Mitsubishi Electric MUFZ-KJ-NAHZ Series Manual de usuario

INDOOR UNIT

SERVICE MANUAL

Models

MFZ-KJ09NA-U1

MFZ-KJ12NA-U1

MFZ-KJ15NA-U1

MFZ-KJ18NA-U1

NOTE:

• This service manual describes technical data of the indoor units.

• RoHS compliant products have <G> mark on the spec name plate.

For servicing of RoHS compliant products, refer to the RoHS Parts List.

No. OBH752

REVISED EDITION-B

PARTS CATALOG (OBB752)

Outdoor unit service manual

MUFZ-KJ•NAHZ Series (OBH753)

MXZ-C•NA, MXZ-C•NAHZ Series

(OBH702, OCH573)

CONTENTS

1. TECHNICAL CHANGES ··································· 3

2. PART NAMES AND FUNCTIONS····················· 4

3. SPECIFICATION················································ 5

4. OUTLINES AND DIMENSIONS ························ 7

5. WIRING DIAGRAM············································ 8

6. REFRIGERANT SYSTEM DIAGRAM··············· 9

7. SERVICE FUNCTIONS ··································· 10

8. MICROPROCESSOR CONTROL ··················· 12

9. TROUBLESHOOTING····································· 21

10. DISASSEMBLY INSTRUCTIONS···················· 36

OBH752 REVISED EDITION-A is void.

Revision B:

• 4. OUTLINES AND DIMENSIONS has been

modified.

INDOOR UNIT

Use the speci¿ed refrigerant only

Never use any refrigerant other than that specified.

Doing so may cause a burst, an explosion, or fire when the unit is being used, serviced, or disposed of.

Correct refrigerant is specified in the manuals and on the spec labels provided with our products.

We will not be held responsible for mechanical failure, system malfunction, unit breakdown or accidents caused by

failure to follow the instructions.

Revision A:

• 3. SPECIFICATION and 4. OUTLINES AND DIMENSIONS have been modified.

Revision B:

• 4. OUTLINES AND DIMENSIONS has been modified.

2%+%

1TECHNICAL CHANGES

MFZ-KJ09NA- U1

MFZ-KJ12NA- U1

MFZ-KJ15NA- U1

MFZ-KJ18NA- U1

1. New model

2%+%

2PART NAMES AND FUNCTIONS

MFZ-KJ09NA MFZ-KJ12NA MFZ-KJ15NA MFZ-KJ18NA

E.O

Display and operation section (When the front panel is opened)

Operation indicator lamp

Emergency operation

switch

Remote control receiving section

Fan guard

Air outlet

$LUFOHDQLQJ¿OWHU

(Anti-allergy enzyme filter, option)

$LU¿OWHU

1DQRSODWLQXP¿OWHU

Panel

Front panel

Horizontal vane

Vertical vane

0XOWLÀRZYDQH

ACCESSORIES

MFZ-KJ09NA MFZ-KJ12NA

MFZ-KJ15NA MFZ-KJ18NA

Drain hose 1

Remote controller holder 1

Fixing screw for 3.5 x 16 mm (Black) 2

Pipe cover 1

Band 2

Battery (AAA) for remote controller 2

Indoor unit mounting bracket 1

Fixing screw for 4 x 25 mm 5

Wood screw for the indoor unit ¿xation 4

Washer of 4

Felt tape (Used for left or left-rear piping) 1

Wireless remote controller 1

2%+%

3SPECIFICATION

Indoor model MFZ-KJ09NA MFZ-KJ12NA MFZ-KJ15NA MFZ-KJ18NA

Power supply V, phase, Hz 208/230, 1, 60

Max. fuse size (time delay)/ Disconnect switch

A15 20

AirÀow

Super High - High - Med. -

Low - Quiet

COOL Dry

(Wet)

CFM 417 - 360 - 272 - 198 - 138

(354 - 306 - 231 - 168 - 117)

431 - 392 - 311 - 254 - 198

(366 - 333 - 264 - 216 - 168)

491 - 420 - 328 - 254 - 198

(417 - 357 - 279 - 216 - 168)

HEAT Dry CFM 417 - 328 - 254 - 191 - 138 470 - 399 - 328 - 268 - 212

Sound level

Super High - High - Med. -

Low - Quiet

Cooling dB (A) 46 - 41 - 34 - 27 - 21

47 - 43 - 38 - 33 - 28 50 - 45 - 39 - 33 - 28

Heating dB (A) 46 - 40 - 34 - 27 - 21

49 - 45 - 40 - 35 - 29 49 - 45 - 40 - 35 - 29

Cond. drain connection O.D. in. 5/8

Dimensions

in.

29-17/32

D8-15/32

H23-5/8

Weight Ib. 33

External ¿nish White

Control voltage (by built-in transformer) 12 - 24 VDC

NOTE: Test conditions are based on ARI 210/240.

Indoor model MFZ-KJ09NA MFZ-KJ12NA MFZ-KJ15NA MFZ-KJ18NA

Power supply V, phase, Hz 208/230, 1, 60

Max. fuse size (time delay)/ Disconnect switch

A15 20

AirÀow

Super High - High - Med. -

Low - Quiet

COOL Dry

(Wet)

CFM 275 - 251 - 208 173 - 138

(234 - 213 - 177 - 147 - 117)

374 - 328 - 282 - 237 - 198

(318 - 279 - 240 - 201 - 168)

HEAT Dry CFM 343 - 219 - 180 - 159 - 138 470 - 325 - 290 - 254 - 212

Sound level

Super High - High - Med. -

Low - Quiet

Cooling dB (A) 38 - 34 - 30 - 25 - 21 43 - 40 - 36 - 31 - 28

Heating dB (A) 41 - 32 - 27 - 24 - 21 49 - 39 - 36 - 34 - 29

Cond. drain connection O.D. in. 5/8

Dimensions

in.

29-17/32

D8-15/32

H23-5/8

Weight Ib. 33

External ¿nish White

Control voltage (by built-in transformer) 12 - 24 VDC

NOTE: Test conditions are based on ARI 210/240.

1. Single connection

2. Multi connection

2%+%

 The air coverage is the figure up to the

position where the air speed is 1 ft./s.,

when air is blown out horizontally from

the unit properly at the High speed posi-

tion.

The coverage should be used only as a

general guideline since it varies accord-

ing to the size of the room and furniture

arranged inside the room.

3-2. OUTLET AIR SPEED AND COVERAGE

1. Single connection

Model Mode Function AirÀow

(CFM)

Air speed

(ft./s.)

Coverage

(ft.)

MFZ-KJ09NA

MFZ-KJ12NA

HEAT Dry 417 20.3 29.6

COOL Dry 417 20.3 29.6

Wet 354 17.2 25.3

MFZ-KJ15NA

HEAT Dry 470 22.9 33.3

COOL Dry 431 21.0 30.6

Wet 366 17.8 26.2

MFZ-KJ18NA

HEAT Dry 470 22.9 33.3

COOL Dry 491 23.9 34.8

Wet 417 20.3 29.7

2. Multi connection

Model Mode Function AirÀow

(CFM)

Air speed

(ft./s.)

Coverage

(ft.)

MFZ-KJ09NA

MFZ-KJ12NA

HEAT Dry 343 16.7 24.5

COOL Dry 275 13.4 19.8

Wet 234 11.4 16.9

MFZ-KJ15NA

MFZ-KJ18NA

HEAT Dry 470 22.9 33.3

COOL Dry 374 18.2 26.7

Wet 318 15.5 22.8

(2) OPERATION

Mode Condition

Intake air temperature (°F)

Indoor Outdoor

DB WB DB WB

Cooling

Standard temperature 80 67 95 —

Maximum temperature 90 73 115 —

Minimum temperature 67 57 14 —

Maximum humidity 78% —

Heating

Standard temperature 70 60 47 43

Maximum temperature 80 67 75 65

Minimum temperature 70 60 -13 -14

3-1. OPERATING RANGE

(1) POWER SUPPLY

Rated voltage Guaranteed voltage (V)

Indoor unit

208/230 V

1 phase

60 Hz

Min. 187 208 230 Max. 253

2%+%

4OUTLINES AND DIMENSIONS

MFZ-KJ09NA MFZ-KJ12NA MFZ-KJ15NA MFZ-KJ18NA Unit: inch

2%+%

MFZ-KJ09NA MFZ-KJ12NA MFZ-KJ15NA MFZ-KJ18NA

5WIRING DIAGRAM

2%+%

MFZ-KJ09NA MFZ-KJ12NA MFZ-KJ15NA MFZ-KJ18NA

Unit: inch (mm)

6REFRIGERANT SYSTEM DIAGRAM

Indoor

heat

exchanger

Flared connection

Room temperature

thermistor

RT11

Indoor coil

thermistor

RT12, RT14,

RT15

(main)

RT13 (sub)

Flared connection

Refrigerant flow in cooling

Refrigerant flow in heating

Refrigerant pipe 3/8 ( 9.52) (MFZ-KJ09/12)

1/2 ( 12.7) (MFZ-KJ15/18)

(with heat insulator)

Refrigerant pipe 1/4 ( 6.35)

(with heat insulator)

Distributor

2%+%

SERVICE FUNCTIONS

7-1. TIMER SHORT MODE

• For service, the following set time can be shortened by bridging the timer short mode point on the electronic control P.C.

board. (Refer to 9-7.)

• The set time for the ON/OFF timer can be reduced to 1 second for each minute.

• After the breaker is turned on, the time for starting the compressor, which normally takes 3 minutes, can be reduced to 3

seconds. Restarting the compressor, which takes 3 minutes, cannot be reduced.

MFZ-KJ09NA MFZ-KJ12NA MFZ-KJ15NA MFZ-KJ18NA

1. How to modify the electronic control P.C. board

Turn OFF the power supply before modification. To assign a number to each indoor unit , cut off “JR05” and “JR06” on the

electronic control P.C. board as shown in Table 1. (Refer to 9-7.)

Unit No. 1

Unit No. 2

Unit No. 3

Unit No. 4

JR05

No modification

Cut off JR05

No modification

Cut off JR05

JR06

No modification

Cut off JR06

Table 1

CN211

Fuse (F11)

VARISTOR (NR11)

Indoor electronic

control P.C. Board

CN151

JR05

JR06

R111

7-2. HOW TO SET REMOTE CONTROLLER EXCLUSIVELY FOR A PARTICULAR INDOOR UNIT

A maximum of 4 indoor units with wireless remote controllers can be used in a room.

To operate the indoor units individually with each remote controller, assign a number to each remote controller according

to the number of the indoor unit.

This setting can be set only when all the following conditions are met:

• The remote controller is powered OFF.

• Weekly timer is not set.

• Weekly timer is not being edited.

2. How to set the remote controller

(1) Hold down button on the remote controller for 2 seconds to enter the pairing mode.

(2) Press button again and assign a number to each remote controller.

Each press of button advances the number in the following order: 1 ĺ2 ĺ3 ĺ4.

(3) Press button to complete the pairing setting.

After the setting, turn ON the power supply and with the remote controller headed towards the indoor unit, press the

STOP/OPERATE (OFF/ON) button. If 1 or 2 beeps are heard from the indoor unit, the setting is completed correctly.

The remote controller that first sends a signal to an indoor unit will be regarded as the remote controller for the indoor

unit.

Once they are set, the indoor unit will only receive the signal from the assigned remote controller afterwards.

2%+%

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Acondicionador de aire de Mitsubishi Electric

Mitsubishi Electric

Mitsubishi Electric City Multi PEFY-P-NMHU-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Mr. Slim SEZ-KA35 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MS-D30VC Manual de usuario

Mitsubishi Electric

Mitsubishi Electric City multi PLFY-P Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSZ-EF18VGW Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Mr. Slim SUZ-KA25 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Mr. Slim PEA-A12AA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PUZ-WZ50VAA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Mr.SLIM SEZ-M25DA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric CITY MULTI PLFY-EP.NEMU-E Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSZ-AP15VG Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSH-XV07UV Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PUHZ-SW40VHA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSZ-GE22VA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric CITY MULTI CMB-P-NU-G Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PLA-RP35BA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PUZ-HA30NHA Guía del producto

Mitsubishi Electric

Mitsubishi Electric Mr.Slim MUZ-FE09NA Manual de usuario

Mitsubishi Electric

Mitsubishi Electric CMB-P-NU-J1 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PFFY-P20VKM-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MXZ-2F53VFHZ Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MSZ-SF25VE Manual de usuario

Mitsubishi Electric

Mitsubishi Electric CITY MULTI PLFY-P-NBMU-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MFZ-KJ25VE Manual de usuario

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Samsung

Samsung AR KV Series Guía

Daikin

Daikin FCFV50A Manual de usuario

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Daikin

Daikin FXLQ20MAVE Manual de usuario

Hitachi

Hitachi RAS-E24CAK Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Samsung

Samsung AS09HM3N Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario