Mazda 2006 MX-5 Manual de referencia
Page 1 of 5
CONSUMER NOTICE: The information and instructions in this bulletin are intended for use by skilled technicians. Mazda technicians utilize the proper tools/
equipment and take training to correctly and safely maintain Mazda vehicles. These instructions should not be performed by “do-it-yourselfers.” Customers
should not assume this bulletin applies to their vehicle or that their vehicle will develop the described concern. To determine if the information applies,
customers should contact their nearest authorized Mazda dealership. Mazda North American Operations reserves the right to alter the specifications and
contents of this bulletin without obligation or advance notice. All rights reserved. No part of this bulletin may be reproduced in any form or by any means,
electronic or mechanical---including photocopying and recording and the use of any kind of information storage and retrieval system ---without permission in
writing.
© 2006 Mazda Motor of America, Inc.
Subject:
CENTER CONSOLE LID WILL NOT STAY CLOSED
Bulletin No: 09-033/06
Last Issued: 7/21/2006
Service Bulletin
Mazda North American Operations
Irvine, CA 92618-2922
2006 MX-5 - CENTER CONSOLE LID WILL NOT STAY CLOSED
APPLICABLE MODEL(S)/VINS
2006 MX-5
DESCRIPTION
On some vehicles, the center console lid may not stay in the closed position due to a broken latch.
Customers having this concern should have the console lid replaced using the following repair procedure.
REPAIR PROCEDURE
1. Verify customer concern.
2. Remove the center console from the vehicle. Refer to Workshop Manual section 09-17 CONSOLE
REMOVAL / INSTALLATION.
3. Remove the cup holder from the center console. Refer to Workshop Manual section 09-17 CONSOLE DIS-
ASSEMBLY / ASSEMBLY.
4. Slide open center console lid fully to rear position.
5. Identify rear guides for console lid.
1653a
REAR GUIDES
FRONT GUIDES
CENTER CONSOLE LID
Bulletin No: 09-033/06
© 2006 Mazda Motor of America, Inc.
Last Issued: 7/21/2006
Page 2 of 5
6. Using a flat-tipped screwdriver, slide guides rearward to disengage tabs from sides of cup holder assembly
as shown.
7. Repeat for other side.
8. Carefully lift console lid and guides from cup holder assembly.
1653b
PLACE FLAT TIPPED SCREWDRIVER INT
O
SLOT AND SLIDE GUIDE TOWARD REAR
OF CUP HOLDER TO DISENGAGE TABS
(REPEAT FOR BOTH SIDES)
1653c
GUIDE TAB SHOWN ENGAGED
GUIDE TAB SHOWN DISENGAGED
Bulletin No: 09-033/06
© 2006 Mazda Motor of America, Inc.
Last Issued: 7/21/2006
Page 3 of 5
9. Remove guides from old console lid.
NOTE: • Make note of sides of cup holder assembly guides are removed from for installation. Guides
cannot be installed backward or on opposite sides. Attempting to do so may damage the guides
and/or the cup holder assembly.
10.Install old guides onto new console lid. Line up with front edge of guides with front of lid.
11. Insert first tab of both guides into cup holder assembly.
PLACE GUIDES
ONTO NEW CENTER
CONSOLE LID
1653e
1653f
INSERT FIRST TAB OF BOTH GUIDES
INTO CUP HOLDER ASSEMBLY
Bulletin No: 09-033/06
© 2006 Mazda Motor of America, Inc.
Last Issued: 7/21/2006
Page 4 of 5
12.Carefully lay lid and guides down to line up remaining tabs.
13.Using a flat-tipped screwdriver, slide guide forward to engage tabs to sides of cup holder assembly.
14.Slide center console lid to fully closed position.
1653g
PLACE FLAT TIPPED SCREWDRIVER
INTO SLOT AND SLIDE GUIDE TOWAR
D
FRONT OF CUP HOLDER TO ENGAGE
TABS (REPEAT FOR BOTH SIDES)
1653h
GUIDE TAB SHOWN DISENGAGED
GUIDE TAB SHOWN ENGAGED
Bulletin No: 09-033/06
© 2006 Mazda Motor of America, Inc.
Last Issued: 7/21/2006
Page 5 of 5
15.Press down on rear of guides to ensure they are properly seated into cup holder assembly.
16. Install cup holder to center console.
17. Install center console to vehicle.
18. Verify repair.
PART(S) INFORMATION
WARRANTY INFORMATION
NOTE: • This warranty information applies only to verified customer complaints on vehicles eligible for war-
ranty repair. Refer to the Warranty Wizard for warranty term information.
• Additional diagnostic time cannot be claimed for this repair.
Part Number Description Qty. Notes
NE51-64-390 -02 Center Console Lid Ass’y 1 Black
NE51-64-390 -89 Center Console Lid Ass’y 1 Tan
Warranty Type A
Symptom Code 64
Damage Code 9A
Part Number Main Cause SEE PART(S) INFORMATION
Quantity 1
Operation Number / Labor Hours: XXB337RX / 0.4 Hrs
1653i
FIRMLY PRESS DOWN ON REAR
OF GUIDES TO ENSURE REAR
TABS LOCK INTO POSITION
Otros manuales para 2006 MX-5
2
Tabla de contenidos
Otros manuales de Automóvil de Mazda
Mazda
Mazda 2006 B-Series Manual de usuario
Mazda
Mazda 2000 Miata MX-5 Guía de inicio rápido
Mazda
Mazda 2010 CX-7 Guía
Mazda
Mazda MX-5 Miata Instrucciones de montaje
Mazda
Mazda Mazda6 2011 Manual de usuario
Mazda
Mazda 2005 B2300 Truck Manual de usuario
Mazda
Mazda CX-7 Navigation System Manual de usuario
Mazda
Mazda 2007 Mazdaspeed 3 Manual de usuario
Mazda
Mazda Tribute Instrucciones de montaje
Mazda
Mazda Mazdaspeed3 5-Door Hatchback Manual de usuario
Mazda
Mazda 2009 CX-9 Guía
Mazda
Mazda 2003 MX-5 Miata Manual de usuario
Mazda
Mazda 2014 2 Manual de usuario
Mazda
Mazda 2008 MAZDA6 5-Door Manual de usuario
Mazda
Mazda 2006 Tribute Manual de usuario
Mazda
Mazda 2007 6 Sports Sedan Manual de usuario
Mazda
Mazda Mazda 6 Guía de instalación
Mazda
Mazda CX-3 Manual de usuario
Mazda
Mazda 2015 CX-5 Manual de usuario
Mazda
Mazda CX-7 Navigation System Instrucciones de montaje
