE SCHEDULE
-
--------------------------------------------------------------
02
345
2
3
4
5
6
6
7
7
11
12
13
16
17
19
20
22
Please be aware of the following symbols used throughout the manual.
TOOLS REQUIRED
IMPORTANT INFORMATION
WARNING
NEWGEN TEAM TIP
IMPORTANT SYMBOLS
03
345
INTRODUCTION
Thank you for purchasing your 345-E from NewGen Bikes.
This manual contains information, warnings and cautions concerning the safe operation
of your bike. All information in this manual should be carefully reviewed. If you have any
questions, please contact NewGen Bikes immediately.
Keep this manual with your bike for future reference. Please note, the content of this
manual is subject to change or withdrawal without notice, for the most up-to-date version
please visit our website (newgenbikes.com). While this manual is intended as a guide,
it is not a comprehensive guide to cycling or bicycle maintenance.
Before setting out on your rst ride, please make sure you have carefully read and
understood your owner’s manual, and that you are familiar with the 345-E’s components
and operation. We recommend that you familiarise yourself with your new bike in a safe
environment before riding your bike on public roads or cycle paths.
There are risks associated with the use of any bike that cannot be predicted or avoided
and which are the sole responsibility of the rider.
Note: The 345-E (electric bicycle) is referred to in this manual as a bike, bicycle,
NewGen Bike, and 345, unless otherwise noted.
04
345
Knowledge Centre
Contact Us
The 345 is designed for use on roads and well-made paths, carrying a
maximum load of 120kgs (rider plus any luggage). The 345 is not intended for
stunts, off-road trails, racing or extreme sports. Your 345 should be used for its
intended purpose only. No liability or warranty shall be accepted if the use of
the 345 deviates from the intended use.
The manufacturer is not liable for any direct or consequential damages. Misuse
may lead to failure of some components, void your warranty, and/or risk injury
or death to the rider.
For the most up-to-date information about your 345-E,
please visit our website: newgenbikes.com
+44 (0) 20 7729 2704
newgenbikes.com
instagram.com/newgen_bikes
INTENDED USE
05
345
LOCAL REGULATIONS
It is important to register your bike with NewGen. When doing so, you will be asked to
enter your serial number, which is stamped on the top of the bike’s bottom bracket (the
cylindrical part of the frame between the pedals - see diagram on p.7). Scan the QR code
below to register your 345-E with our online form to validate your warranty.
The UK and EU recognise your 345-E as an ‘electrically assisted pedal cycle’ (EAPC). In
the UK and EU, you do not need a driver’s licence to operate an electric bike, nor do you
need to have it registered, taxed or insured, but you must be over the age of 14 to use
one.
Electric bike laws and regulations vary from country to country so please make sure you
check your local regulations. In most countries, you can ride an electric bike in bike lanes
and on bike paths as you would a regular non-assisted bicycle.
In many countries, including the UK, it is illegal to cycle on a public road after dark
without lights (front and rear) and reectors. Before riding at night be sure to check the
battery to ensure there is sufcient charge to power any lights for the duration of your ride.
It is also sensible to wear bright reective clothing. If you are using lights purchased from
Alternatively, please visit our website newgenbikes.com/345-registration.
Registration will allow us to inform you about product updates and promotions.
REGISTER YOUR 345
06
345
UNBOXING & ASSEMBLY
You should be condent that you have the skills required to safely prepare your bike
before use. If you have concerns about assembling the bike safely, please consider
taking it to a bike shop where a professional can assemble it for you.
We recommend asking a friend to help unpack and assemble your bike.
ABOUT YOUR BIKE
07
345
LED rear light
Rigid front fork
Bottom bracket
and cadence sensor
Cargo deck
250w hub
motor
Removable
battery with light
and reector
Brake levers and
display
Brake rotor
Brake caliper
Headset and
handlebar stem
Battery lock
Kickstand
1. Remove the four plastic inserts located around the bottom of the box.
Then, with two people, lift the top box off and set it down next to the bike.
If your bike has a front light, do not use it to lift the bike. It is not designed to hold the
weight of the bike.
2. Remove the accessories box from the tower. In this box you will nd:
3. Slide out the tower, so you can carefully roll your 345-E out from the box. Use the
bike’s kickstand to lean the bike on while you complete the rest of the assembly.
1 x 6mm Allen key 2 x pedals
1 x 15mm pedal spanner 1 x battery charger
1 x user manual 1 x bell
2 x battery keys
08
345
3. Now release the handlebars from the protective packaging and place them on the
stem. Loosely screw the bolts and plate back onto the stem making them nger-tight.
4. Working in a diagonal sequence, tighten each bolt by a half turn before moving
onto the next, allowing each bolt to be tightened evenly until all are tight and the
handlebar will not rotate in the stem. Ensure the handlebars are angled
perpendicular to the ground, as shown in the diagram on p.7.
5. To avoid damage during shipping the pedals are not pre-installed onto the
crank arms. Grab the pedals and the 15mm spanner from the box.
HANDLEBAR AND PEDAL ASSEMBLY
1. First take out the 6mm Allen key (an L-shaped metal tool). You will need this
to install the handlebars onto the handlebar stem.
2. Using the 6mm Allen key, remove all four bolts and plate from the stem.
09
345
7. Carefully attach the pedals to the crank arms and start tightening them by hand:
• The Right pedal should be tightened in a clockwise direction.
• The Left pedal should be tightened in an anticlockwise direction.
8. The thread on the pedals should be found easily. If not, check you have the
correct pedal for that side of the bike, remove and realign it, then try again.
Once the pedal is partly screwed into the crank, use the 15mm spanner to
tighten it fully. Excessive force may damage the pedal and/or crank arm.
6. The pedals look similar but one is intended for the right crank and one for the
left crank. Each pedal is marked with either an R for right and L for left. The right
and left side of the bike are as seen from the perspective of a seated rider.
10
345
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Otros manuales de Bicicleta de Newgen
