Mitsubishi Electric TRANE NTXFKS09A112AA Manual de usuario

INDOOR UNIT

SERVICE MANUAL

Models

NTXFKS09A112AA

NTXFKS12A112AA

NTXFKS15A112AA

NTXFKS18A112AA

No. OBHT752

PARTS CATALOG (OBBT752)

CONTENTS

1. TECHNICAL CHANGES ··································· 3

2. PART NAMES AND FUNCTIONS····················· 4

3. SPECIFICATION················································ 5

4. OUTLINES AND DIMENSIONS ························ 7

5. WIRING DIAGRAM············································ 8

6. REFRIGERANT SYSTEM DIAGRAM··············· 9

7. SERVICE FUNCTIONS ··································· 10

8. MICROPROCESSOR CONTROL ··················· 12

9. TROUBLESHOOTING····································· 21

10. DISASSEMBLY INSTRUCTIONS···················· 36

INDOOR UNIT

Outdoor unit service manual

NTXSPF·A112AA Series (OBHA753)

NTXMMX·A·AA, NTXMPH·A·AA

Series (OBHA702, OCHA573)

Use the specied refrigerant only

Never use any refrigerant other than that specified.

Doing so may cause a burst, an explosion, or fire when the unit is being used, serviced, or disposed of.

Correct refrigerant is specified in the manuals and on the spec labels provided with our products.

We will not be held responsible for mechanical failure, system malfunction, unit breakdown or accidents caused by

failure to follow the instructions.

OBHT752

1TECHNICAL CHANGES

NTXFKS09A112AA

NTXFKS12A112AA

NTXFKS15A112AA

NTXFKS18A112AA

1. New model

OBHT752

2PART NAMES AND FUNCTIONS

NTXFKS09A112AA NTXFKS12A112AA NTXFKS15A112AA NTXFKS18A112AA

E.O

Display and operation section (When the front panel is opened)

Operation indicator lamp

Emergency operation

switch

Remote control receiving section

Fan guard

Air outlet

Air cleaning ﬁlter

(Anti-allergy enzyme filter, option)

Air ﬁlter

(Nano platinum ﬁlter)

Panel

Front panel

Horizontal vane

Vertical vane

Multi-ﬂow vane

ACCESSORIES

NTXFKS09A112AA NTXFKS12A112AA

NTXFKS15A112AA NTXFKS18A112AA

Drain hose 1

Remote controller holder 1

Fixing screw for 3.5 x 16 mm (Black) 2

Pipe cover 1

Band 2

Battery (AAA) for remote controller 2

Indoor unit mounting bracket 1

Fixing screw for 4 x 25 mm 5

Wood screw for the indoor unit xation 4

Washer of 4

Felt tape (Used for left or left-rear piping) 1

Wireless remote controller 1

OBHT752

3SPECIFICATION

Indoor model

NTXFKS09A112AA NTXFKS12A112AA NTXFKS15A112AA NTXFKS18A112AA

Power supply V, phase, Hz 208/230, 1, 60

Max. fuse size (time delay)/ Disconnect switch

A 15 20

Airow

Super High - High - Med. -

Low - Quiet

COOL Dry

(Wet)

CFM 417 - 360 - 272 - 198 - 138

(354 - 306 - 231 - 168 - 117)

431 - 392 - 311 - 254 - 198

(366 - 333 - 264 - 216 - 168) 491 - 420 - 328 - 254 - 198

(417 - 357 - 279 - 216 - 168)

HEAT Dry CFM 417 - 328 - 254 - 191 - 138 470 - 399 - 328 - 268 - 212

Sound level

Super High - High - Med. -

Low - Quiet

Cooling dB (A) 46 - 41 - 34 - 27 - 21

47 - 43 - 38 - 33 - 28 50 - 45 - 39 - 33 - 28

Heating dB (A) 46 - 40 - 34 - 27 - 21

49 - 45 - 40 - 35 - 29 49 - 45 - 40 - 35 - 29

Cond. drain connection O.D. in. 5/8

Dimensions Win. 29-17/32

D 8-15/32

H 23-5/8

Weight Ib. 33

External nish White

Control voltage (by built-in transformer) 12 - 24 VDC

NOTE: Test conditions are based on ARI 210/240.

Indoor model

NTXFKS09A112AA NTXFKS12A112AA NTXFKS15A112AA NTXFKS18A112AA

Power supply V, phase, Hz 208/230, 1, 60

Max. fuse size (time delay)/ Disconnect switch

A 15 20

Airow

Super High - High - Med. -

Low - Quiet

COOL Dry

(Wet)

CFM 275 - 251 - 208 173 - 138

(234 - 213 - 177 - 147 - 117) 374 - 328 - 282 - 237 - 198

(318 - 279 - 240 - 201 - 168)

HEAT Dry CFM 343 - 219 - 180 - 159 - 138 470 - 325 - 290 - 254 - 212

Sound level

Super High - High - Med. -

Low - Quiet

Cooling dB (A) 38 - 34 - 30 - 25 - 21 43 - 40 - 36 - 31 - 28

Heating dB (A) 41 - 32 - 27 - 24 - 21 49 - 39 - 36 - 34 - 29

Cond. drain connection O.D. in. 5/8

Dimensions Win. 29-17/32

D 8-15/32

H 23-5/8

Weight Ib. 33

External nish White

Control voltage (by built-in transformer) 12 - 24 VDC

NOTE: Test conditions are based on ARI 210/240.

1. Single connection

2. Multi connection

OBHT752

The air coverage is the figure

up to the position where the

air speed is 1 ft./s., when air is

blown out horizontally from the

unit properly at the High speed

position.

The coverage should be used

only as a general guideline

since it varies according to the

size of the room and furniture

arranged inside the room.

3-2. OUTLET AIR SPEED AND COVERAGE

(2) OPERATION

Mode Condition Intake air temperature (°F)

Indoor Outdoor

DB WB DB WB

Cooling

Standard temperature 80 67 95 —

Maximum temperature 90 73 115 —

Minimum temperature 67 57 14 —

Maximum humidity 78% —

Heating Standard temperature 70 60 47 43

Maximum temperature 80 67 75 65

Minimum temperature 70 60 -13 -14

3-1. OPERATING RANGE

(1) POWER SUPPLY

Rated voltage Guaranteed voltage (V)

Indoor unit 208/230 V

1 phase

60 Hz

Min. 187 208 230 Max. 253

1. Single connection

Model Mode Function Airow

(CFM) Air speed

(ft./s.) Coverage (ft.)

NTXFKS09A112AA

NTXFKS12A112AA

HEAT Dry 417 20.3 29.6

COOL Dry 417 20.3 29.6

Wet 354 17.2 25.3

NTXFKS15A112AA HEAT Dry 470 22.9 33.3

COOL Dry 431 21.0 30.6

Wet 366 17.8 26.2

NTXFKS18A112AA HEAT Dry 470 22.9 33.3

COOL Dry 491 23.9 34.8

Wet 417 20.3 29.7

2. Multi connection

Model Mode Function Airow

(CFM) Air speed

(ft./s.) Coverage (ft.)

NTXFKS09A112AA

NTXFKS12A112AA

HEAT Dry 343 16.7 24.5

COOL Dry 275 13.4 19.8

Wet 234 11.4 16.9

NTXFKS15A112AA

NTXFKS18A112AA

HEAT Dry 470 22.9 33.3

COOL Dry 374 18.2 26.7

Wet 318 15.5 22.8

OBHT752

4OUTLINES AND DIMENSIONS

NTXFKS09A112AA NTXFKS12A112AA NTXFKS15A112AA NTXFKS18A112AA Unit: inch

OBHT752

NTXFKS09A112AA NTXFKS12A112AA NTXFKS15A112AA NTXFKS18A112AA

5WIRING DIAGRAM

OBHT752

NTXFKS09A112AA NTXFKS12A112AA NTXFKS15A112AA NTXFKS18A112AA

Unit: inch (mm)

6REFRIGERANT SYSTEM DIAGRAM

Indoor

heat

exchanger

Flared connection

Room temperature

thermistor

RT11

Indoor coil

thermistor

RT12, RT14,

RT15

(main)

RT13 (sub)

Flared connection

Refrigerant flow in cooling

Refrigerant flow in heating

Refrigerant pipe 3/8 ( 9.52) (NTXFKS09A/12A)

1/2 ( 12.7) (NTXFKS15A/18A)

(with heat insulator)

Refrigerant pipe 1/4 ( 6.35)

(with heat insulator)

Distributor

OBHT752

SERVICE FUNCTIONS

7-1. TIMER SHORT MODE

• For service, the following set time can be shortened by bridging the timer short mode point on the electronic control P.C.

board. (Refer to 9-7.)

• The set time for the ON/OFF timer can be reduced to 1 second for each minute.

• After the breaker is turned on, the time for starting the compressor, which normally takes 3 minutes, can be reduced to 3

seconds. Restarting the compressor, which takes 3 minutes, cannot be reduced.

NTXFKS09A112AA NTXFKS12A112AA NTXFKS15A112AA NTXFKS18A112AA

1. How to modify the electronic control P.C. board

Turn OFF the power supply before modification. To assign a number to each indoor unit , cut off “JR05” and “JR06” on the

electronic control P.C. board as shown in Table 1. (Refer to 9-7.)

Unit No. 1

Unit No. 2

Unit No. 3

Unit No. 4

JR05

No modification

Cut off JR05

No modification

Cut off JR05

JR06

No modification

Cut off JR06

Table 1

CN211

Fuse (F11)

VARISTOR (NR11)

Indoor electronic

control P.C. Board

CN151

JR05

JR06

R111

7-2. HOW TO SET REMOTE CONTROLLER EXCLUSIVELY FOR A PARTICULAR INDOOR UNIT

A maximum of 4 indoor units with wireless remote controllers can be used in a room.

To operate the indoor units individually with each remote controller, assign a number to each remote controller according

to the number of the indoor unit.

This setting can be set only when all the following conditions are met:

• The remote controller is powered OFF.

• Weekly timer is not set.

• Weekly timer is not being edited.

2. How to set the remote controller

(1) Hold down button on the remote controller for 2 seconds to enter the pairing mode.

(2) Press button again and assign a number to each remote controller.

Each press of button advances the number in the following order: 1 → 2 → 3 → 4.

(3) Press button to complete the pairing setting.

After the setting, turn ON the power supply and with the remote controller headed towards the indoor unit, press the

STOP/OPERATE (OFF/ON) button. If 1 or 2 beeps are heard from the indoor unit, the setting is completed correctly.

The remote controller that first sends a signal to an indoor unit will be regarded as the remote controller for the indoor

unit.

Once they are set, the indoor unit will only receive the signal from the assigned remote controller afterwards.

OBHT752

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Acondicionador de aire de Mitsubishi Electric

Mitsubishi Electric

Mitsubishi Electric PCA-RP KA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MXZ-3C68VA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric CITY MULTI PEFY-P15 VMS1-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PKFY-P VBM-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Mr.Slim SUY-SM13VA-TH Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSH-GD80VB Manual de usuario

Mitsubishi Electric

Mitsubishi Electric JG79B594H07 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric City Multi PCFY-P NGMU-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric CITY MULTI PEFY-M20VMA-A1 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSZ-LN18VG2W Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSZ-HR71VF Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PCH-2GKHA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric 2.5KKC Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PUMY-P112VKM4 Manual de funcionamiento

Mitsubishi Electric

Mitsubishi Electric Mr.Slim PEA-RP100 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PKFY R2 Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MUZ-WR09NA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PLA-RP.BA Series Manual de instrucciones

Mitsubishi Electric

Mitsubishi Electric MS-GD08ND Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Trane NTXSPF09A112AA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PLFY-P-VAM-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PUZ-ZM-HA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Mr. Slim PEA-M250LA2 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PKA-RP HAL Manual de usuario

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Samsung

Samsung AR KV Series Guía

Daikin

Daikin FCFV50A Manual de usuario

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Daikin

Daikin FXLQ20MAVE Manual de usuario

Hitachi

Hitachi RAS-E24CAK Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Samsung

Samsung AS09HM3N Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario