Majestic 300DVB Manual de usuario

MODELS: 300DVB, 400DVB, 500DVB, 600DVB

DVB SERIES

DIRECT VENT GAS FIREPLACE

WARNINGS

IF THE INFORMATION IN THESE INSTRUCTIONS ARE

NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION

MAY RESULT CAUSING PROPERTY DAMAGE,

PERSONAL INJURY OR LOSS OF LIFE.

 

vapors and liquids in the vicinity of this or any

other appliance.

– WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use



        

     

instructions.

• If you cannot reach your gas supplier, call the



      

       

gas supplier.

   







service agency or the gas supplier.



    

       

local codes.

This appliance is only for use with the type of gas

indicated on the rating plate. This appliance is





         



DUE TO HIGH TEMPERATURES, THE

APPLIANCE SHOULD BE LOCATED

OUT OF TRAFFIC AND AWAY FROM

FURNITURE AND DRAPERIES.

CHILDREN AND ADULTS SHOULD

BE ALERTED TO THE HAZARDS OF

HIGH SURFACE TEMPERATURE AND

SHOULD STAY AWAY TO AVOID BURNS

OR CLOTHING IGNITION.

YOUNG CHILDREN SHOULD BE

SUPERVISED WHEN THEY ARE IN THE

SAME ROOM AS THE APPLIANCE.

CLOTHING OR OTHER FLAMMABLE

MATERIAL SHOULD NOT BE PLACED ON

OR NEAR THE APPLIANCE.

KEEP THE ROOM AREA CLEAR AND

FREE FROM COMBUSTIBLE MATERIALS,

GASOLINE, AND OTHER FLAMMABLE

VAPORS AND LIQUIDS.

READ BEFORE INSTALLING. SAVE THESE INSTRUCTIONS

INSTALLATION AND OPERATING INSTRUCTIONS

2 54D0701

CONTENTS

 .......................... 3

Product Features .............................................. 5

Code Approval .................................................. 5



Installing Above 2000 Feet............................ 6

Orice Sizes, Pressures and BTUs............... 6

Before You Install .......................................... 6

Fireplace Framing ......................................... 7

Fireplace Dimensions.................................... 8

Fireplace Location......................................... 9

Clearances ...................................................... 10

 ........11

.................................. 12

Vent Installation .............................................. 13

Installation Precautions............................... 13

Optional Top Vent Application ..................... 14

Installation Planning.................................... 15

Rear (Through the Wall) Applications ......... 18

Horizontal Termination Conguration .......... 20

Below Grade Installation ............................. 22

Vertical Through-the-Roof Installation......... 23

Installation for Vertical Termination ............. 24

Fireplace Installation...................................... 26

Check Gas Type.......................................... 26

Installing Gas Piping to Fireplace/Burner

System Location.......................................... 26

 ................................. 28

Electrical Installation...................................... 29

Electrical Wiring .......................................... 29

Electronic Pilot Ignition Wiring..................... 30

Remote Wall Switch .................................... 31

................................................ 32

Final Installation ............................................. 33

Rockwool Placement................................... 33

Log Placement ............................................ 33

Lava Rock and Ember Placement............... 33

................. 34

What To Do If You Smell Gas...................... 34

Lighting Pilot for the First Time.................... 35

Lighting Pilot................................................ 35

Lighting Burner............................................ 36

To Turn Off Gas........................................... 36

 37

What To Do If You Smell Gas...................... 37

Lighting Electronic Ignition ......................... 37

To Turn Off Gas........................................... 37

Cleaning and Maintenance ............................ 38

Burner, Pilot and Control Compartment ...... 38

Pilot Flame .................................................. 38

Burner Flame .............................................. 39

Vent System................................................ 39

Glass Door .................................................. 39

Logs ............................................................ 39

Rock Wool .................................................. 39

 ............................................. 40

 ......................................... 42

Firebox Components................................... 42

Standing Pilot Engine ................................. 44

Electronic IGN Engine ................................ 46

Vent Components........................................ 47

Logs ............................................................ 48

 ..................... 49

Warranty .......................................................... 51

54D0701 3

4. Neverinstallthereplace

  • inarecreationalvehicle

  • wherecurtains,furniture,clothing,orotherammable

objectsarelessthan42"fromthefront,top,orsides

ofthereplace

  • inhightrafcareas

  • inwindyordraftyareas

5. Thisreplacereacheshightemperatures.Keepchildren

andadultsawayfromhotsurfacestoavoidburnsorcloth-

ingignition.Fireplace will remainhotfora time after

shutdown.Allowsurfacestocoolbeforetouching.

6. Carefullysuperviseyoungchildrenwhentheyareinthe

roomwithreplace.

7. Donotmodifyreplaceunderanycircumstances.Any

parts removed for servicing must be replaced prior to

operatingreplace.

8. Turnreplaceoffandletcoolbeforeservicing,install-

ing,orrepairing.Onlyaqualiedservicepersonshould

install,service,orrepairthereplace.Haveburnersystem

inspectedannuallybyaqualiedserviceperson.

9. Youmustkeepcontrolcompartments,burners,andcir-

culatingairpassagesclean.Morefrequentcleaningmay

beneededduetoexcessivelintanddust.Turnoffthegas

valveandpilotlightbeforecleaningreplace.

10. Haveventingsysteminspectedannuallybyaqualied

serviceperson.Ifneeded,haveventingsystemcleaned

orrepaired.SeeCleaning and Maintenance,page32.

11. Keeptheareaaroundyourreplaceclearofcombustible

materials,gasoline,andotherammablevaporandliq-

uids.Donotrunreplacewheretheseareusedorstored.

Donotplaceitemssuchasclothingordecorationsonor

aroundreplace.

INSTALLER

Pleaseleavetheseinstructionswiththeappliance.

OWNER

Pleaseretaintheseinstructionsforfuturereference

IMPORTANT SAFETY INFORMATION

This replace is a vented product. This replace must be

properlyinstalledbyaqualiedserviceperson.Theglassdoor

mustbeproperlyseatedandsealed.Ifthisunitisnotproperly

installedbyaqualiedservicepersonwithglassdoorproperly

seatedandsealed,combustionleakagecanoccur.

CARBON MONOXIDE POISONING: Early signs of

carbonmonoxidepoisoningaresimilartotheuwithhead-

aches,dizzinessand/ornausea.Ifyouhavethesesigns,the

replacemaynothavebeeninstalledproperly.Getfreshair

atonce!Havethereplaceinspectedandservicedbyaquali-

edserviceperson.Somepeoplearemoreaffectedbycarbon

monoxidethanothers.Theseincludepregnantwomen,people

withheartorlungdiseaseoranemia,thoseundertheinuence

ofalcohol,andthoseathighaltitudes.

Propane/LPgasandnaturalgasarebothodorless.Anodor-

makingagentisaddedtoeachofthesegases.Theodorhelps

youdetectagasleak.However,theodoraddedtothesegases

canfade.Gasmaybepresenteventhoughnoodorexists.

Make certain you read and understand all warnings. Keep

thismanualforreference.Itisyourguidetosafeandproper

operationofthisreplace.

1. Thisapplianceisonlyforusewiththetypeofgasindi-

catedontheratingplate.Thisapplianceisnotconvertible

forusewithothergasesunlessacertiedkitisused.

2. Forpropane/LPreplace,donotplacepropane/LPsupply

tank(s)insideanystructure.Locatepropane/LPsupply

tank(s)outdoors.Topreventperformanceproblems,do

notusepropane/LPfueltankoflessthan100lbs.capac-

ity.

3. Ifyousmellgas

  • shutoffgassupply.

  • donottrytolightanyappliance.

  • do not touch any electrical switch; donot use any

phoneinyourbuilding.

  • immediatelycallyourgassupplierfromaneighbor’s

phone.Followthegassupplier’sinstructions. Continued on page 4

 



 

 



WARNING

4 54D0701

IMPORTANT SAFETY INFORMATION

Continued from page 3

12.Donotusethisreplacetocookfoodorburnpaperor

otherobjects.

13. Neverplaceanythingontopofreplace.

14. Donotuseanysolidfuels(wood,coal,paper,cardboard,

etc.)inthisreplace.Useonlythegastypeindicatedon

ratingplate.

15. This appliance, when installed, must be electrically

groundedinaccordancewithlocalcodesorintheabsence

oflocalcodes,withtheNational Electrical Code, ANSI/

NFPA 70,ortheCanadian Electrical Code, CSA C22.1.

16. Donotobstructtheowofcombustionandventilation

air in any way. Provide adequate clearances around

air openings into the combustion chamber along with

adequateaccessibilityclearanceforservicingandproper

operation.

17. Whentheapplianceisinstalleddirectlyoncarpeting,tile

orothercombustiblematerialotherthanwoodooring,

youmustsetapplianceonametalorwoodpanelorhearth

padextendingthefullwidthanddepthoftheappliance.

18. Donotusereplaceifanyparthasbeenexposedtoor

hasbeenunderwater.Immediatelycallaqualiedservice

persontoarrangeforreplacementoftheunit.

19. Donotoperatereplaceifanylogisbroken.

20. Donotuseablowerinsert,heatexchangerinsert,orany

otheraccessorynotapprovedforusewiththisreplace.

21. Donot operatethe replacewithglassdoorremoved,

cracked,orbroken.

IMPORTANT:

PLEASE READ THE FOLLOWING CAREFULLY

It is normal for replaces fabricated of steel to

give off some expansion and/or contraction noises

during the start up or cool down cycle. Similar

noises are found with your furnace heat exchanger

or car engine.

IMPORTANT:

PLEASE READ THE FOLLOWING CAREFULLY

It is not unusual for gas replaces to give off some

odor the rst time it is burned. This is due to the

manufacturing process.





It is recommended that you burn your replace for

at least ten (10) hours the rst time you use it. Place

the fan switch in the “OFF” position during this time.

Never connect unit to private





wellhead gas.

WARNING



We suggest that our gas hearth

products be installed and

serviced by professionals who

are certied in the U.S. by the

National Fireplace Institute®

(NFI) as Gas Specialists.

54D0701 5

PRODUCT FEATURES and CODE APPROVAL

Off/Pilot/On Knob

Optional Remote

Receiver

Figure 1 - DVB300, 400, 500, 600 Fireplace

• This appliance has been certi-

edforusewitheithernaturalor

propanegas.Seeappropriatedata

plates.

• Thisapplianceisnotforusewith

solidfuels.

• The appliance is approved for

bedroom or bedsitting room

installations.

• Theappliancemustbeinstalled

inaccordancewithlocalcodesif

any.Ifnoneexistusethecurrent

installationcode.ANSIZ223.1/

NFPA54intheUSA,CSAB149

inCanada.

• This appliance is mobile home

approved.

• Theappliancemustbeproperly

connectedtoaventingsystem.

• Theapplianceisnotapprovedfor

closetorrecessedinstallations.

The efciency rating of this appli-

anceisaproductthermalefciency

rating determined under continuous

operatingconditionsandwasdeter-

minedindependentlyofanyinstalled

system.

ThermalEfciency=upto80%

Hi/Lo Knob

PRODUCT SPECIFICATIONS

CODE APPROVAL

DirectVenttypeappliancesdrawallcombustionairfromoutsideofthedwellingthroughtheventpipe.

TheseapplianceshavebeentestedbyCSAandfoundtocomplywiththeestablishedstandardsforDIRECTVENTGAS

FIREPLACEHEATERSintheUSAandCanadaasfollows:

LISTED VENTED GAS FIREPLACE HEATER

TESTED TO: ANSI Z21.88Bb-2008/CSA 2.33b-2008 STANDARDS

Amanufacturedhome(USAonly)ormobilehomeOEMinstallationmustconformwiththeManufactured Home Con-

struction and Safety Standard, Title 24 CFR, Part 3280, orwhensuchastandardisnotapplicable,theStandard for

Manufactured Home Installations, ANSI/NCSBCS A225.1,orStandard for Gas Equipped Recreational Vehicles and

Mobile Housing, CSA Z240.4.

Blower Control

On/Off/RS Switch

Ignitor

6 54D0701

PRE-INSTALLATION INFORMATION

INSTALLING ABOVE 2000 FEET

• IntheUSA,theappliancemustbederated4%forevery1,000ftabove2,000ftelevations.

• InCanada,theseappliancesarecertiedforaltitudesof0–2000ft,andmustbede-ratedby10percentforinstallations

between2000and4,500ft.(derateanadditional4%forevery1,000ft.above4,500ft.elevations).

ORIFICE SIZES, PRESSURES AND BTUs

NATURAL GAS PROPANE GAS

ManifoldPress:(W.C.) 3.5" ManifoldPress:(W.C.) 10"

MaximumSupplyPressure 10.5" MaximumSupplyPressure 13" 

MinimumSupplyPressure 4.5" MinimumSupplyPressure 11"

    

Natural Propane Natural Propane Natural Propane Natural Propane

Max. Btu/hr Input 21,000 21,000 24,000 24,000 26,000 26,000 26,000 26,000

Min. Btu/hr Input 15,000 15,000 17,000 17,000 20,000 20,000 20,000 20,000

Orice size #43 #54 #41 #53 #40 1.55mm #40 1.55mm

BEFORE YOU START

Readthishomeownermanualthoroughlyandfollowallinstructionscarefully.Inspectallcontentsforshippingdamageand

immediatelyinformyourdealerifanydamageisfound.Donotinstallanyunitwithdamaged,incomplete,orsubstituteparts.

Checkyourpackinglisttoverifythatalllistedpartshavebeenreceived.Youshouldhavethefollowing:

• Fireplace(FireboxandBurnerSystem)

• RockWool

• LogSet

ITEMS REQUIRED FOR INSTALLATION

Tools: Building Supplies:

• PhillipsScrewdriver • FramingMaterials

• Hammer • WallFinishingMaterials

• Sawand/orsabersaw • CaulkingMaterial(Noncombustible)

• Level • FireplaceSurroundMaterial(Noncombustible)

• MeasuringTape • PipingComplyingwithLocalCodes

• ElectricDrillandBits • TeeJoint

• Pliers • PipeSealantApprovedforusewithPropane/LPG

• Square  (ResistanttoSulfurCompounds)

• PipeWrench

54D0701 7

1/2" or 5/8"

A1/2" or 5/8"

PRE-INSTALLATION INFORMATION

FIREPLACE FRAMING

Fireboxframingcanbebuiltbeforeoraftertheapplianceissetinplace.ConstructreboxframingfollowingFigure 2and

thechartbelowforyourspecicinstallationrequirements.See Figure 3 on Page 8 forreboxdimensions.Theframing

headersmayrestonthetopofthereboxstandoffs. Do not bring headers below top of standoffs.

Thereboxmaybeinstalleddirectlyonacombustibleoororraisedonaplatformofanappropriateheight.Whenthe

reboxisinstalleddirectlyoncarpeting,tile,orothercombustiblematerial,otherthanwoodooring,thereboxshallbe

installedonametalorwoodpanelextendingthefullwidthanddepthoftheenclosure.

300 400 500 600

A 331/2" 371/2" 411/2" 471/2"

B 371/4" 407/8" 407/8" 407/8"

C 281/4" 291/4" 331/4" 391/4"

D 141/8" 145/8" 165/8" 195/8"

E 5511/16" 607/8" 647/8" 707/8"

F 2713/16" 307/16" 327/16" 357/16"

G 133/4" 153/4" 153/4" 153/4"

H 393/8" 431/16" 457/8" 501/8"

Corner Installation

Stud Location

Inside Chase Installation

Recessed Installation



    



WARNING

Figure 2 - Framing Dimensions

8 54D0701

FGJ

31/2"

1/2"

81/4"

5/8"

1/2"

5/8"

1/2"5/8"1/2"

Drywall

Support

Tabs

PRE-INSTALLATION INFORMATION

Figure 3 - Fireplace Dimensions

DESCRIPTION Key Letter BDV300 BDV400 BDV500 BDV600

Overall Front Width A 331/16" 371/16" 411/16" 471/16"

Inside Width B 297/8" 32" 36" 42"

Glass Width C 27" 29" 33" 39"

CTR Pipe D 161/2" 181/2" 201/2" 231/2"

Rear Width E 28" 29" 33" 39"

Glass Height F 18" 203/8" 203/8" 203/8"

Chassis Height G 337/8" 371/2" 371/2" 371/2"

Depth H 14" 16" 16" 16"

Height to Standoffs I 37" 401/2" 401/2" 401/2"

CTR Height J 295/8" 331/8" 331/8" 331/8"

Top Face K 21/8" 11/4" 11/4" 11/4"

Side Face L 11/2" 21/2" 21/2" 21/2"

Bottom Face M 15/16" 15/16" 15/16" 15/16"

Overall Front Height N 315/8" 343/4" 343/4" 343/4"

FIREPLACE DIMENSIONS

54D0701 9

EAB

PRE-INSTALLATION INFORMATION

FIREPLACE LOCATION

Planfortheinstallationofyourappliance.Thisincludesdeterminingwheretheunitistobeinstalled,theventconguration

tobeused,framingandnishingdetails,andwhetheranyoptionalaccessories(i.e.blower,wallswitch,orremotecontrol)

aredesired.Consultyourlocalbuildingcodeagencytoensurecompliancewithlocalcodes,includingpermitsandinspec-

tions.

Thefollowingfactorsshouldbetakenintoconsideration:

• Clearancetoside-wall,ceiling,woodwork,andwindows.Minimumclearancestocombustiblesmust be maintained.

• Thisreplacemaybeinstalledalongawall,acrossacorner,oruseanexteriorchase.See Figure 4 forsuggestedloca-

tions.

• Locationshouldbeoutofhightrafcareasandawayfromfurnitureanddraperiesduetoheatfromappliance.

• Neverobstructthefrontopeningofthereplace.

• Donot installinthevicinitywheregasolineorotherammableliquidsmaybestored.

• Ventpiperouting.SeeVenting sectionfoundinthismanualforallowableventingcongurations.

• Theseunitscanbeinstalledinabedroom.SeeNationalFuelGasCodeANSIZ233.1/NFPA54—(currentedition),the

UniformMechanicalCode—(currentedition),andLocalBuildingCodesforspecicinstallationrequirements.

Figure 4 - Locating Gas Fireplace

A Flat on Wall

B Cross Corner

C Island**

D Room Divider*

E Flat on Wall Corner*

F Chase Installation

Y 4" Minimum

** Island (C) and room divider (D) installation is possible as long as the horizontal portion of vent system (X)

does not exceed 20'. See Installing Horizontal Termination Conguration on pages 18 and 19.

* When you install your replace in (D) room divider or (E) at on wall corner positions (Y), a minimum of 6"

clearance must be maintained from perpendicular wall and front of replace.

10 54D0701

12"

Maximum

Depth

11"Minimum

71"Minimum

Minimum 4"

From Both

Side Walls

Follow these instructions carefully to ensure safe installation. Failure to follow









the appliance.

WARNING

CLEARANCES

CLEARANCES TO COMBUSTIBLES

MANTEL CLEARANCES

NOTE: The combustible area above the facing must not protrude more than 3/4" from the facing. If it does,

it is considered a mantel and must meet the mantel requirements listed in this manual.

Figure 5 - Clearances

Otros manuales para 300DVB

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Chimenea de interior de Majestic

Majestic

Majestic MDVI30IN Manual de usuario

Majestic

Majestic MARQ36IN Manual de usuario

Majestic

Majestic MER36PN Manual de usuario

Majestic

Majestic SC36A Instrucciones de montaje

Majestic

Majestic SHR36 Guía de inicio rápido

Majestic

Majestic DSR36 Manual de usuario

Majestic

Majestic SA42R Manual de usuario

Majestic

Majestic Al Fresco ODSR36A Instrucciones de montaje

Majestic

Majestic MERCURY MERC32VN Manual de usuario

Majestic

Majestic 33LDVT Instrucciones de montaje

Majestic

Majestic DSR36 Manual de usuario

Majestic

Majestic WarmMajic-II Manual de usuario

Majestic

Majestic QUARTZ32IFTN Manual de usuario

Majestic

Majestic RHEDV25 Manual de usuario

Majestic

Majestic G2000piLP Manual de usuario

Majestic

Majestic SA36R Manual de usuario

Majestic

Majestic DVLINEAR36 Manual de usuario

Majestic

Majestic DVBL7 Series Manual de usuario

Majestic

Majestic 33BDVT Instrucciones de montaje

Majestic

Majestic MERCURY Series Manual de usuario

Majestic

Majestic DBT33 Manual de usuario

Majestic

Majestic NVC36 Instrucciones de funcionamiento

Majestic

Majestic DVDNV Manual de usuario

Majestic

Majestic MERCURY MERC32IN Manual de usuario

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación