Motorola V3 Manual de usuario

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 1 / 11

Motorola internal use

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 2 / 11

Motorola internal use

Table of contents

1.0 Preamble

2.0 Some basic tips

3.0 Top 10 defective parts

4.0 Most frequent failure codes and root causes

Troubleshooting

5.0 U700

5.1 U50

5.2 Keyboard Flex Assy

5.3 U900

5.4 U800

5.5 Display

5.6 J 41

5.7 J-Keyboard

Modified Date By

9. June 2005 L. Heide

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 3 / 11

Motorola internal use

1.0 Preamble

This document was created to assist analyzers when fixing problems on Motorola

GSM Phones. All information was collected during the repair in the Repairentitlement

Group Flensburg.

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 4 / 11

Motorola internal use

2.0 Some basic tips

2.1Software upgrade

- always use the latest Software available for the phone (Software- bugs are

excluded)

2.2Visual inspection

- check for liquid damage (water indicator)

- check for missing, broken or unsoldered parts

- check for mechanical damage (board twisted, tracks defect etc.)

2.3Cross check

- before beginning to replace/change parts or soldering anything

try to consider the failure from all sides.

2.4Solder process

- the soldering process of lead-free products always must be done with the aid

of a bottom-heater and flux for lead-free soldering

- always cover sensitive parts with shields

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 5 / 11

Motorola internal use

3.0 Top 10 Defects

- Fig. 1 shows a analysis-summary of the phones repaired in NPI- process

related to the first repair works at all.

Fig. 1

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 6 / 11

Motorola internal use

4.0 Most frequent failure-codes - related root causes

TON -

U700, U800 ,U900, Keyboard Flex Assy ,J Keyboard, Y900, Y805

MKP -

Keyboard Flex Assy, J Keyboard

CHG

U900

CPR -

U50, U800

DIM -

Display, Keyboard Flex Assy, J Keyboard

DIS -

Display

ALT -

U900

AUD -

J41, U900

BAT -

U50

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 7 / 11

Motorola internal use

5.0 U700 Flash-Part / EE-Prom / SRAM

Customer complaint

- TONxx

1. Check the phone with a test battery. When the phone turns on, check the

customers charger and battery.

2. Disassemble the phone and try to boot the PCB with EMU connector if the

phone starts up, check the customers housing.

3. If the phone starts in flash-mode (yellow status) when connecting with the

EMU connector, try to reflash with 1FF-flash file. If this is not successful

replace U700.

4. When the phone starts in blank- mode (yellow status)when connecting with the

EMU connector, try to make a reflash with an Image-flash file. If is this not

successful replace U700

5. If the phones current drain is ~55mA (red status) and decreases after a few

seconds to ~6mA when connecting with the EMU connector also replace

U700.

5.1 U50 Power-Amplifier (Eagle-IC)

Customer complaint

- CPRxx / TONxx

1. Connect the phone with the EMU connector while monitoring the current

drain. If U50 (PA) is defect, you could have a short to ground (board does not

start/disconnects immediately). Occasionally the PA draws slightly more than

the nominal current (check nominal current with a reference-board ~40mA). If

the PA gets hot, replace the PA (U50).

2. Check TX-output spectrum by setting the phone in TX-mode using the

spectrum-analyzer. Compare level and shape of the spectrum with a

reference-board if the level is to low or the spectrum looks bad replace U50.

3. Also check to the time mask with a GSM-Test-Set. If the signal does not

conform to specifications, replace U50.

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 8 / 11

Motorola internal use

5.2 Keyboard Flex Assy

Customer complaint

- MKPxx / DIMxx / TONxx / DISxx

1. If some or all keys are not working or power up is impossible with the on/off

key, then perform a cross check with reference-housing. When all keys are

working, replace the Keyboard Flex Assy.

2. When the keyboard backlight is defect or intermittent, make a cross check

and if necessary change Keyboard Flex Assy.

3. If the display shows strange symbols or nothing at all also make a cross

check and replace Keyboard Flex Assy if it is necessary.

5.3 U900 PCAP 3

Customer complaint

- TONxx / ALTxx / CHGxx

1. If the multi-media ring tones are not working, replace U900.

2. When the charging process is not working, U900 could be defect.

3. Check these voltages, if the phone has a power up problem. Connect PCB

with EMU Connector and check the current drain. If the current drain is only

~ 0.6 mA, measure following voltages:

VBoost ~ 5.8V at C921

VBuck ~ 1.9V at L920

RF 5V REG ~ 5,0V at C933

Please refer to Fig. 2

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 9 / 11

Motorola internal use

If these Voltages are not present change U900.

Fig. 2

5.4 U800 Processor (Neptune)

Customer complaint

- TONxx

1. If all the voltages of PCAP 3 are present, the crystals

(Y805 and Y900) begin to oscillate and the flash-part has previously been

replaced, a defect U800 could cause the problem too.

VBuck ~ 1.9 V

RF 5V REG ~ 5 V

VBoost ~ 5.8 V

Motorola GmbH, CSS Center, Mobile Devices

Doc. No: TSG_V3

Version: 1.1

Date: 09.06.2005

Title: Troubleshooting-Guide V3 Page: 10 / 11

Motorola internal use

5.5 Display

Customer complaint

- DISxx / DIMxx

1. If the display has missing pixels or a missing line replace it.

2. If the secondary display shows only backlight or is completely dead, change

the display.

3. If the display shows strange symbols, make a cross check with a reference-

housing and a reference-flip and act accordingly.

5.6 J41 MIC

Customer complaint

- AUDxx

1. If TX-audio is missing, buzzing or is to low set PCB in audio

loop mode and check at C1202-2 mic bias voltage ~ 2.15 V

from PCAP (Fig. 3). If the bias voltage is present, measure using an

oscilloscope measure at C1202-1 int-micp ~1V. While speaking into the

microphone check for audio signals on your oscilloscope.

Fig. 3

audio

waves

mic

bias

voltage

Otros manuales para V3

Otros manuales de Teléfono móvil de Motorola

Motorola

Motorola V300 - Cell Phone 5 MB Manual de usuario

Motorola

Motorola MOTO Q 9HMOTO Manual de usuario

Motorola

Motorola RAZR HD Manual de usuario

Motorola

Motorola W208 Refresh Manual de usuario

Motorola

Motorola Nextel iDEN i2000plus Manual de usuario

Motorola

Motorola V300 - Cell Phone 5 MB Manual de usuario

Motorola

Motorola V360 Manual de usuario

Motorola

Motorola V505 Manual de instrucciones

Motorola

Motorola Moto g stylus Manual de usuario

Motorola

Motorola V177 Manual de usuario

Motorola

Motorola BACKFLIP Manual de usuario

Motorola

Motorola MOTO Q global Manual de usuario

Motorola

Motorola Rapture VU30 Manual de usuario

Motorola

Motorola A630 Manual de usuario

Motorola

Motorola i418 Manual de usuario

Motorola

Motorola BALI Manual de usuario

Motorola

Motorola EXHIBIT 8 Manual de usuario

Motorola

Motorola PAZR V Manual de usuario

Motorola

Motorola Fire XT 531 Manual de usuario

Motorola

Motorola i830 Manual de usuario

Motorola

Motorola Vodafone 702MO Manual de usuario

Motorola

Motorola T190 Manual de usuario

Motorola

Motorola Netopia 7000 Manual de usuario

Motorola

Motorola Moto G Hoja de especificaciones

Manuales populares de Teléfono móvil de otras marcas

Zte

Zte BLADE A520 Manual de usuario

Nokia

Nokia Lumia 620 Manual de usuario

Blackbe;rry

Blackbe;rry KEYone Manual de usuario

Bea-fon

Bea-fon X5 Premium Manual de usuario

Blackbe;rry

Blackbe;rry 8707 Series Manual de usuario

Blackbe;rry

Blackbe;rry Storm Instrucciones de funcionamiento

LG LM-X420QN Manual de usuario

LifeWatch

LifeWatch V Manual de usuario

Bea-fon

Bea-fon SILVER LINE SL860 Manual de usuario

IKI Mobile

IKI Mobile KF4.5i Manual de usuario

Hitech

Hitech HT-850 Manual de usuario

Yezz

Yezz Fashion F10 Manual de usuario

Point Mobile

Point Mobile PM60 Manual de usuario

Blackbe;rry

Blackbe;rry Q10 Manual de usuario

Blackbe;rry

Blackbe;rry Bold 9900 Manual de usuario

Blackbe;rry

Blackbe;rry STORM 9500 - VERSION 5.0 Manual de usuario

LG LM-K420EMW Manual de usuario

ISAFE MOBILE

ISAFE MOBILE IS655.2 Manual de usuario